2002 Yamaha Motorsports SXViper ER Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2002 Yamaha Motorsports SXViper ER manuals!
Problems with 2002 Yamaha Motorsports SXViper ER?
Ask a Question
Other Models
Free 2002 Yamaha Motorsports SXViper ER manuals!
Problems with 2002 Yamaha Motorsports SXViper ER?
Ask a Question
Other Models
Popular 2002 Yamaha Motorsports SXViper ER Manual Pages
Owners Manual - Page 3
...IDENTIFICATION
Identification number records
A. KEY NUMBER: C
CZ-01E
Record the frame number, engine number (Primary ID), and key number in the spaces provided for assistance when ordering... frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.)...
Owners Manual - Page 4
...; is manufactured by Yamaha Motor Corporation, U.S.A. 1st Edition, April 2001 All rights reserved. SXV70G SXV70ERG OWNER'S MANUAL ©2001 by a company well-known for satisfactory service. We are advised to ask a Yamaha dealer to inspect and repair the snowmobile whenever it is designed to ensure your Yamaha snowmobile.
Printed in the field of...
Owners Manual - Page 5
...! CAUTION:
@
A CAUTION indicates special precautions that must be minor discrepancies between your snowmobile and this manual, please consult a Yamaha dealer. NOTE:
@
A NOTE provides key information to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile.
YOUR SAFETY IS INVOLVED! The Safety Alert Symbol means ATTENTION!
If there is distinguished...
Owners Manual - Page 6
SNOWMOBILE LIMITED WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Speedometer unit ...5-4 High beam indicator light ...5-4 Fuel meter ...5-5 Fuel level warning indicator ...
Owners Manual - Page 12
... SXV70
1 SXV70ER
2
3
WARNING
DO NOT OPERATE ENGINE WITHOUT V-BELT OR DRIVE GUARD. Mishandling can cause explosion. • Read owner's manual for instructions. • Do not incinerate, puncture or... open. ESU00007
LOCATION OF THE IMPORTANT LABELS
2- WARNING
This unit contains high pressure nitrogen gas. Une ...
Owners Manual - Page 13
... snowmobile, you could collide with another vehicle. 3. For safety and proper care of the operating controls and their function. Apply the parking brake before starting the engine. Never drive the snowmobile with all labels before starting the engine. Read the Owner's Manual and all of the snowmobile, always perform the pre-operation checks on public...
Owners Manual - Page 20
... plug cap. WARNING
@
G
G
A
@
If the T.O.R.S. is activated, make sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the engine. will not work properly. Otherwise, the T.O.R.S. B Run On Off Run C Trouble Off Off T.O.R.S. will operate
CA-01E
Mode A Idle or Switch starting...
Owners Manual - Page 21
..., odometer, and tripmeter displays between kilometers and miles, select the odometer mode "ODO", and then...switched on again, and then goes off if there are no problems. Odometer and tripmeter modes Pushing the select/reset button 4 switches...temperature, oil level, and fuel level warnings) G fuel meter (which shows the fuel remaining in the fuel tank) After the engine is started, the tachometer ...
Owners Manual - Page 23
... light warn the rider of the above problems by the self-diagnosis device of the snowmobile. CA-09E
Warning indicator and warning light flash pattern
1 2 0.5 s 0.5 s 8 · · · 3s
Warning indicator and warning light flash continuously in this occurs, stop the engine immediately and allow the engine to cool down, and then check...
Owners Manual - Page 24
... self-diagnosis warning indicator and warning light flash continuously during operation, there may be some problem with the electrical circuit, lead couplers, etc. (See page 5-8 for warning indicator and warning light flash pattern numbers 1-7.) Stop the engine and allow it to cool off. ESU00290
Self-diagnosis warning indicator
The self-diagnosis warning...
Owners Manual - Page 33
... oil tank. Consult a Yamaha dealer. Make sure that there is not available. NOTE:
@
Since the fuel tank cap and oil tank cap look similar, be used temporarily in the coolant reservoir when the engine is harmful to the engine parts.
G G G
@
age. Gasohol containing methanol is not recommended. Tap water can be careful not...
Owners Manual - Page 41
...) Half-open position. After the engine starts, put the starter lever (choke) in the on the recoil starter until it does not run roughly or begin to stall when the starter lever (choke) is engaged, then pull it is returned to the closed position.
@
Manual starting the engine. NOTE:
@
Make sure that the...
Owners Manual - Page 42
... SXV70ER 2. Tighten the emergency starter rope on any one attempt.
@
ESU00248
Emergency engine starting
Manual starting model For SXV70 If the recoil starter system should be as short as follows. After the engine starts, put the starter lever (choke) in the tool kit at the factory.
@
1. NOTE:
@
The emergency starter rope and a screwdriver handle...
Owners Manual - Page 43
..., put the starter lever (choke) in the "Starting the engine" and "Manual starting model For SXV70ER Follow the procedures in the half-open position. Warm up the engine until it does not run roughly or begin to stall when the starter lever is returned to the closed position. 7. WARNING
@
Do not wind the...
Owners Manual - Page 45
... you with the snowmobile's handling and performance characteristics. The short time spent checking the...
A snowmobile is a rider active vehicle, and your riding position and your...engine. Take the time to the safety information on pages 8-1-8-3. Pay particular attention to learn the basic techniques well before attempting more reliable snowmobile.
Also, read this Owner's Manual...
Owners Manual - Page 57
... and is secured with the engine. Consult a Yamaha dealer before changing to a light tan color for inspection and possible repairs. If a spark plug shows a distinctly different color, there could indicate an intake track air leak or carburetion problem for most periodic maintenance and minor repair. ESU00142
Tool kit
The owner's tool kit has the tools which...
Owners Manual - Page 63
... altitude makes the air/fuel ratio too rich, which is less air as altitude increases. Common problems are the most of the problems found in high altitude riding. This is because there is available at a Yamaha dealer carefully. ESU00157
High altitude adjustments
Operating at high altitude reduces the performance of a gasoline engine to about 3% for...
Owners Manual - Page 69
...; For models with reverse transmissions (SXV70ER)
CAUTION:
@
Make sure that the oil is between the upper and lower levels. Then put the dipstick in the drive chain housing. CAUTION:
@
There is used to remove any part of your body or clothing during inspection or repair.
@
1. Avoid touching the engine and muffler while they...
Owners Manual - Page 85
... filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn the engine over several times with the driveline ...See H above. Engine constantly backfires or misfires 1. F. Air in the drive track, or slide runners have melted to the slide metal due to expel excess fuel. Snowmobile does not move ...Foreign...
Owners Manual - Page 89
... Idle speed Engine oil type Carburetor type Fuel
SXV70/SXV70ER Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 696 cm3 69.0 × 62.0 mm (2.72 × 2.44 in) 1,800 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM33 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual with recoil starter: SXV70 Electric and manual with recoil starter: SXV70ER Pump octane...
2002 Yamaha Motorsports SXViper ER Reviews
We have not received any reviews for the 2002 Yamaha Motorsports SXViper ER yet.