2002 Yamaha Motorsports Road Star Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2002 Yamaha Motorsports Road Star manuals!
Problems with 2002 Yamaha Motorsports Road Star?
Ask a Question
Other Models
Free 2002 Yamaha Motorsports Road Star manuals!
Problems with 2002 Yamaha Motorsports Road Star?
Ask a Question
Other Models
Popular 2002 Yamaha Motorsports Road Star Manual Pages
Owners Manual - Page 11
... when adding cargo or accessories to your motorcycle:
1-3
Never touch the engine or exhaust system during or after operation. Loading and accessories
Adding accessories or cargo to your motorcycle...fatalities from motorcycle accidents are some general guidelines to follow if loading cargo or adding accessories to an impairment of a jacket, heavy boots, trousers, gloves, etc., is the...
Owners Manual - Page 13
...ability, therefore, such accessories are not recommended. 2. Bulky or large accessories may also cause instability when passing or being passed by large vehicles. b. Never refuel ...accessories. Accessories fitted to a minimum. This improper position limits the freedom of movement of time in the vicinity of lights or engine power.
1
Gasoline and exhaust gas
1. Always turn the engine...
Owners Manual - Page 14
... motorcycle in another vehicle, make sure that it should swallow any gasoline spills on a slope or soft ground, otherwise it could catch fire. 4. a kerosene heater, or near a flammable source (e.g. If it is kept upright and that the fuel cock is turned to "ON" or "RES" (for vacuum type) / "OFF" (for manual type). If...
Owners Manual - Page 25
...
3
Indicator and warning lights
EAU00079
Neutral indicator light " " This indicator light comes on when the transmission is defective. EAU00057
1. 2. 3. 4. 5.
Engine trouble warning light " " This warning light comes on or flashes when an electrical circuit monitoring the engine is in the neutral position.
EAU00091
Fuel level warning light " " This warning light comes on when the...
Owners Manual - Page 29
...also be canceled manually by pushing the switch in case of an emergency, such as when the motorcycle overturns or when the throttle cable is stuck. Start switch " " / "
EAU03890
1. Engine stop switch " .... Turn signal switch " 3. When released, the switch returns to starting the engine.
INSTRUMENT AND CONTROL FUNCTIONS
Since this model is equipped with the starter.
EAU04078
...
Owners Manual - Page 30
...clutch lever is equipped with the clutch lever when shifting the gears of the 5-speed constant-mesh transmission equipped on the left handlebar grip. To disengage the clutch, pull the lever toward the handlebar...lever
The brake lever is used in combination with a clutch switch, which is part of the engine and is located at the left side of the ignition circuit cut -off system. (See page ...
Owners Manual - Page 32
...fuel. CAUTION: Use only unleaded gasoline. Fill the fuel tank to the fuel system or vehicle performance problems.
_
WARNING ● Do not overfill the fuel... Yamaha engine has been designed to the engine internal parts such as shown. Fuel level
EAU03753
Fuel
Make sure... FUNCTIONS
EAU00185
CAUTION: Immediately wipe off spilled fuel with a pump octane number [(R+M)/2] of 86 or higher, ...
Owners Manual - Page 40
...in certain situations. (See further down . EW000045
WARNING If a malfunction is noted, have a Yamaha dealer repair it if it with the sidestand down, or if the sidestand cannot be properly moved up (or does...lever is pulled, but the sidestand is still down. ● It cuts the running engine when the transmission is in gear and the sidestand is part of the frame. Raise the sidestand or...
Owners Manual - Page 41
... motorcycle should not be ridden until checked by a Yamaha dealer. Shift the transmission into the neutral position. 5. Does the engine start switch. YES
NO
The clutch switch may be defective. The system is most reliable if performed with a warmed-up engine. YES
With the engine still running: 6. Move the sidestand up . 11.
Keep the clutch lever...
Owners Manual - Page 46
...function that you do not thoroughly understand. ● Never start the engine or operate it could contact the ground and distract the operator, resulting...9679; The transmission is not raised completely, it in a possible loss of time.
OPERATION AND IMPORTANT RIDING POINTS
●
EAU00372
Before starting , one of the following conditions must be blocked and performance will suffer. ...
Owners Manual - Page 47
... the starter (choke) knob back halfway.
5-2
NOTE: The engine is in the halfway position.
