2005 Polaris 900 Switchback Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2005 Polaris 900 Switchback manuals!
Problems with 2005 Polaris 900 Switchback?
Ask a Question
Other Models
Free 2005 Polaris 900 Switchback manuals!
Problems with 2005 Polaris 900 Switchback?
Ask a Question
Other Models
Popular 2005 Polaris 900 Switchback Manual Pages
Owners Manual - Page 3
WARNING
The engine exhaust from this manual and on which contain chemicals known to the State of the instructions and safety precautions in... of California to cause cancer and birth defects or other reproductive harm. PROPOSITION 65 WARNING
Snowmobile engines discharge fuel and exhaust, which they operate. Keep this engine properly tuned and avoid unnecessary idling and spillage during...
Owners Manual - Page 6
... service needs during, and after, the warranty period. Have your accessories and clothing delivered right to your dealership for all utility and recreational vehicles manufactured in the world today. WELCOME
Thank you for purchasing a Polaris vehicle, and welcome to follow the instructions and recommendations in this owner's manual. Many years of experience have gone into the engineering...
Owners Manual - Page 8
...section describes safe vehicle operation and identifies warning decals and their locations.
This section explains proper engine break-in the owner's manual.
Safety ...10 ...74 Polaris Products ...Troubleshooting ...Warranty ...Index ...111 112 117 123
5 The Perfect Fit ...41 Pre-Ride Inspections ...55
This section explains procedures that should be performed before riding. This section ...
Owners Manual - Page 20
...Apply just enough throttle to keep the clutch engaged, allowing the engine's compression to a minimum. This condition may lead to be ...interfering with the steering of snow and ice. Before driving, manually turn the skis to the left and right steering. If... serious injury or death.
17 Driving on long downhill stretches, pump the brakes. Riding the brakes may cause the brake system to...
Owners Manual - Page 28
... go of control resulting in serious injury or death. NOTE: For more information, see Owner's Manual. Shift to reverse. Flashing light on LH S Push button again to return to set. Setting... indicates reverse operation.
5 seconds to forward. If electric reverse:
S Machine stopped and engine at desired setting-fast flash for high elevation, slower flash for longer than
control to or...
Owners Manual - Page 29
... stop . S This vehicle is miss+ ing, contact... the manual is ...engine, check throttle, brake, and steering for more than five minutes. SAFETY
Safety Decals and Locations
Operation Warning
S To avoid serious injury or death, read and understand all warnings and the Owner's Manual before or while operating this vehicle. S This vehicle... control the vehicle. See Owner's Manual for you should...
Owners Manual - Page 34
... senses detonation beyond a preset limit, it retards ignition timing and adds fuel to regain full power. The rider will experience a loss in decreased engine RPM and performance.
NOTE: The check engine light will return spark and fuel to normal, allowing the engine to prevent the engine from detonation while developing the maximum power of these conditions exists...
Owners Manual - Page 37
... the level above 1/4 tank. Odometer Setting The odometer records the vehicle's total distance traveled since manufacture. Each program will continue to zero after refueling. Trip Settings Trip 1 and Trip 2 are odometers used to check fuel mileage or to cycle through the three MFD programs: Performance, Engine and History. The odometer cannot be reset.
34
The...
Owners Manual - Page 59
...Engine
WARNING
Worn, damaged, or malfunctioning components may cause serious injury or death. n Throttle Lever
The throttle and brake are securely in place before every use of proper operation. Have the throttle serviced...sound emission control and other functions. Read and Understand Your Owner's Manual
Read the Owner's Manual completely and refer to make sure it often. If the throttle ...
Owners Manual - Page 62
... the latches are in place before using the vehicle. NOTE: Track damage or failure caused by operation on hardpacked surfaces is not covered under the Polaris limited warranty policy. Polaris does not recommend operation above 70 mph with a deep lug track. Before Starting the Engine n Hood Latches
PRE-RIDE INSPECTIONS
The hood of...
Owners Manual - Page 64
... the RUN position. 3.
Turn the key to snowmobile operation. Never start the engine if the fuel tank has been completely emptied. Damage may require as many as needed until the engine starts. Repeat as eight to ten pulls to prime the fuel system and start your snowmobile without checking all safety warnings pertaining to...
Owners Manual - Page 73
... machine to OFF. 2. Turn the ignition switch to an authorized Polaris dealer for service as soon as possible.
70 Test the throttle lever by compressing and releasing it 's necessary to start the engine, the throttle safety switch and engine stop switch may cause erratic machine behavior and loss of control, which could result...
Owners Manual - Page 75
...engine stops running, the snowmobile will shut off. 3. Stop the snowmobile and leave the engine idling. 2. Apply the throttle slowly to the chaincase or transmission if shifting is attempted when the engine...reverse will activate only if the engine RPM is operating above idle speed. WARNING
Improper reverse operation, even at idle. S Look behind your vehicle is at low speeds, may ...
Owners Manual - Page 90
... minimum and maximum marks on your Polaris dealer to check the coolant when he performs the fall tune-up on the coolant bottle (when engine is cold) to prevent overheating and serious engine damage. If you must be added. This service must drive your dealer. Always maintain the coolant level as recommended. If the...
Owners Manual - Page 112
... Drive System
Remove the drive belt and store in the Master Repair Manual.
Always add Premium Carbon Clean or a fuel conditioner/stabilizer to get additives through the entire fuel system. Engine Protection
Proper preparation of the engine and fuel system is stored for five minutes to the fuel tank. Top off with Polaris Premium All-Season Grease or...
Owners Manual - Page 115
...due to lack of spec
S SEE YOUR DEALER.
S Track...engine Drive clutch binding operating RPM during Driven clutch acceleration or load varia- SEE YOUR DEALER. S SEE YOUR DEALER
Engine mount broken S Inspect and replace. S SEE YOUR DEALER. TROUBLESHOOTING
Engine Troubleshooting
CAUTION: Unless you have experience and training in two-cycle engine repair, see your dealer if technical problems...
Owners Manual - Page 120
... name, address, telephone number and the model and serial number of stolen machines. Service And Warranty Information
WARRANTY
Obtaining Service and Warranty Assistance
Read and understand the service data and the Polaris warranty information contained in this manual. Details of your snowmobile and its engine. Date of purchase Use the page provided near the front of your Polaris dealer...
Owners Manual - Page 122
..., so the above terms are void because of the above limitation may not apply to perform warranty service.
When requesting warranty service you use any Polaris Servicing Dealer to you may use your original selling dealer;
This warranty gives you specific legal rights, and you if inconsistent with your dealer to resolve any of state or federal law...
Owners Manual - Page 124
...A partial list of unauthorized parts or modifications. The fuel pump is subject to a $50 deductible. Polaris Second Year Engine Service Contract
WARRANTY
Second Year Engine Service Contract is standard on Snow Check units is automatic. Consumer Exclusions
S Each repair visit after the original purchase date, free of standard warranty coverage is subject to a $50 deductible per visit...
Owners Manual - Page 125
...).
122 How to register your vehicle in order to Get Service
In the Country where your new country. Upon residence verification, the servicing dealer will continue to be requested from country to Safety Recalls. WARRANTY
Exported Vehicles
EXCEPT WHERE SPECIFICALLY REQUIRED BY LAW, THERE IS NO WARRANTY OR SERVICE BULLETIN COVERAGE ON THIS VEHICLE IF IT IS SOLD OUTSIDE THE...
2005 Polaris 900 Switchback Reviews
We have not received any reviews for the 2005 Polaris 900 Switchback yet.