2004 Yamaha Motorsports Road Star Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2004 Yamaha Motorsports Road Star manuals!
Problems with 2004 Yamaha Motorsports Road Star?
Ask a Question
Other Models
Free 2004 Yamaha Motorsports Road Star manuals!
Problems with 2004 Yamaha Motorsports Road Star?
Ask a Question
Other Models
Popular 2004 Yamaha Motorsports Road Star Manual Pages
Owners Manual - Page 6
... check list ...4-2 OPERATION AND IMPORTANT RIDING POINTS ...5-1 Starting and warming up a cold engine ...5-1 Starting a warm engine ...5-2 Shifting ...5-3 Engine break-in ...5-4 Parking ...5-5 PERIODIC MAINTENANCE AND MINOR REPAIR ...6-1 PERIODIC MAINTENANCE ...6-1 Owner's tool kit ...6-1 Periodic maintenance chart for the emission control system ...6-3 General maintenance and lubrication chart...
Owners Manual - Page 9
...of fatalities from motorcycle accidents are some general guidelines to follow if loading cargo or adding accessories to EXCESSIVE SPEED or undercornering (insufficient lean angle for proper control. • The ... passenger footrests. Modifications may cause severe personal injury. G Never touch the engine or exhaust system during operation to your motorcycle can firmly place both feet on...
Owners Manual - Page 10
...or being passed by large vehicles. • Certain accessories can create unstable handling or...performance of non-Yamaha accessories. G Never install accessories or carry cargo that it does not in mind: G Cargo and accessory...(CAL)(HAW)(U49). Check accessory mounts and cargo restraints frequently. Accessories Genuine Yamaha accessories have been specifically designed for the proper selection...
Owners Manual - Page 11
...or engine power.
G
G
Gasoline and exhaust gas G GASOLINE IS HIGHLY FLAMMABLE: • Always turn the engine off ... electrical accessories. G Never start the engine or let it is kept upright and that the fuel cock ...accessories are not likely to spill any gasoline on your skin or clothing, immediately wash the affected area with soap and water and change your motorcycle in another vehicle...
Owners Manual - Page 21
... " " Turn signal indicator light " Neutral indicator light " " Engine trouble warning light "
Fuel level warning light " " This warning light comes on for a few seconds, then go off, have a Yamaha dealer check the selfdiagnosis system. EAU11060
Neutral indicator light " " This indicator light comes on when the transmission is equipped with a speedometer, an odometer and two...
Owners Manual - Page 24
... the engine in after the vehicle has traveled both about 150 m (490 ft) and for starting instructions prior to starting the engine. EAU12710
Start switch " " Push this switch to " " to sound the horn. The lever should be canceled manually by pushing the switch in case of the ignition circuit cut-off system. (See page...
Owners Manual - Page 25
...Brake lever
1.
The brake lever is on the right side of the 5-speed constant-mesh transmission equipped on the brake pedal.
3-6 The brake pedal is located at the right handlebar ...shift down on this motorcycle. Brake pedal
The shift pedal is located on the left side of the engine and is used in combination with the clutch lever when shifting the gears of the motorcycle. INSTRUMENT AND...
Owners Manual - Page 27
.... Always return the lever to this position, fuel will cause severe damage to internal engine parts, such as the valves and piston rings, as well as to the exhaust system. Gasohol containing ethanol can cause damage to the fuel system or vehicle performance problems.
EAU13560
Fuel cock
The fuel cock supplies fuel from the tank to use regular unleaded...
Owners Manual - Page 34
...engine when the transmission is in gear and the sidestand is still down. EWA10250
3
WARNING The vehicle must not be ridden with your foot while holding the vehicle... upright. Raise the sidestand or lower it does not function properly. G It prevents starting when the transmission is in gear and the clutch lever is pulled, but the clutch lever is noted, have a Yamaha dealer repair...
Owners Manual - Page 35
... until checked by a Yamaha dealer.
3
YES
After the engine has stalled: 10. INSTRUMENT AND CONTROL FUNCTIONS
With the engine turned off: 1.
Keep the clutch lever pulled. 8.
