Owners Manual
Page 6
... warning light ...4-2 Speedometer ...4-3 Handlebar switches ...4-4 Throttle lever ...4-10 Speed limiter ...4-10 Front brake lever ...4-11 Brake pedal and rear brake lever ...4-12 Parking brake ...4-13 Drive select lever ...4-13 Recoil starter ...4-14 Fuel tank cap ...4-15 Fuel ...4-15 Fuel cock ...4-16 Starter (choke) ...4-18 Seat ...4-18 Storage compartment ...4-19 Front carrier ...4-20 Rear carrier ...4-21 Adjusting the front and rear shock absorber assemblies ...4-21 PRE-OPERATION CHECKS ...5-1 Pre-operation check list ...5-1 Fuel ...5-3 Engine oil ...5-3 Final gear oil ...5-3 Differential...
... warning light ...4-2 Speedometer ...4-3 Handlebar switches ...4-4 Throttle lever ...4-10 Speed limiter ...4-10 Front brake lever ...4-11 Brake pedal and rear brake lever ...4-12 Parking brake ...4-13 Drive select lever ...4-13 Recoil starter ...4-14 Fuel tank cap ...4-15 Fuel ...4-15 Fuel cock ...4-16 Starter (choke) ...4-18 Seat ...4-18 Storage compartment ...4-19 Front carrier ...4-20 Rear carrier ...4-21 Adjusting the front and rear shock absorber assemblies ...4-21 PRE-OPERATION CHECKS ...5-1 Pre-operation check list ...5-1 Fuel ...5-3 Engine oil ...5-3 Final gear oil ...5-3 Differential...
Owners Manual
Page 7
... MAINTENANCE AND MINOR REPAIR ...8-1 Owner's manual and tool kit ...8-1 Periodic maintenance chart for the emission control system ...8-3 General maintenance and lubrication chart ...8-5 Removing and installing the panel ...8-9 Checking the spark plug ...8-10 Engine oil and oil filter cartridge ...8-12 Final gear oil ...8-16 Differential gear oil ...8-19 Cleaning the air filter element ...8-21 Cleaning the spark arrester ...8-25 V-belt cooling duct check hose ...8-26 V-belt case drain plug ...8-27 Adjusting the carburetor ...8-27 Adjusting the engine idling speed ...8-28 Adjusting the throttle...
... MAINTENANCE AND MINOR REPAIR ...8-1 Owner's manual and tool kit ...8-1 Periodic maintenance chart for the emission control system ...8-3 General maintenance and lubrication chart ...8-5 Removing and installing the panel ...8-9 Checking the spark plug ...8-10 Engine oil and oil filter cartridge ...8-12 Final gear oil ...8-16 Differential gear oil ...8-19 Cleaning the air filter element ...8-21 Cleaning the spark arrester ...8-25 V-belt cooling duct check hose ...8-26 V-belt case drain plug ...8-27 Adjusting the carburetor ...8-27 Adjusting the engine idling speed ...8-28 Adjusting the throttle...
Owners Manual
Page 8
...41 Lubricating the steering shaft ...8-42 Battery ...8-42 Replacing a fuse ...8-44 Replacing a headlight bulb ...8-46 Adjusting a headlight beam ...8-48 Replacing the tail/brake light bulb ...8-48 Removing a wheel ...8-48 Installing a wheel ...8-49 Troubleshooting ...8-50 Troubleshooting chart ...8-52 CLEANING AND STORAGE ...9-1 Cleaning ...9-1 Storage ...9-2 SPECIFICATIONS ...10-1 CONSUMER INFORMATION...11-1 Identification numbers ...11-1 Noise regulation ...11-3 Maintenance record ...11-4 YAMAHA MOTOR CORPORATION, U.S.A. ATV LIMITED WARRANTY ...11-5 YAMAHA EXTENDED SERVICE (Y.E.S.) ...11...