@ @
5 NOTE: If the engine fails to preserve the battery. To avoid the possibility of starter (choke) use depends upon the ambient temperature. Shift the transmission into the neutral position. Turn the fuel cock lever to the throttle with the starter...
Owners Manual - Page 48
... distances. The gear positions are not designed to withstand the shock of its travel, and then slightly raise it.
@ @
5-3 Inadequate lubrication may damage the transmission. ● Always use the clutch while changing gears to avoid damaging the engine, transmission, and drive train, which are shown in the illustration.
@
CAUTION: ● Even with the...
Owners Manual - Page 49
...mi/h (km/h)
Deceleration shift point mi/h (km/h)
EAU00427
To decelerate 1. Shift the transmission into the neutral position.) 6. OPERATION AND IMPORTANT RIDING POINTS
EAU02988* EAU02974
To start out... clutch lever. 7. Shift the transmission into first gear. NOTE: Always shift gears at the same time, release the clutch lever slowly. 4. If the engine is almost completely stopped. Open ...
Owners Manual - Page 52
... the spark plugs ...6-8 Canister (for California only) ...6-9 Engine oil and oil filter cartridge ...6-9 Transfer case oil ...6-13 Cleaning the air filter element ...6-15 Adjusting the carburetor ...6-17 Adjusting the throttle cable free play ...6-17 Adjusting the valve clearance ...6-17 Tires...6-18 Spoke wheels ...6-20 Accessories and replacement parts ...6-20 Adjusting the clutch lever...
Owners Manual - Page 55
... for cracks or damage. • Replace if necessary. • Check fuel hose for cracks or damage. • Replace if necessary. •... and adjust engine idle speed. • Adjust cable free play. • Check control system for the emission control system
No. PERIODIC MAINTENANCE AND MINOR REPAIR
EAU00471
Periodic ... and technical skills, have a Yamaha dealer perform the service.
6-3
Owners Manual - Page 56
...8730;
Check
√
√
Replace
√
7
• Check vehicle for looseness. • Moderately repack every 16,000 mi (25,000 km...PERIODIC MAINTENANCE AND MINOR REPAIR
EAU00472
General maintenance and ...data and technical skills, have a Yamaha dealer perform the service. 6-4 ITEM ROUTINE TYPE INITIAL 600 mi (1,... km) or 30 months
1 2 3
Engine oil
• Replace • Replace •...
Owners Manual - Page 60
...wrench is not available when installing a spark plug, a good estimate of the engine.
6 PERIODIC MAINTENANCE AND MINOR REPAIR
The porcelain insulator around the center electrode of each spark plug should be a ... and, if necessary, adjusted to specification. Instead, have the same color. However, the spark plug should be tightened to diagnose such problems yourself. In addition, the condition ...
Owners Manual - Page 70
... kPa
EAU01846
Tires
To ensure maximum performance, long service, and safe operation, note the following: Tire air pressure Always check and adjust the tire pressure before operating the motorcycle. Operation of an overloaded motorcycle could cause tire damage, an accident, or even injury.
_
* Total weight of rider, passenger, cargo and accessories
EWA00012
6
WARNING Tire inflation pressure...
Owners Manual - Page 107
... you believe that a safety defect exists in individual problems between you may order a recall and remedy campaign. area) or write to notifying Yamaha Motor Corporation, U.S.A. Department of vehicles, it finds that your dealer, or Yamaha Motor Corporation, U.S.A. You can also obtain other information about motor vehicle safety from the Hotline.
9
9-3 However, NHTSA cannot become...
Owners Manual - Page 115
...Accessories and replacement parts ...6-20 Air filter element, cleaning ...6-15
E
Engine break-in ...5-5 Engine oil and oil filter cartridge ...6-9 Engine stop switch...3-6 Engine...checking ...6-30 Fuel ...3-9 Fuel cock...3-10 Fuel gauge ...3-4 Fuel level warning light ...3-2 Fuel tank cap...3-8... ...6-29 Spark plugs, checking ...6-8 Specifications...8-1 Speedometer unit...3-3 Starter (choke) knob...
2002 Yamaha Motorsports Road Star Reviews
Do you have an experience with the 2002 Yamaha Motorsports Road Star that you would like to share?
Earn 750 points for your review!
We have not received any reviews for the 2002 Yamaha Motorsports Road Star yet.
Earn 750 points for your review!