Owners Manual
Page 7
... control system ...6-3 General maintenance and lubrication chart ...6-4 Checking the spark plugs ...6-8 Canister (for California only) ...6-9 Engine oil and oil filter cartridge ...6-9 Transfer case oil ...6-12 Air filter element ...6-13 Checking the throttle cable free play ...6-13 Valve clearance ...6-13 Tires ...6-14 Cast wheels ...6-15 Accessories and replacement parts ...6-16 Clutch lever ...6-16 Adjusting the rear brake light switch ...6-17 Checking the front and rear brake pads ...6-17 Checking the brake and clutch fluid levels ...6-18 Changing the brake and clutch fluids ...6-19 Drive...
... control system ...6-3 General maintenance and lubrication chart ...6-4 Checking the spark plugs ...6-8 Canister (for California only) ...6-9 Engine oil and oil filter cartridge ...6-9 Transfer case oil ...6-12 Air filter element ...6-13 Checking the throttle cable free play ...6-13 Valve clearance ...6-13 Tires ...6-14 Cast wheels ...6-15 Accessories and replacement parts ...6-16 Clutch lever ...6-16 Adjusting the rear brake light switch ...6-17 Checking the front and rear brake pads ...6-17 Checking the brake and clutch fluid levels ...6-18 Changing the brake and clutch fluids ...6-19 Drive...
Owners Manual
Page 11
... mind: G Cargo and accessory weight should be kept to a minimum. • Bulky or large accessories may become unstable in any way reduce ground clearance or cornering clearance, limit suspension travel, steering travel or control operation, or obscure lights or reflectors. • Accessories fitted to the handlebar, front fork, or front fender. Since Yamaha cannot test all other accessories that it to make...
... mind: G Cargo and accessory weight should be kept to a minimum. • Bulky or large accessories may become unstable in any way reduce ground clearance or cornering clearance, limit suspension travel, steering travel or control operation, or obscure lights or reflectors. • Accessories fitted to the handlebar, front fork, or front fender. Since Yamaha cannot test all other accessories that it to make...
Owners Manual
Page 12
.... If electrical accessories exceed the capacity of gasoline vapor, or allow gasoline to touch these hot areas. • Do not park the motorcycle on a slope or soft ground, otherwise it may limit control ability, therefore, such accessories are not likely to get into your eyes, see your motorcycle in a closed area. G Never start the engine or let it run for...
.... If electrical accessories exceed the capacity of gasoline vapor, or allow gasoline to touch these hot areas. • Do not park the motorcycle on a slope or soft ground, otherwise it may limit control ability, therefore, such accessories are not likely to get into your eyes, see your motorcycle in a closed area. G Never start the engine or let it run for...
Owners Manual
Page 19
...) (0.66 Imp.gal). INSTRUMENT AND CONTROL FUNCTIONS To unlock the steering EAU11003 EAU11080 Indicator and warning lights High beam indicator light " " This indicator light comes on when the high beam of control or an accident. Make sure that the vehicle is pushed to "OFF" or "LOCK". 1. 2. 3. 4. 5. 6. Neutral indicator light " " High beam indicator light " " Right turn signal indicator light " " Left turn signal indicator light " " Engine trouble warning light " " Fuel level warning light " " EAU11030 Turn signal indicator lights " " and " " The...
...) (0.66 Imp.gal). INSTRUMENT AND CONTROL FUNCTIONS To unlock the steering EAU11003 EAU11080 Indicator and warning lights High beam indicator light " " This indicator light comes on when the high beam of control or an accident. Make sure that the vehicle is pushed to "OFF" or "LOCK". 1. 2. 3. 4. 5. 6. Neutral indicator light " " High beam indicator light " " Right turn signal indicator light " " Left turn signal indicator light " " Engine trouble warning light " " Fuel level warning light " " EAU11030 Turn signal indicator lights " " and " " The...
Owners Manual
Page 23
... This model is displayed. Push and hold the "SELECT" switch. 3. Multi-function meter unit panel LCD Speedometer needle Tachometer needle Fuel gauge needle The brightness can be checked as soon as follows. 1. Item number 3. When the hour digits start flashing. 5. If any error codes, note the code number, and then have a Yamaha dealer check the vehicle. G 3 1. 2. 3. 4. 5. Brightness level 4. Turn the key to...