...41 Lubricating the steering shaft ...8-42 Battery ...8-42 Replacing a fuse ...8-44 Replacing a headlight bulb ...8-46 Adjusting a headlight beam ...8-48 Replacing the tail/brake light bulb ...8-48 Removing a wheel ...8-48 Installing a wheel ...8-49 Troubleshooting ...8-50 Troubleshooting chart ...8-52 CLEANING AND STORAGE ...9-1 Cleaning ...9-1 Storage ...9-2 SPECIFICATIONS ...10-1 CONSUMER INFORMATION...11-1 Identification numbers ...11-1 Noise regulation ...11-3 Maintenance record ...11-4 YAMAHA MOTOR CORPORATION, U.S.A. ATV LIMITED WARRANTY ...11-5 YAMAHA EXTENDED SERVICE (Y.E.S.) ...11...
Owners Manual
Page 18
Fuses 5. Battery 6. Recoil starter 8. Engine oil filler cap 9. Fuel cock 3. Throttle stop screw 4. Rear shock absorber assembly spring preload adjusting ring 7. Oil filter cartridge 10.V-belt cooling duct check hose 3-1 1. 2. 3. 4. 5. 6. 7. Front shock absorber assembly spring preload adjusting ring 2. Spark arrester Storage compartment and tool kit Air filter case Spark plug Rear brake light switch Brake pedal V-belt case drain plug EBU17680 DESCRIPTION EBU17690 EBU17700 Left view 3 Right view 1.
Fuses 5. Battery 6. Recoil starter 8. Engine oil filler cap 9. Fuel cock 3. Throttle stop screw 4. Rear shock absorber assembly spring preload adjusting ring 7. Oil filter cartridge 10.V-belt cooling duct check hose 3-1 1. 2. 3. 4. 5. 6. 7. Front shock absorber assembly spring preload adjusting ring 2. Spark arrester Storage compartment and tool kit Air filter case Spark plug Rear brake light switch Brake pedal V-belt case drain plug EBU17680 DESCRIPTION EBU17690 EBU17700 Left view 3 Right view 1.
Owners Manual
Page 21
..." Oil temperature warning light " " On-Command differential gear lock indicator light " On-Command four-wheel-drive indicator light " " " EBU28331 Reverse indicator light "REVERSE" This indicator light comes on while the start switch is being pushed, G when the engine is in the reverse position. If the warning light does not come on when the transmission is released, have a Yamaha dealer check the speed sensor circuit. The electrical circuit of the warning light can be checked by turning...
..." Oil temperature warning light " " On-Command differential gear lock indicator light " On-Command four-wheel-drive indicator light " " " EBU28331 Reverse indicator light "REVERSE" This indicator light comes on while the start switch is being pushed, G when the engine is in the reverse position. If the warning light does not come on when the transmission is released, have a Yamaha dealer check the speed sensor circuit. The electrical circuit of the warning light can be checked by turning...
Owners Manual
Page 22
... On-Command differential gear lock indicator light " " This indicator light and the On-Command fourwheel-drive indicator light " " come on until the ATV starts moving. 4-3 This information will enable you can be reset to the "LOCK" position. If the warning light stays on, allow the engine to specification. The tripmeter can ride on when the On-Command differential gear lock switch is cool, have a Yamaha dealer check the electrical circuit...
... On-Command differential gear lock indicator light " " This indicator light and the On-Command fourwheel-drive indicator light " " come on until the ATV starts moving. 4-3 This information will enable you can be reset to the "LOCK" position. If the warning light stays on, allow the engine to specification. The tripmeter can ride on when the On-Command differential gear lock switch is cool, have a Yamaha dealer check the electrical circuit...
Owners Manual
Page 45
... brake system. Have a Yamaha dealer correct if necessary. If a problem cannot be a leak in this manual, have a Yamaha dealer check for one minute. WARNING POTENTIAL HAZARD Riding with the brakes. EBU19761 5 Throttle lever Check the operation of every ride. It must open smoothly and spring back to make sure they are working properly. If the brakes do not provide proper braking performance, check the brake pads...
... brake system. Have a Yamaha dealer correct if necessary. If a problem cannot be a leak in this manual, have a Yamaha dealer check for one minute. WARNING POTENTIAL HAZARD Riding with the brakes. EBU19761 5 Throttle lever Check the operation of every ride. It must open smoothly and spring back to make sure they are working properly. If the brakes do not provide proper braking performance, check the brake pads...
