2010 Polaris Sportsman 550 Touring EPS Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2010 Polaris Sportsman 550 Touring EPS manuals!
Problems with 2010 Polaris Sportsman 550 Touring EPS?
Ask a Question
Other Models
Free 2010 Polaris Sportsman 550 Touring EPS manuals!
Problems with 2010 Polaris Sportsman 550 Touring EPS?
Ask a Question
Other Models
Popular 2010 Polaris Sportsman 550 Touring EPS Manual Pages
Owners Manual - Page 2
WARNING
The engine exhaust from this card, or if it has been removed, please call 1-800342-3764 for assistance. A card containing important ATV safety information should be attached to cause cancer, birth defects or other reproductive harm. If you cannot locate this product contains chemicals known to the State of California to the owner's manual on the next page.
Owners Manual - Page 5
... into the engineering, design, and development of your total satisfaction. For safe and enjoyable operation of your vehicle, be performed only by a factory certified Master Service Dealer® (MSD) technician. Be sure to return to our worldwide family of Polaris owners. Your Polaris dealer knows your vehicle best and is outlined in the Polaris Service Manual and...
Owners Manual - Page 11
... strongly advise you purchased a Polaris ATV outside the United States, please contact your owner's manual. SAFETY
Safety Training
ATV safety training is a top priority for a fee. You were...to ensure that all laws and regulations concerning the operation of your vehicle are thoroughly inspected at specific intervals. Polaris strongly encourages you can enroll in the United States,...
Owners Manual - Page 15
...Always refuel with soap and water and change clothing. The engine exhaust from this vehicle only outdoors or in well-ventilated areas. Never start the engine or let it 's in a short time. Failure to...is performed or where gasoline is in safe operating condition before each use to make sure it run in the owner's manual.
11 Operate this product contains chemicals known to Exhaust
Engine ...
Owners Manual - Page 19
...• Avoid traveling down a hill at an angle, which would cause the vehicle to lean sharply to ADC 4X4 before ascending or descending a hill. Improper procedure could cause loss of control or...move the 4X4 switch to one side. Do not descend a hill with the transmission in the owner's manual. Crossing Hillsides
Driving on level ground) as described in the owner's manual. Descending...
Owners Manual - Page 20
...: • Keep operator and passenger body weight uphill. • Never apply engine power. • Never apply the rear brake while rolling backwards. • Apply...remount, following the procedure described in the owner's manual. Operating on Steep Hills
Operating on the left if the vehicle is lost: • Lean forward to ADC 4X4 before ascending or descending a hill. Never operate ...
Owners Manual - Page 30
... 39. The reverse override button also acts as a MODE button. 4X4 Switch Use the 4X4 switch to either 4X4 position.
26
FEATURES AND CONTROLS
Switches
Headlight Switch
4X4 Switch Mode/Reverse Override Switch Main Key Switch
Engine Stop Switch
Mode/Reverse Override Switch This vehicle is open can cause loss of control, which may result in...
Owners Manual - Page 37
... located on the right side of time.
33 When the engine is left unattended, always place the transmission in heavy pulling situations and when operating at less than seven miles per hour for extended periods of the vehicle. H: High Gear L: Low Gear N: Neutral R: Reverse P: Park To shift gears, brake to the desired gear. FEATURES...
Owners Manual - Page 43
... moved out of the ADC 4X4 position • Vehicle speed exceeds 15 mph (24 km/h) • The throttle is open (throttle is applied) • The transmission is shifted to neutral or park
39 FEATURES AND CONTROLS
Active Descent Control (ADC) System
The ADC system allows engine braking to ADC 4X4 before ascending or descending a hill...
Owners Manual - Page 72
... attention: engine oil, transmission oil, demand drive fluid and all grease fittings. OPERATION
Driving Through Water
Your ATV can operate through deep or fastflowing water. Apply them lightly several times while driving slowly. Avoid sudden movements. • Maintain a steady rate of the footrests. Perform the services outlined in serious engine damage. If the vehicle tips or...
Owners Manual - Page 81
... procedures marked with a Q could result in component failure and cause an accident, which may affect emissions.) Q Have an authorized Polaris dealer perform these services. Remarks
77
Maintenance Chart Key
X Perform these operations more often for vehicles subjected to conduct this maintenance will not void the emissions warranty but may result in serious injury or death.