... This model is displayed. Push and hold the "SELECT" switch. 3. Multi-function meter unit panel LCD Speedometer needle Tachometer needle Fuel gauge needle The brightness can be checked as soon as follows. 1. Item number 3. When the hour digits start flashing. 5. If any error codes, note the code number, and then have a Yamaha dealer check the vehicle. G 3 1. 2. 3. 4. 5. Brightness level 4. Turn the key to...
Owners Manual
Page 25
... Turn signal switch " / " To signal a right-hand turn signal lights can be canceled manually by pushing the switch in after the vehicle has traveled both about 150 m (490 ft) and for optional lights) " " This model can also be equipped with the starter. When released, the switch returns to " ". However, the turn , push this switch to the center position. Engine stop the engine in either light, otherwise the headlight fuse may blow or the battery...
... Turn signal switch " / " To signal a right-hand turn signal lights can be canceled manually by pushing the switch in after the vehicle has traveled both about 150 m (490 ft) and for optional lights) " " This model can also be equipped with the starter. When released, the switch returns to " ". However, the turn , push this switch to the center position. Engine stop the engine in either light, otherwise the headlight fuse may blow or the battery...
Owners Manual
Page 29
... secured before doing any maintenance work. G Do not allow the engine to the catalytic converter. NOTE: Make sure that the exhaust system has cooled down to lock it counterclockwise. Insert the key into the seat holder as grass or other damages. Seat lock 2. Seat holder CAUTION: The following precautions must be observed to prevent a fire hazard or other materials that position, lift the front of...
... secured before doing any maintenance work. G Do not allow the engine to the catalytic converter. NOTE: Make sure that the exhaust system has cooled down to lock it counterclockwise. Insert the key into the seat holder as grass or other damages. Seat lock 2. Seat holder CAUTION: The following precautions must be observed to prevent a fire hazard or other materials that position, lift the front of...
Owners Manual
Page 32
... system This model is turned on, have a Yamaha dealer service the shock absorber. For proper handling, read and understand the following information before handling the shock absorber. If the EXUP system cannot be held responsible for property damage or personal injury that regulates the diameter of or damage to an open the gas cylinder. This system boosts engine power by a computer-controlled servomotor. Changing these...
... system This model is turned on, have a Yamaha dealer service the shock absorber. For proper handling, read and understand the following information before handling the shock absorber. If the EXUP system cannot be held responsible for property damage or personal injury that regulates the diameter of or damage to an open the gas cylinder. This system boosts engine power by a computer-controlled servomotor. Changing these...
Owners Manual
Page 39
... neutral position. NOTE: When the transmission is set to " ". Consult a Yamaha dealer regarding any length of time. Exhaust fumes are poisonous, and inhaling them can cause loss of control. Never ride with all operating controls and their functions before riding. Turn the key to preserve the battery. If a warning light does not go 5-1 Always make sure that the engine stop switch is in gear with the clutch...
... neutral position. NOTE: When the transmission is set to " ". Consult a Yamaha dealer regarding any length of time. Exhaust fumes are poisonous, and inhaling them can cause loss of control. Never ride with all operating controls and their functions before riding. Turn the key to preserve the battery. If a warning light does not go 5-1 Always make sure that the engine stop switch is in gear with the clutch...
Owners Manual
Page 40
..., and then slightly raise it. Shift pedal 2. Neutral position G Shifting gears lets you control the amount of engine power available for starting off. Pull the clutch lever to avoid damaging the engine, transmission, and drive train, which are shown in the neutral position, do not tow the motorcycle for long distances. Shifting CAUTION: G 5 1. EAU16680 To start out and accelerate 1. The neutral indicator light should go out. 3. Inadequate lubrication...
..., and then slightly raise it. Shift pedal 2. Neutral position G Shifting gears lets you control the amount of engine power available for starting off. Pull the clutch lever to avoid damaging the engine, transmission, and drive train, which are shown in the neutral position, do not tow the motorcycle for long distances. Shifting CAUTION: G 5 1. EAU16680 To start out and accelerate 1. The neutral indicator light should go out. 3. Inadequate lubrication...
Owners Manual
Page 49
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. G Hydraulic brake and clutch systems • After disassembling the brake or clutch master cylinders, caliper cylinders or clutch release cylinder, always change the fluid. EAU38440 NOTE: G Air filter • This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. • The air filter element needs to be replaced more frequently when riding in...