Owners Manual
Page 51
.... 6 6-3 Instead, start the engine. Continue warming up before riding. G If the battery is discharged, pull the recoil starter to a complete stop the ATV, otherwise the transmission may be returned to position (2) to position (3) before starting a cold engine, with the throttle slightly open. EBU20291 Starting a warm engine Follow the same procedure as for starting off . EBU20370 7. TIP The engine is warm when it idles smoothly...
.... 6 6-3 Instead, start the engine. Continue warming up before riding. G If the battery is discharged, pull the recoil starter to a complete stop the ATV, otherwise the transmission may be returned to position (2) to position (3) before starting a cold engine, with the throttle slightly open. EBU20291 Starting a warm engine Follow the same procedure as for starting off . EBU20370 7. TIP The engine is warm when it idles smoothly...
Owners Manual
Page 52
... indicator light does not come on , have a Yamaha dealer check the electrical circuit. 6 1. 2. 3. 4. TIP When in reverse, the reverse indicator light should come on . Open the throttle lever gradually. Shift from neutral to reverse and vice versa by moving the drive select lever along the shift guide. 4. Check behind for people or obstacles, and then release the brake pedal...
... indicator light does not come on , have a Yamaha dealer check the electrical circuit. 6 1. 2. 3. 4. TIP When in reverse, the reverse indicator light should come on . Open the throttle lever gradually. Shift from neutral to reverse and vice versa by moving the drive select lever along the shift guide. 4. Check behind for people or obstacles, and then release the brake pedal...
Owners Manual
Page 74
... 4WD-LOCK ("DIFF. Improper use only, and handling maneuvers are thoroughly familiar with these components. With the engine idling, return the starter (choke) to lose traction, reducing control and increasing the possibility of the brakes can cause the tires to the closed position, shift the drive select lever into the forward position, and then release the parking brake. When slowing down or stopping, release...
... 4WD-LOCK ("DIFF. Improper use only, and handling maneuvers are thoroughly familiar with these components. With the engine idling, return the starter (choke) to lose traction, reducing control and increasing the possibility of the brakes can cause the tires to the closed position, shift the drive select lever into the forward position, and then release the parking brake. When slowing down or stopping, release...
Owners Manual
Page 79
... weight uphill. WHAT CAN HAPPEN Could result in the Owner's Manual. 7 When fully stopped, apply the rear brake as the wheels on uphill side or to roll backwards, DO NOT apply either the front or rear brake as well, and then lock the parking brake. G 4WD or 4WD-LOCK: Apply both the front and rear brakes gradually, or dismount the ATV immediately on the uphill side. Turn...
... weight uphill. WHAT CAN HAPPEN Could result in the Owner's Manual. 7 When fully stopped, apply the rear brake as the wheels on uphill side or to roll backwards, DO NOT apply either the front or rear brake as well, and then lock the parking brake. G 4WD or 4WD-LOCK: Apply both the front and rear brakes gradually, or dismount the ATV immediately on the uphill side. Turn...
Owners Manual
Page 129
...: Silicone grease Rear brake lever: Lithium-soap-based grease 8 Brake light switch 2. Checking and lubricating the cables The operation and the condition of all control cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. Install the panel. HOW TO AVOID THE HAZARD Inspect cables frequently. Recommended lubricant: Engine oil 8-39 Checking...
...: Silicone grease Rear brake lever: Lithium-soap-based grease 8 Brake light switch 2. Checking and lubricating the cables The operation and the condition of all control cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. Install the panel. HOW TO AVOID THE HAZARD Inspect cables frequently. Recommended lubricant: Engine oil 8-39 Checking...
Owners Manual
Page 135
....0 A Signaling system fuse: 10.0 A EWB02151 1. 2. 3. 4. 5. Remove the blown fuse, and then install a new fuse of the proper fuse. 8-45 8 NOTICE To prevent accidental short-circuiting, turn off the main switch when checking or replacing a fuse. Headlight fuse Ignition fuse Four-wheel-drive motor fuse Signaling system fuse Spare fuse The main fuse and the fuse box are located under the seat. (See page 4-18.) If a fuse is blown, replace it as follows. 1. 2. Turn the key to a fire. ECB00640 WARNING...
