2010 Polaris RZR 170 Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2010 Polaris RZR 170 manuals!
Problems with 2010 Polaris RZR 170?
Ask a Question
Other Models
Free 2010 Polaris RZR 170 manuals!
Problems with 2010 Polaris RZR 170?
Ask a Question
Other Models
Popular 2010 Polaris RZR 170 Manual Pages
Owners Manual - Page 3
WARNING
The engine exhaust from this product contains chemicals known to the State of California to follow all product labels. WARNING
Read, understand, and follow the safety precautions could result in this manual and on all of the instructions and safety precautions in serious injury or death.
Failure to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 11
... Number (left rear wheel well)
####
Key Number
Vehicle Model Number: _____ Vehicle Identification Number: _____ Engine Serial Number: _____ Key Number _____
8 The ignition switch must be duplicated only by ... the spare key and store it with one of your existing keys. INTRODUCTION
Vehicle Identification Numbers
Record your vehicle's identification numbers and key number in a safe place.
Owners Manual - Page 16
...Accessories
Installing non-approved accessories may seriously affect vehicle handling and stability, which could result in the event of an accident. Safety Warnings
SAFETY
Failure to Inspect Before Operating
Failure to make sure the seat belts are secured for use on this vehicle...inspect the vehicle before each use the cab nets and side guards while riding in the owner's manual. Operator ...
Owners Manual - Page 19
... could cause loss of control or overturn. Always follow proper procedures for hill climbing as described in the owner's manual. • Always drive down a hill with the transmission in the owner's manual. Never operate the vehicle on hills steeper than 15 degrees. • Always check the terrain carefully before driving down a hill. • Never...
Owners Manual - Page 20
Maintain a steady speed when climbing a hill.
Avoid crossing the side of control or overturn. Place the transmission in the owner's manual. If crossing a hillside is unavoidable, always follow proper procedures as described in reverse and slowly allow the vehicle to roll straight downhill while applying light brake pressure to control speed. Safety Warnings
SAFETY...
Owners Manual - Page 26
... labels. • with non-Polaris approved accessories - LOCATE AND READ OWNER'S MANUAL. WARNING Operation of this vehicle. Adult supervision required for the operator's skills...TIRE PRESSURE IN PSI (KPa): Front: 3 (20.7) Rear: 3 (20.7) MAXIMUM WEIGHT CAPACITY 300 lbs. (136 KG) INCLUDES WEIGHT OF OPERATOR, PASSENGER AND ACCESSORIES. WARNING VEHICLE OVERTURN could enter vehicle. The cab...
Owners Manual - Page 35
....
32 Electrical circuits are off . The key returns to start the engine. See page 40 for starting a cold engine. Electrical equipment can be used. Use the ignition switch to the ON... position to the engine starting procedure on .
FEATURES AND CONTROLS
Ignition Switch
The ignition switch is in starting procedures. OFF ON START The engine is off , except accessory 12V. Refer to...
Owners Manual - Page 36
... unattended. Always be sure to the desired gear. Stop the engine. 4. Operating the vehicle while the parking brake is moving . See your dealer if you experience any shifting problems. NOTICE: Do not attempt to the transmission could cause an accident resulting in driveline or engine damage. It could also result in serious injury or death...
Owners Manual - Page 39
... to operate the vehicle properly can result in period for these components.
NOTICE: Excessive heat build-up during the first three hours of this owner's manual. Mixing brands or using a non-recommended oil may result in serious injury or death. Careful treatment of operation will result in more efficient performance and longer life...
Owners Manual - Page 42
...this vehicle. 9. Do not touch hot exhaust system components. Engine exhaust fumes are designed for possible damage. 11. Drive in an enclosed area. Never start the engine or...at excessive speeds. Never install accessories not approved by a supervising adult. Never operate the vehicle on pavement or on a frozen body of tires specified for your vehicle. Always use .
39 ...
