2002 Yamaha Motorsports Vmax 600 ER Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2002 Yamaha Motorsports Vmax 600 ER manuals!
Problems with 2002 Yamaha Motorsports Vmax 600 ER?
Ask a Question
Other Models
Free 2002 Yamaha Motorsports Vmax 600 ER manuals!
Problems with 2002 Yamaha Motorsports Vmax 600 ER?
Ask a Question
Other Models
Popular 2002 Yamaha Motorsports Vmax 600 ER Manual Pages
Owners Manual - Page 3
... ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record and keep the ID numbers in a separate...
Owners Manual - Page 4
... SX600G VT600G VX600ERG OWNER'S MANUAL © 2001 by a company well-known for satisfactory service. Your Yamaha snowmobile is designed to acquaint you enjoy many hours of the highest quality and dependability. The most advanced production equipment and technology have the techniques, tools, and parts to inspect and repair the snowmobile whenever it is...
Owners Manual - Page 5
... SNOWMOBILE.
@
NOTE:
@
G
G
Yamaha continually seeks advancements in this manual. YOUR SAFETY IS INVOLVED! BECOME ALERT! NOTE:
@
A NOTE provides key information to make procedures easier or clearer. This manual should be taken to avoid damage to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile.
The Safety Alert Symbol means ATTENTION! If...
Owners Manual - Page 6
...WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Oil level warning light...5-3 Coolant temperature warning light ...5-4 Engine...CHECKS ...6-1 Fuel ...6-1 Engine oil...6-2 ...
Owners Manual - Page 7
... the engine...7-13 Transporting ...7-14 PERIODIC MAINTENANCE ...8-1 Periodic maintenance chart ...8-1 Tool kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-5 Throttle cable adjustment ...8-6 Oil pump cable ... replacement...8-32 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3 WIRING DIAGRAM ...12-1
Owners Manual - Page 14
... you could collide with another vehicle. 3. Do not operate the snowmobile after drinking alcohol or taking drugs. Check the throttle, brake, and steering for use the following . Never drive the snowmobile with all labels before starting the engine. ESU00009
3- Carrying a passenger can cause loss of the snowmobile, always perform the pre-operation checks...
Owners Manual - Page 15
... wash your skin with soap and water, and change your doctor immediately. Allow the engine to cool for operation of your exposure to stand behind the snowmobile when starting the engine to the operator or bystanders. 8. Never remove the fuel cap indoors. exhaust fumes are dangerous. 2. Be careful where you swallow some gasoline...
Owners Manual - Page 16
... rapid wear of dirt or sand mixed in. The best braking method on a ride. Fuel may also make the snowmobile illegal to use on surfaces other snowmobilers when going on most ... than snow or ice. Allow the engine to release the throttle and apply the brake gently-not suddenly. You may cause severe personal injury. Always ride with fuel in an enclosed space. 4. Be alert...
Owners Manual - Page 18
VT600
9 0 A B C D E F G H I J K L M N O P Q R S T U V W X Y Z
Headlight Shroud Storage compartment Tail/brake light Snow flap Side mirror (VT600 / VX600ER) Brake lever Headlight beam switch Parking brake lever Strap (MM600) Engine stop switch Throttle lever Drive select lever (VT600 / VX600ER) Starter handle Shroud latch Main switch Starter lever Thumb warmer control knob Grip warmer control ...
Owners Manual - Page 21
... been corrected and that the engine can be operated without a problem before restarting the engine. will operate
CA-01E
B
Mode A Idle or Switch starting Throttle switch Off Carburetor switch On Engine È É Ê...light
If the oil level falls below the lower level, this light comes on , add engine oil to use the specified spark plug and spark plug cap. will not work properly. ...
Owners Manual - Page 22
... flashes three times to check the bulb, and then goes off . Then, check that the wire harness couplers are no problems. (See page 5-5 for warning light flash pattern numbers 1-7.) Stop the engine and allow it to detect a malfunctioning sensor, disconnected coupler, broken lead, abnormally high coolant temperature, etc.
WARNING
@
G
G
G
If the coolant...
Owners Manual - Page 39
...engine starting )
NOTE:
@
The starter lever (choke) is not required when the engine is applied. NOTE:
@
Make sure that the parking brake is warm. After the engine... sure that the engine stop switch is in the half-open (warm engine up the engine until it does not...model For MM600 / SX600 2. Warm up ) Closed (warm engine starting ) Half-open position. Put the starter lever (choke)...
Owners Manual - Page 40
... to preserve the battery. Do not crank the engine more than 10 seconds on the screwdriver handle. 1 Screwdriver handle
7-2 After the engine starts, put the starter lever (choke) in the tool kit at the factory.
@
1. Proceed with the "Starting the engine" section items 1 and 2 for the "Manual starting model For VT600 / VX600ER 2. Tighten the emergency...
Owners Manual - Page 41
..., put the starter lever (choke) in the "Starting the engine" and "Manual starting model" sections.
7-3 WARNING
@
Avoid contact with the edge of the primary sheave assembly. ... guard and shroud. WARNING
@
Do not wind the emergency starter rope around your hand.
@
6. Warm up the engine until it does not run roughly or begin to stall when the starter lever is returned to the closed position. ...
Owners Manual - Page 43
...controls. Please read this Owner's Manual completely and understand the operation ...vehicle, and your riding position and your balance are ready to begin riding your snowmobile.
7-5 Take the time to learn the basic techniques well before attempting more reliable snowmobile. Also, read the Snowmobiler's Safety Handbook that is supplied with operating your snowmobile at maximum performance...
Owners Manual - Page 56
... a light tan color for that the tool kit is firmly seated in the holder and is secured with the engine. For example, a very white center electrode porcelain color could be something wrong with the holding band.
@
NOTE:
@
If you do not have a torque wrench available during a service operation requiring one, take the snowmobile...
Owners Manual - Page 61
... is because there is available at a Yamaha dealer carefully. Less air at high altitude reduces the performance of a gasoline engine to prevent fuel flowing. 3. Common problems are the most of elevation. Proper carburetion adjustments will correct the air/fuel ratio.
8-9 Remove the drain plug and install the proper main jet. 4. Follow the Main Jet Setting...
Owners Manual - Page 67
... while they are still hot with reverse transmissions (VT600 / VX600ER)
CAUTION:
@
Make sure that the oil is a magnet attached to remove any part of your body or clothing during inspection or repair.
@
1. It is used to the end of the drive chain housing
WARNING
@
The engine and muffler will be sure to the...
Owners Manual - Page 86
... turn the engine over with the driveline ...See H above.
9-2 "Hydrolock" occurs when fuel has filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn over several times with the correct V-belt. 2. C. Incorrect jetting for altitude or conditions ...Ask a Yamaha dealer to expel excess fuel. Incorrect V-belt clutch settings for...
Owners Manual - Page 90
ESU00228
1- SPECIFICATIONS
MM600 / SX600 / VT600 / VX600ER 2,990 mm (117.7 in): MM600 / VT600 2,760 mm (108.7 in): ...Engine oil type Carburetor type Fuel
MM600 / SX600 / VT600 / VX600ER Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 593 cm3 65.0 × 59.6 mm (2.56 × 2.35 in) 1,600 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM31 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual...
2002 Yamaha Motorsports Vmax 600 ER Reviews
We have not received any reviews for the 2002 Yamaha Motorsports Vmax 600 ER yet.