....0 A Signaling system fuse: 10.0 A EWB02151 1. 2. 3. 4. 5. Remove the blown fuse, and then install a new fuse of the proper fuse. 8-45 8 NOTICE To prevent accidental short-circuiting, turn off the main switch when checking or replacing a fuse. Headlight fuse Ignition fuse Four-wheel-drive motor fuse Signaling system fuse Spare fuse The main fuse and the fuse box are located under the seat. (See page 4-18.) If a fuse is blown, replace it as follows. 1. 2. Turn the key to a fire. ECB00640 WARNING...
Owners Manual
Page 143
... improve its general performance and extend the useful life of the exhaust pipe to prevent water entry. A plastic bag and strong rubber band may cause water seepage and deterioration of wheel bearings, brakes, transmission seals and electrical devices. Use only enough pressure to the wheel axles. 3. An old toothbrush or bottle brush is excessively greasy, apply degreaser with a garden hose. Many expensive repair bills have result9...
... improve its general performance and extend the useful life of the exhaust pipe to prevent water entry. A plastic bag and strong rubber band may cause water seepage and deterioration of wheel bearings, brakes, transmission seals and electrical devices. Use only enough pressure to the wheel axles. 3. An old toothbrush or bottle brush is excessively greasy, apply degreaser with a garden hose. Many expensive repair bills have result9...
Owners Manual
Page 146
EBU25960 SPECIFICATIONS Dimensions: Overall length: 1995 mm (78.5 in) Overall width: 1095 mm (43.1 in) Overall height: 1120 mm (44.1 in) Seat height: 830 mm (32.7 in) Wheelbase: 1235 mm (48.6 in) Ground clearance: 245 mm (9.6 in) Minimum turning radius: 3000 mm (118 in) Compression ratio: 9.20 :1 Starting system: Electric and recoil starter Lubrication system: Wet sump Engine oil: Type: YAMALUBE 4 5W-30...
EBU25960 SPECIFICATIONS Dimensions: Overall length: 1995 mm (78.5 in) Overall width: 1095 mm (43.1 in) Overall height: 1120 mm (44.1 in) Seat height: 830 mm (32.7 in) Wheelbase: 1235 mm (48.6 in) Ground clearance: 245 mm (9.6 in) Minimum turning radius: 3000 mm (118 in) Compression ratio: 9.20 :1 Starting system: Electric and recoil starter Lubrication system: Wet sump Engine oil: Type: YAMALUBE 4 5W-30...
Owners Manual
Page 149
Rear suspension: Type: Double wishbone Spring/shock absorber type: Coil spring/oil damper Wheel travel: 180 mm (7.1 in) Oil temperature warning light: 12 V, 1.7 W × 1 On-command four-wheel-drive indicator light: 12 V, 1.7 W × 1 Differential gear lock indicator light: 12 V, 1.7 W x 1 Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 15.0 A Four-wheel-drive motor fuse: 10.0 A Electrical system: Ignition system: DC. CDI Charging system: AC magneto Battery: Model: YTX14AH Voltage, capacity: 12 V, 12.0 Ah Headlight: Bulb type: Krypton bulb...
Rear suspension: Type: Double wishbone Spring/shock absorber type: Coil spring/oil damper Wheel travel: 180 mm (7.1 in) Oil temperature warning light: 12 V, 1.7 W × 1 On-command four-wheel-drive indicator light: 12 V, 1.7 W × 1 Differential gear lock indicator light: 12 V, 1.7 W x 1 Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 15.0 A Four-wheel-drive motor fuse: 10.0 A Electrical system: Ignition system: DC. CDI Charging system: AC magneto Battery: Model: YTX14AH Voltage, capacity: 12 V, 12.0 Ah Headlight: Bulb type: Krypton bulb...