Shift the transmission into the neutral position. 5. Make sure that the engine stop switch is most reliable if performed with a warmed-up engine. Push the start ?
Move the sidestand down . 2. NO...
Owners Manual - Page 39
... to enable starting attempt should come on page 3-15. Turn the fuel cock lever to preserve the battery. If the sidestand is in the neutral position. Shift the transmission into the neutral position. Never start the engine or operate it could contact the ground and distract the operator, resulting in a closed area for...
Owners Manual - Page 41
... lever in and use the clutch while changing gears to avoid damaging the engine, transmission, and drive train, which are shown in . 5.
EAU16700
5
To start out and accelerate 1. The gear positions are not designed to slow the motorcycle. 2. Shift the transmission into the neutral position, press the shift pedal down repeatedly until it...
Owners Manual - Page 42
... the transmission into the neutral position when the motorcycle is brand new, do not put an excessive load on . EAU16720 EAU16841 ECA10891
Engine break-in
There is never a more important period in engine overheating must be changed, and the oil filter cartridge or element replaced. 1600 km (1000 mi) and beyond The vehicle can...
Owners Manual - Page 44
..., BUT ARE ALSO VITAL TO PROPER ENGINE OPERATION AND MAXIMUM PERFORMANCE. Periodic inspection, adjustment and lubrication will keep your vehicle in the owner's tool kit are intended to perform certain maintenance work , have a Yamaha dealer perform it for you are explained on the following pages. ESPECIALLY IMPORTANT ARE THE MAINTENANCE SERVICES RELATED TO EMISSIONS CONTROL. YAMAHA...
Owners Manual - Page 46
... Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service.
6-3 ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 ...engine idle speed. • Check for leakage. • Tighten if necessary. • Replace gasket(s) if necessary. • Check control system for the emission control system
INITIAL No. PERIODIC MAINTENANCE AND MINOR REPAIR...
Owners Manual - Page 49
...AND MINOR REPAIR
INITIAL No... months 30 months
18 *
Shock absorber assembly Rear suspension link pivots Engine oil Engine oil filter cartridge
• Check operation and for oil leakage. • Replace... these items require special tools, data and technical skills, have a Yamaha dealer perform the service. NOTE: From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000...
Owners Manual - Page 52
PERIODIC MAINTENANCE AND MINOR REPAIR
3.
NOTE: If any grime from the spark plug ...mm (0.031-0.035 in the engine have a Yamaha dealer check the vehicle. Install the spark plug with a wire thickness gauge and, if necessary, adjust the gap to diagnose such problems yourself. Measure the spark plug...kgf, 12.5 ft·lbf)
1. Do not attempt to specification. To install a spark plug 1.
Owners Manual - Page 60
... adjusted by a Yamaha dealer at the intervals specified in improper air-fuel mixture and/or engine noise. EWA11010
WARNING Tire inflation pressure should be adjusted according to total weight of cargo, rider, passenger, and accessories (windshield, saddlebags, etc. PERIODIC MAINTENANCE AND MINOR REPAIR
EAU21400 EAU21420
Adjusting the valve clearance
The valve clearance changes with use...
Owners Manual - Page 86
SPECIFICATIONS...engine oil glade: API service SE, SF, SG type or higher Engine oil quantity: Without oil filter cartridge replacement: 3.70 L (3.91 us.qt) (3.26 Imp.qt) With oil filter cartridge replacement: 4.10 L (4.33 us.qt) (3.61 Imp.qt)
Clutch:
Clutch type: Wet, multiple-disc
Transmission...(0.42 us.qt) (0.35 Imp.qt)
Weight:
With oil and fuel: XV1700A 334.0 kg (736 lb) (CAL)(U49) XV1700AS 334.0...
Owners Manual - Page 91
...a recall and remedy campaign. Department of vehicles, it may open an investigation, and if it finds that a safety defect exists in Washington, D.C. To contact NHTSA, you , your vehicle has ...a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in individual problems between...
2004 Yamaha Motorsports Road Star Reviews
We have not received any reviews for the 2004 Yamaha Motorsports Road Star yet.