Owners Manual - Page 51
... it 's impossible to bring the vehicle to your dealer before starting the engine, perform the service outlined on page 79, and take the vehicle to your dealer as soon as possible...vehicle can result if the vehicle is not thoroughly inspected after operation in water. See page 53. Follow these precautions when driving through water, test the brakes. If it to engine oil, transmission...
Owners Manual - Page 58
... the vehicle. adjust and lubricate if needed Drain water as needed Check operation Inspect daily; clean often; test Inspect level; Remarks
Miles (Km) 100 (160) 100 (160) 100 (160) 250 (400) 250 (400) Inspect; change (break-in) Drive chain (break-in wet conditions Inspect; E Emission-Related Service Q Have an authorized Polaris dealer perform these...
Owners Manual - Page 59
...
Remarks
Miles (Km) 150 (250) 300 (480) 500 (800) 300 (480) 500 (800) 500 (800) 500 (800 500 (800) 500 (800) 500 (800) 500 (800) Inspect; MAINTENANCE
Item
Periodic Maintenance Chart
Maintenance Interval
(whichever comes first) Hours Calendar X Engine breather E filter (if equipped) X Engine oil change at tank cap, lines, fuel valve, filter, pump, carburetor...
Owners Manual - Page 60
... fluid
Spark arrestor Idle speed
Q Toe adjustment
X Perform these services
57 E Emission-Related Service Q Have an authorized Polaris dealer perform these procedures more often for wear, routing, security;... Engine mounts Exhaust muffler/ pipe
Q Ignition timing
MAINTENANCE
Remarks
Miles (Km) 1000 (1600) Inspect 1000 (1600) Inspect 1000 (1600) Inspect 1000 (1600) Inspect for vehicles ...
Owners Manual - Page 69
...a high speed. See your dealer for service as soon as the owner, you have ...manual. • This CVT system is accidently ingested into the CVT system. NOTICE: Exposure to salt water will cause the system to ensure the safety of the CVT system. Allow the water to metal components. Take the vehicle to neutral. Any modification will cause corrosion to drain. Shift the transmission...
Owners Manual - Page 72
... Inspection
1. Place the transmission in neutral. Set the parking brake. 2. Measure the distance the throttle pedal moves before starting the engine and occasionally during operation....vehicle if it to pick up thoroughly. 3. Immediately contact your dealer for free movement and return before the engine begins to warm up speed. Always check the pedal for service if throttle problems...
Owners Manual - Page 82
... page 67. 4. Turn the fuel valve on page 66 for service as soon as possible, whether you succeed in starting it, follow the procedure on . Take the vehicle to a dealer before starting the engine. If it or not. 12. Attempt to dry land. 2. If water has been ingested into the transmission follow the steps outlined...
Owners Manual - Page 104
... Fuel Sealants Hotel fees Towing charges Mileage Rentals/Loss of product use of materials or workmanship. improper engine timing; improper component alignment, tension, adjustment or altitude compensation; modified components; THE REMEDIES SET FORTH IN THIS WARRANTY ARE THE ONLY REMEDIES AVAILABLE TO ANY PERSON FOR BREACH OF THIS WARRANTY. Batteries (unless defective) Cosmetic damage/repair...
Owners Manual - Page 106
... not apply to country. This policy does not apply to determine this vehicle's warranty or service bulletin coverage if you should consult an authorized dealer to vehicles that have any kind. (Vehicles registered to perform the warranty repair. This policy does not apply to vehicles registered to Get Service
In the Country where your new country. How to government officials...
Owners Manual - Page 108
... at the exclusive option of Polaris, repair or replacement of God. This limited warranty also does not cover physical damage, corrosion or defects caused by accidents for performing the scheduled maintenance identified in material or workmanship.This limited warranty does not cover damage due to perform any engine that may be , at 1-888-704-5290.
105...
2010 Polaris RZR 170 Reviews
We have not received any reviews for the 2010 Polaris RZR 170 yet.