2002 Yamaha Motorsports SX600 Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2002 Yamaha Motorsports SX600 manuals!
Problems with 2002 Yamaha Motorsports SX600?
Ask a Question
Other Models
Free 2002 Yamaha Motorsports SX600 manuals!
Problems with 2002 Yamaha Motorsports SX600?
Ask a Question
Other Models
Popular 2002 Yamaha Motorsports SX600 Manual Pages
Owners Manual - Page 3
...CZ-01E
C. A
ESU00286
1- KEY NUMBER: C
CZ-01E
Record the frame number, engine number (Primary ID), and key number in the spaces provided for assistance when ordering spare...1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, ...
Owners Manual - Page 4
... are advised to ask a Yamaha dealer to inspect and repair the snowmobile whenever it is designed to ensure your Yamaha snowmobile.
they have made Yamaha one of our customers. INTRODUCTION
Congratulations! ESU00001
1- Your Yamaha snowmobile is expressly prohibited. MM600G SX600G VT600G VX600ERG OWNER'S MANUAL © 2001 by a company well-known for satisfactory service.
Owners Manual - Page 5
... be taken to avoid damage to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile.
The Safety Alert Symbol means ATTENTION! CAUTION:
@
A CAUTION indicates special precautions that must be minor discrepancies between your snowmobile and this manual, please consult a Yamaha dealer.
NOTE:
@
A NOTE provides key information to make procedures easier...
Owners Manual - Page 6
...WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Oil level warning light...5-3 Coolant temperature warning light ...5-4 Engine...CHECKS ...6-1 Fuel ...6-1 Engine oil...6-2 ...
Owners Manual - Page 7
... the engine...7-13 Transporting ...7-14 PERIODIC MAINTENANCE ...8-1 Periodic maintenance chart ...8-1 Tool kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-5 Throttle cable adjustment ...8-6 Oil pump cable ... replacement...8-32 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3 WIRING DIAGRAM ...12-1
Owners Manual - Page 14
... to carry the OPERATOR ONLY. Apply the parking brake before starting the engine. Never drive the snowmobile with another vehicle. 3. This may result if you ignore any control or function you ...operating 1. Read the Owner's Manual and all of the following for use the following . Carrying a passenger can cause loss of the snowmobile, always perform the pre-operation checks on ...
Owners Manual - Page 15
... spills on established trails to minimize your doctor immediately. G Use an approved fuel container.
7. Do not allow anyone to stand behind the snowmobile when starting the engine to cool for operation of the building. Handle fuel with extreme care. G Fill the fuel tank outdoors with care; G Make sure that will permit use of an...
Owners Manual - Page 16
... than snow or ice. Operation under such conditions will damage or result in . Always ride with fuel in an enclosed space. 4. Many surfaces such as necessary.
3-3 Always refer to the "STORAGE"...alert, plan ahead and begin decelerating early. Do not leave the snowmobile on a ride. Allow the engine to use that may need help if you run out of time. You may cause severe personal ...
Owners Manual - Page 18
VT600
9 0 A B C D E F G H I J K L M N O P Q R S T U V W X Y Z
Headlight Shroud Storage compartment Tail/brake light Snow flap Side mirror (VT600 / VX600ER) Brake lever Headlight beam switch Parking brake lever Strap (MM600) Engine stop switch Throttle lever Drive select lever (VT600 / VX600ER) Starter handle Shroud latch Main switch Starter lever Thumb warmer control knob Grip warmer control ...
Owners Manual - Page 21
... Run
C
ESU00026
Oil level warning light
If the oil level falls below the lower level, this light comes on , add engine oil to use the specified spark plug and spark plug cap. B Run On Off Run C Trouble Off Off T.O.R.S. will not...on . is activated, make sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the...
Owners Manual - Page 22
... page 5-5 for warning light flash pattern numbers 1-7.) Stop the engine and allow it to cool off if there are connected properly in the engine compartment and that the wire harness couplers are no problems. (See page 5-5 for warning light flash patterns.) After the engine starts, this light flashes three times to detect a malfunctioning sensor...
Owners Manual - Page 39
... run roughly or begin to stall when the starter lever (choke) is in the closed position.
7-1
Make sure that the engine stop switch is returned to the closed position.
@
Manual starting the engine. Turn the main switch to check the "SAFETY INFORMATION" section carefully before starting model For MM600 / SX600 2. Warm up ) Closed...
Owners Manual - Page 40
... starter rope on any one attempt.
@
ESU00248
Emergency engine starting
Manual starting model For MM600 / SX600 If the recoil starter system should be as short as follows. Each attempt should fail, take the emergency starter rope and the screwdriver handle out of the tool kit and proceed as possible to start, release the...
Owners Manual - Page 41
Grasp the screwdriver handle and pull briskly. Warm up the engine until it does not run roughly or begin to stall when the...starting model For VT600 / VX600ER Follow the procedures in the half-open position. After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model" sections.
7-3 WARNING
@
Avoid contact with the edge of the primary sheave ...
Owners Manual - Page 43
...Also, read this Owner's Manual completely and understand the operation...engine. Take the time to ride your snowmobile requires skills acquired through practice over a period of maneuvering your snowmobile. However, it has warmed up, you ride, always perform the pre-operation checks listed on your snowmobile.
7-5 Learning to learn the basic techniques well before attempting more reliable...
Owners Manual - Page 56
...
If you do not have a torque wrench available during a service operation requiring one, take the snowmobile to a Yamaha dealer for that ...problems yourself. The ideal coloration at this point is a medium to a light tan color for most periodic maintenance and minor repair. Consult a Yamaha dealer before changing to a different type of the engine. A
ESU00143
Tool kit
The owner's tool kit...
Owners Manual - Page 61
...air means less oxygen available for every 305 m (1,000 ft) of the problems found in the holder and throttle operates smoothly after assembling the carburetor.
@
...fuel hose to overcome most important. Your snowmobile can cause poor performance. Less air at high altitude makes the air/fuel ratio too rich, which is available at high altitude reduces the performance of a gasoline engine...
Owners Manual - Page 67
... Drive chain oil: API GL-3 SAE 75 or 80 È For models without reverse transmissions (MM600 / SX600) É For models with any metal particles that no foreign material ...repair.
@
1. Remove the dipstick 1 and wipe it out slowly and gently so the metal particles do not fall off with a clean rag. Avoid touching the engine and muffler while they are still hot with reverse transmissions...
Owners Manual - Page 86
...to inspect. 3. Incorrect V-belt clutch settings for altitude or temperature ...Carburetor. E. Malfunctioning T.O.R.S. B. Engine trouble ...Check B above . Incorrect jetting for altitude or conditions ...Ask a Yamaha dealer to inspect. "Hydrolock" occurs when fuel has filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn over several times with...
Owners Manual - Page 90
SPECIFICATIONS
MM600 / SX600 / VT600 / VX600ER 2,990 mm (117.7 in): MM600 / VT600 2,760 mm (108.7 in): SX600 2,780...Engine oil type Carburetor type Fuel
MM600 / SX600 / VT600 / VX600ER Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 593 cm3 65.0 × 59.6 mm (2.56 × 2.35 in) 1,600 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM31 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual ...
2002 Yamaha Motorsports SX600 Reviews
We have not received any reviews for the 2002 Yamaha Motorsports SX600 yet.