2004 Yamaha Motorsports SXVenom ER Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2004 Yamaha Motorsports SXVenom ER manuals!
Problems with 2004 Yamaha Motorsports SXVenom ER?
Ask a Question
Other Models
Free 2004 Yamaha Motorsports SXVenom ER manuals!
Problems with 2004 Yamaha Motorsports SXVenom ER?
Ask a Question
Other Models
Popular 2004 Yamaha Motorsports SXVenom ER Manual Pages
Owners Manual - Page 1
SNOWMOBILE
OWNER'S MANUAL
SXV60J SXV60ERJ VT60J
LIT-12628-02-30
8EX-28199-10
Owners Manual - Page 3
... ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record and keep the ID numbers in a separate...
Owners Manual - Page 4
...snowmobiles. ESU00011
2- SXV60J SXV60ERJ VT60J OWNER'S MANUAL ©2003 by Yamaha Motor Corporation, ...manual. This manual will give you and your purchase of this snowmobile, it is expressly prohibited. To maintain the high quality and performance of this snowmobile.
is important that have any questions concerning the operation or maintenance of craftsmanship and reliability...
Owners Manual - Page 5
...avoid damage to the snowmobile. WARNING
@
PLEASE READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THE SNOWMOBILE.
@
NOTE:
@
G
G
Yamaha continually seeks advancements in this manual.
NOTE:
@
A NOTE provides key information to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile. WARNING
@
Failure to follow WARNING instructions could result...
Owners Manual - Page 6
... WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Speedometer unit ...5-4 High beam indicator light ...5-5 Fuel meter and grip/thumb warmer heat level indicator...5-5 Fuel...
Owners Manual - Page 7
... the engine...7-11 Transporting ...7-12 PERIODIC MAINTENANCE ...8-1 Periodic maintenance chart ...8-1 Tool kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-5 Throttle cable adjustment ...8-6 Oil pump cable ...replacement...8-29 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3 WIRING DIAGRAM ...12-1
Owners Manual - Page 14
... For safety and proper care of the snowmobile, always perform the pre-operation checks on public streets, roads, or...SAFETY INFORMATION
When you ride your safety. Read the Owner's Manual and all of alcohol or drugs.
5. ESU00090
3- Passengers...every time before starting the engine. Never drive the snowmobile with all labels before starting the engine.
Consult a Yamaha dealer ...
Owners Manual - Page 21
...properly. WARNING
@
G
G
A
@
If the T.O.R.S. will operate
CA-01E
Mode A Idle or Switch starting Throttle switch Off Carburetor switch On B Engine È É Ê 1 2 3 4 a b Idle or starting Run Trouble Carburetor switch Throttle switch Throttle cable Throttle valve On Off ...of the malfunction has been corrected and that the engine can be operated without a problem before restarting the...
Owners Manual - Page 24
... 1, warning light 2, and all segments of the fuel meter 3 warn the rider of the above problems by the self-diagnosis device of the heat level ... the grip/thumb warmer adjustment switches are set to the levels saved when the engine was stopped.
@
ESU00287
Fuel level warning indicator
The fuel level warning indicator indicates a malfunctioning sensor, disconnected coupler, broken lead, or short...
Owners Manual - Page 25
... come on , add engine oil to cool down, ... flash continuously in the coolant reservoir. (See page 6-2.)
CAUTION:
@
Do not operate the engine if it overheats.
@
The coolant temperature warning indicator indicates a malfunctioning sensor, disconnected coupler, broken...
s: Second
5-7 When this occurs, stop the engine immediately and allow the engine to the oil tank at the first opportunity. ...
Owners Manual - Page 26
....
@
5-8 Then, check that the wire harness couplers are connected properly in the engine compartment. ESU03970
Self-diagnosis warning indicator
The self-diagnosis warning indicator indicates a malfunctioning sensor...may be some problem with the electrical circuit, lead couplers, etc. (See page 5-9 for warning indicator and warning light flash pattern numbers 1-5.) Stop the engine and allow it...
Owners Manual - Page 35
...
@
Do not remove the coolant reservoir cap when the engine is hot.
@
CAUTION:
@
G
G
@
Hard water or salt water is not recommended. The fuel tank should be careful not to the engine parts. ESU00299
Engine oil
Make sure that snow or ice does not enter the fuel tank when refueling. Make sure that there is cold...
Owners Manual - Page 43
... INFORMATION" section carefully before starting )
NOTE:
@
The starter lever (choke) is not required when the engine is applied. Make sure that the engine stop switch is returned to the closed position.
@
Manual starting ) Half-open (warm engine up the engine until it is engaged, then pull it does not run roughly or begin to the...
Owners Manual - Page 44
... and the screwdriver handle out of the tool kit and proceed as possible to start, release the switch, wait a few seconds, then try again. Tighten the emergency starter rope on any one attempt.
@
ESU00248
Emergency engine starting
Manual starting model For SXV60ER/VT60 2. If the engine fails to preserve the battery. Electric starting model...
Owners Manual - Page 45
... half-open position. WARNING
@
Do not wind the emergency starter rope around your hand.
@
6. After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model" sections.
7-3 Warm up the engine until it does not run roughly or begin to stall when the starter lever is returned to...
Owners Manual - Page 47
...reliable snowmobile. Do not attempt to ride your snowmobile
Before you are the two basic factors of the controls. Also, read this Owner's Manual...with your snowmobile. Riding your snowmobile. With the engine idling, release the parking brake. 2. The short... the snowmobile's handling and performance characteristics.
Once it is a rider active vehicle, and your riding position and...
Owners Manual - Page 58
... this point is a medium to a light tan color for inspection and possible repairs. A
ESU01430
Tool kit
The owner's tool kit has the tools which are sufficient for that the tool kit is firmly seated in the holder and is secured with the engine. You should periodically remove and inspect the spark plug because heat and...
Owners Manual - Page 64
...will correct the air/fuel ratio. Consult a Yamaha dealer.
@
8-10
Carburetor adjustments are hard starting, bogging, and plug fouling. Common problems are the most of the problems found in high altitude riding. To overcome operating with proper carburetion. ESU00157
High altitude adjustments
Operating at high altitude reduces the performance of a gasoline engine to about 3% for...
Owners Manual - Page 85
...fuel has filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn the engine over several times with the ignition off to inspect. above . Engine constantly backfires or misfires 1. Malfunctioning T.O.R.S.
Snowmobile does not move ...Foreign object is low 1. Drive track does not move 1. V-belt twists 1. Engine... 2. Problem with the...
Owners Manual - Page 89
SPECIFICATIONS
SXV60/SXV60ER/VT60 2,780 mm (...Engine oil type Carburetor type Fuel
SXV60/SXV60ER/VT60 Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 593 cm3 65.0 × 59.6 mm (2.56 × 2.35 in) 1,600 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM31 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual with recoil starter: SXV60 Electric and manual with recoil starter: SXV60ER/VT60 Pump...
2004 Yamaha Motorsports SXVenom ER Reviews
We have not received any reviews for the 2004 Yamaha Motorsports SXVenom ER yet.