2002 Yamaha Motorsports SXViper Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2002 Yamaha Motorsports SXViper manuals!
Problems with 2002 Yamaha Motorsports SXViper?
Ask a Question
Other Models
Free 2002 Yamaha Motorsports SXViper manuals!
Problems with 2002 Yamaha Motorsports SXViper?
Ask a Question
Other Models
Popular 2002 Yamaha Motorsports SXViper Manual Pages
Owners Manual - Page 3
... ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record and keep the ID numbers in a separate...
Owners Manual - Page 4
..., and parts to inspect and repair the snowmobile whenever it is designed to acquaint you are confident that the information within this snowmobile and minor maintenance required for excellence in Japan P/N LIT-12628-02-22 SXV70G SXV70ERG OWNER'S MANUAL ©2001 by a company well-known for satisfactory service. Any reprinting or unauthorized use...
Owners Manual - Page 5
... snowmobile when resold.
@
Particularly important information is any question concerning this manual contains the most current product information available at the time of printing, there... a bystander, or a person inspecting or repairing the snowmobile. WARNING
@
PLEASE READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THE SNOWMOBILE.
@
NOTE:
@
G
G
Yamaha continually...
Owners Manual - Page 6
..., U.S.A. SNOWMOBILE LIMITED WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Speedometer unit ...5-4 High beam indicator light ...5-4 Fuel meter ...5-5 Fuel level warning...
Owners Manual - Page 12
... LABELS
2-
WARNING
This unit contains high pressure nitrogen gas. Une mauvaise manipulation peut entraîner d'explosion....AVERTISSEMENT
Cette unité contient de l'azote à haute pression. Mishandling can cause explosion. • Read owner's manual for instructions. • Do not incinerate, puncture or open. NOTE:
@
Maintain or replace safety and instruction labels...
Owners Manual - Page 13
..., you do not understand. 2. This may result if you could collide with another vehicle. 3. SXV70 and SXV70ER are prohibited. Do not operate the snowmobile after drinking alcohol ...Never drive the snowmobile with all labels before starting the engine. ESU00009
3-
Read the Owner's Manual and all of the snowmobile, always perform the pre-operation checks on public streets, roads, or ...
Owners Manual - Page 20
...will not work properly. will operate
CA-01E
Mode A Idle or Switch starting Throttle switch Off Carburetor switch On B Engine È É Ê 1 2 3 4 a b Idle or starting Run Trouble Carburetor switch Throttle switch Throttle...malfunction has been corrected and that the engine can be operated without a problem before restarting the engine. B Run On Off Run C Trouble Off Off T.O.R.S.
Owners Manual - Page 21
... the odometer mode "ODO" and the tripmeter modes "TRIP A" and "TRIP B" in the fuel tank) After the engine is started, the tachometer 1 makes one sweep, and the warning light 2 and all segments of... turn on and off if there are no problems. Odometer and tripmeter modes Pushing the select/reset button 4 switches the display between kilometers and miles, select the odometer mode "ODO", and then ...
Owners Manual - Page 23
...warning light flash continuously in the coolant reservoir. (See page 6-2.)
CAUTION:
@
Do not operate the engine if it overheats.
@
The coolant temperature warning indicator indicates a malfunctioning sensor, disconnected coupler, broken lead...problems by flashing continuously. (See the table below the minimum level, the oil level warning indicator 1 and the warning light 2 come on , add engine ...
Owners Manual - Page 24
... self-diagnosis warning indicator and warning light flash continuously during operation, there may be some problem with the electrical circuit, lead couplers, etc. (See page 5-8 for warning indicator and warning light flash pattern numbers 1-7.) Stop the engine and allow it to cool off. ESU00290
Self-diagnosis warning indicator
The self-diagnosis warning...
Owners Manual - Page 33
... water absorbing additives with straight gasoline as specified. ESU00299
Engine oil
Make sure that snow or ice does not enter the fuel tank when refueling.
Gasohol containing methanol is cold.
If...
6-2 NOTE:
@
Since the fuel tank cap and oil tank cap look similar, be careful not to the engine parts. Tap water can be filled with oxygenated fuel. Make sure that there is ...
Owners Manual - Page 41
... the "ON" position. 1 "ON"
3.
ESU00112
7-
Warm up ) Closed (warm engine starting)
NOTE:
@
The starter lever (choke) is not required when the engine is returned to the closed position.
@
Manual starting the engine. Put the starter lever (choke) in the half-open (warm engine up the engine until it is engaged, then pull it does not run...
Owners Manual - Page 42
... again. Tighten the emergency starter rope on any one attempt.
@
ESU00248
Emergency engine starting
Manual starting model For SXV70 If the recoil starter system should be as short as ..."Starting the engine" section items 1 and 2 for the "Manual starting model For SXV70ER 2. Electric starting model".
2. After the engine starts, put the starter lever (choke) in the tool kit at the ...
Owners Manual - Page 43
... not wind the emergency starter rope around your hand.
@
6.
Warm up the engine until it does not run roughly or begin to stall when the starter lever is... counterclockwise three turns on the primary sheave assembly. 5. 3. After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model" sections.
7-3 Grasp the screwdriver handle and pull briskly. ...
Owners Manual - Page 45
... attempting more reliable snowmobile. However...Getting to know your snowmobile
A snowmobile is a rider active vehicle, and your riding position and your balance are ready to...for both warmth and to start the engine. Also, read this Owner's Manual completely and understand the operation of pleasure...low speeds, even if you ride, always perform the pre-operation checks listed on your snowmobile
...
Owners Manual - Page 57
...engine. You should periodically remove and inspect the spark plug because heat and deposits will cause a spark plug to diagnose such problems...have a torque wrench available during a service operation requiring one, take the snowmobile ...engine component and is being ridden normally. ESU00142
Tool kit
The owner's tool kit has the tools which are sufficient for inspection and possible repairs...
Owners Manual - Page 63
... performance of a gasoline engine to about 3% for every 305 m (1,000 ft) of 900 m (3,000 ft). Proper carburetion adjustments will correct the air/fuel ratio. Less air at high altitude makes the air/fuel ratio too rich, which is less horsepower available, even with less power at a Yamaha dealer carefully. Common problems are the most of the problems...
Owners Manual - Page 69
...oil: API GL-3 SAE 75 or 80 È For models without reverse transmissions (SXV70) É For models with reverse transmissions (SXV70ER)
CAUTION:
@
Make sure that may accumulate in the hole.
G... any part of your body or clothing during inspection or repair.
@
1. ESU00171
Checking the oil level of the drive chain housing
WARNING
@
The engine and muffler will be sure to: G Pull it off...
Owners Manual - Page 85
... ...Ask a Yamaha dealer to inspect.
9-2 Incorrect V-belt clutch offset ...Ask a Yamaha dealer to expel excess fuel. "Hydrolock" occurs when fuel has filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn the engine over several times with the ignition off to inspect. 3. Faulty wire connections ...Check connections or ask...
Owners Manual - Page 89
... Idle speed Engine oil type Carburetor type Fuel
SXV70/SXV70ER Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 696 cm3 69.0 × 62.0 mm (2.72 × 2.44 in) 1,800 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM33 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual with recoil starter: SXV70 Electric and manual with recoil starter: SXV70ER Pump octane...
2002 Yamaha Motorsports SXViper Reviews
Do you have an experience with the 2002 Yamaha Motorsports SXViper that you would like to share?
Earn 750 points for your review!
We have not received any reviews for the 2002 Yamaha Motorsports SXViper yet.
Earn 750 points for your review!