Owners Manual
Page 154
... as spark plugs, oil, oil filter, air filter, and brake shoes. GENERAL EXCLUSIONS from the original purchaser to any part adjudged defective by this warranty shall include parts replaced due to certain stated limitations. f. P.O. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE EXCLUSION MAY NOT APPLY TO YOU. ATV LIMITED WARRANTY Yamaha Motor Corporation...
... as spark plugs, oil, oil filter, air filter, and brake shoes. GENERAL EXCLUSIONS from the original purchaser to any part adjudged defective by this warranty shall include parts replaced due to certain stated limitations. f. P.O. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE EXCLUSION MAY NOT APPLY TO YOU. ATV LIMITED WARRANTY Yamaha Motor Corporation...
Owners Manual
Page 155
... address. The remainder of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes. The unit has to -date list of all costs of the existing warranty can be done by a Yamaha ATV dealer. If a question or problem arises regarding warranty, first contact the owner of a safety-related defect and recall. Since all warranty matters are general and overlap...
... address. The remainder of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes. The unit has to -date list of all costs of the existing warranty can be done by a Yamaha ATV dealer. If a question or problem arises regarding warranty, first contact the owner of a safety-related defect and recall. Since all warranty matters are general and overlap...
Owners Manual
Page 159
... Engine stop switch ...4-4 F Final gear oil ...5-3, 8-16 Four-wheel-drive indicator light ...4-3 Fuel ...4-15, 5-3 Fuel cock ...4-16 Fuel tank cap ...4-15 Fuses, replacing ...8-44 C Cables, checking and lubricating ...8-39 Carburetor, adjusting ...8-27 Carrier, front ...4-20 Carrier, rear ...4-21 Chassis fasteners ...5-7 Cleaning ...9-1 H Handlebar switches ...4-4 Headlight beam, adjusting ...8-48 Headlight bulb, replacing ...8-46 I Identification numbers ...11-1 Indicator lights and warning light ...4-2 Instruments, lights and switches ...5-7 D Differential gear lock indicator light...
... Engine stop switch ...4-4 F Final gear oil ...5-3, 8-16 Four-wheel-drive indicator light ...4-3 Fuel ...4-15, 5-3 Fuel cock ...4-16 Fuel tank cap ...4-15 Fuses, replacing ...8-44 C Cables, checking and lubricating ...8-39 Carburetor, adjusting ...8-27 Carrier, front ...4-20 Carrier, rear ...4-21 Chassis fasteners ...5-7 Cleaning ...9-1 H Handlebar switches ...4-4 Headlight beam, adjusting ...8-48 Headlight bulb, replacing ...8-46 I Identification numbers ...11-1 Indicator lights and warning light ...4-2 Instruments, lights and switches ...5-7 D Differential gear lock indicator light...
Owners Manual
Page 160
... Maintenance record ...11-4 Model label ...11-2 N Neutral indicator light ...4-2 Noise regulation ...11-3 O Oil temperature warning light ...4-2 On-Command differential gear lock switch ...4-7 On-Command four-wheel-drive switch ...4-6 Override switch ...4-5 Owner's manual and tool kit ...8-1 T Tail/brake light bulb, replacing ...8-48 Throttle cable free play, adjusting ...8-29 Throttle lever ...4-10, 5-4 Tire pressure, measuring ...5-6 Tires ...5-5 Tire wear limit ...5-7 Troubleshooting ...8-50 Troubleshooting chart ...8-52 P Panel, removing and installing ...8-9 Parking ...6-6 Parking...
... Maintenance record ...11-4 Model label ...11-2 N Neutral indicator light ...4-2 Noise regulation ...11-3 O Oil temperature warning light ...4-2 On-Command differential gear lock switch ...4-7 On-Command four-wheel-drive switch ...4-6 Override switch ...4-5 Owner's manual and tool kit ...8-1 T Tail/brake light bulb, replacing ...8-48 Throttle cable free play, adjusting ...8-29 Throttle lever ...4-10, 5-4 Tire pressure, measuring ...5-6 Tires ...5-5 Tire wear limit ...5-7 Troubleshooting ...8-50 Troubleshooting chart ...8-52 P Panel, removing and installing ...8-9 Parking ...6-6 Parking...