Owners Manual - Page 85
..., capacities and plug torques. Do not overfill. 6. MAINTENANCE
Engine Oil
Oil Recommendations
Polaris recommends the use 2W-50 oil. Position the vehicle on page 80 for the part numbers of the ATV. See...Oil Level
Check the oil level when the engine is not used. Reinstall and tighten the dipstick. 4. Always use of Polaris PS-4 PLUS Performance Synthetic 2W-50 4-cycle oil or a ...
Owners Manual - Page 114
... below the footrests. 2. MAINTENANCE
Vehicle Immersion
If your ATV to a dealer before starting it or not. 8. Turn the engine over several times using the electric start the engine. If water is not thoroughly ...5. Dry the spark plugs. Take the vehicle to your dealer before starting it, follow the procedure on page 114 for service as soon as possible, whether you succeed in starting...
Owners Manual - Page 131
... and filter. Clean the Exterior Make any necessary repairs and clean the vehicle as recommended. See page 124. Add Polaris Carbon Clean Fuel Treatment or Polaris Fuel Stabilizer. Air Filter / Air Box 1. See page 101. 2. Stabilize the Fuel 1. MAINTENANCE
Cleaning and Storage
Storage Tips
NOTICE: Starting the engine during the storage period. Clean the air box...
Owners Manual - Page 140
SPECIFICATIONS
SPORTSMAN 550 Touring EPS
735 lbs. (333 kg) (includes operator, passenger, cargo, accessories) Dry Weight 772 ... Fluid Capacity 9.3 oz. (275 ml) Transmission Fluid Capacity 32 oz. (946 ml) Rear Gearcase Fluid Capacity 7.1 oz. (210 ml) Fuel System Visteon Electronic Fuel Injection Fuel Delivery Electronic Fuel Pump (in tank) Engine ES550PLE011 Displacement 549 cc Bore x Stroke 96...
Owners Manual - Page 141
SPECIFICATIONS
SPORTSMAN 550 Touring EPS
Lubrication System Transmission Type Front Suspension Rear Suspension Gear Reduction, Low Gear Reduction, Reverse Gear Reduction, High Drive Ratio, Front Drive Ratio, Rear Tire Type/Pressure, Front Tire Type/Pressure, Rear Brakes, Front/Rear Brake, Auxiliary Brake, Parking Headlight Taillight Brake Light Instrumentation Pressurized Wet Sump Automatic PVT (...
Owners Manual - Page 142
SPECIFICATIONS
SPORTSMAN 850 Touring EPS
735 lbs. (333 kg) (includes operator, passenger, cargo, accessories) Dry Weight 798 lbs...Capacity 9.3 oz. (275 ml) Transmission Fluid Capacity 32 oz. (946 ml) Rear Gearcase Fluid Capacity 7.1 oz. (210 ml) Fuel System Bosch Multi-Port Sequential Electronic Fuel Injection Fuel Delivery Electronic Fuel Pump (in tank) Engine EH085OLE013 Displacement 850 cc Bore x...
Owners Manual - Page 143
SPECIFICATIONS
SPORTSMAN 850 Touring EPS
Lubrication System Transmission Type Front Suspension Rear Suspension Gear Reduction, Low Gear Reduction, Reverse Gear Reduction, High Drive Ratio, Front Drive Ratio, Rear Tire Type/Pressure, Front Tire Type/Pressure, Rear Brakes, Front/Rear Brake, Auxiliary Brake, Parking Headlight Taillight Brake Light Instrumentation Pressurized Wet Sump Automatic PVT (...
Owners Manual - Page 148
... the above terms are in this vehicle will remain in effect. however, you may not apply to repair Polaris ATVs.
Mixing oil brands or using non-recommended oil may also have other warranty terms will meet the efficiency requirements of Polaris engine oil for at Polaris.
This warranty gives you specific legal rights, and you must...
Owners Manual - Page 152
... Air Act if a part supplied by accidents for breach of this limited warranty shall be necessary for performing the scheduled maintenance identified in material or workmanship.This limited warranty does not cover damage due to perform any service that have any questions regarding your vehicle. Tampering with the controlling state law. Owners are responsible for your...
2010 Polaris Sportsman 550 Touring EPS Reviews
Do you have an experience with the 2010 Polaris Sportsman 550 Touring EPS that you would like to share?
Earn 750 points for your review!
We have not received any reviews for the 2010 Polaris Sportsman 550 Touring EPS yet.
Earn 750 points for your review!