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. G Hydraulic brake and clutch systems • After disassembling the brake or clutch master cylinders, caliper cylinders or clutch release cylinder, always change the fluid. EAU38440 NOTE: G Air filter • This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. • The air filter element needs to be replaced more frequently when riding in...
Owners Manual
Page 54
... clutch), do not use oils with the remaining oil quantity while regularly checking the oil level on any parts after the engine and exhaust system have a Yamaha dealer check and repair the vehicle. If any chemical additives. Do not use oils labeled "ENERGY CONSERVING II" or higher. If oil is found, have cooled down. 14. Start the engine, rev it several times, and then turn the engine...
... clutch), do not use oils with the remaining oil quantity while regularly checking the oil level on any parts after the engine and exhaust system have a Yamaha dealer check and repair the vehicle. If any chemical additives. Do not use oils labeled "ENERGY CONSERVING II" or higher. If oil is found, have cooled down. 14. Start the engine, rev it several times, and then turn the engine...
Owners Manual
Page 59
.... PERIODIC MAINTENANCE AND MINOR REPAIR EAU22270 EAU22390 Adjusting the rear brake light switch Checking the front and rear brake pads The front and rear brake pads must be checked for damage and measure the lining thickness. EAU22430 indicator grooves have almost disappeared, have a Yamaha dealer replace the brake pads as a set . Rear brake light switch 2. Brake pad wear indicator groove Each front brake pad is less than 0.8 mm (0.03 in), have a Yamaha dealer replace the brake pads as...
.... PERIODIC MAINTENANCE AND MINOR REPAIR EAU22270 EAU22390 Adjusting the rear brake light switch Checking the front and rear brake pads The front and rear brake pads must be checked for damage and measure the lining thickness. EAU22430 indicator grooves have almost disappeared, have a Yamaha dealer replace the brake pads as a set . Rear brake light switch 2. Brake pad wear indicator groove Each front brake pad is less than 0.8 mm (0.03 in), have a Yamaha dealer replace the brake pads as...
Owners Manual
Page 68
... fuse Specified fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling system fuse: 10.0 A Ignition fuse: 25.0 A Fuel injection system fuse: 15.0 A ECU (Electronic Control Unit) fuse: 10.0 A Auxiliary DC connector fuse: 3.0 A Taillight fuse: 10.0 A Backup fuse: 10.0 A ECA10640 If a fuse is blown, replace it as follows. 1. CAUTION: Do not use a fuse of the specified amperage. Turn the key to "ON" and turn off the electrical circuit in question to the electrical system and possibly a fire...
... fuse Specified fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling system fuse: 10.0 A Ignition fuse: 25.0 A Fuel injection system fuse: 15.0 A ECU (Electronic Control Unit) fuse: 10.0 A Auxiliary DC connector fuse: 3.0 A Taillight fuse: 10.0 A Backup fuse: 10.0 A ECA10640 If a fuse is blown, replace it as follows. 1. CAUTION: Do not use a fuse of the specified amperage. Turn the key to "ON" and turn off the electrical circuit in question to the electrical system and possibly a fire...
Owners Manual
Page 80
... Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 4.10 L (4.33 US qt) (3.61 Imp.qt) With oil filter cartridge replacement: 4.90 L (5.18 US qt) (4.31 Imp.qt) Spark plug (s): Manufacturer/model: NGK/DPR8EA-9 Manufacturer/model: DENSO/X24EPR-U9 Spark plug gap: 0.8-0.9 mm (0.031-0.035 in) Clutch: Clutch type: Wet, multiple-disc Transmission: Primary reduction system: Spur gear Primary...
... Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 4.10 L (4.33 US qt) (3.61 Imp.qt) With oil filter cartridge replacement: 4.90 L (5.18 US qt) (4.31 Imp.qt) Spark plug (s): Manufacturer/model: NGK/DPR8EA-9 Manufacturer/model: DENSO/X24EPR-U9 Spark plug gap: 0.8-0.9 mm (0.031-0.035 in) Clutch: Clutch type: Wet, multiple-disc Transmission: Primary reduction system: Spur gear Primary...
Owners Manual
Page 81
... RADIAL G Rear suspension: Type: Swingarm (link suspension) Spring/shock absorber type: Coil spring/gas-oil damper Wheel travel: 110.0 mm (4.33 in) Front wheel: Wheel type: Cast wheel Rim size: 18M/C x MT4.00 Electrical system: Ignition system: Transistorized coil ignition (digital) Charging system: AC magneto Rear wheel: Wheel type: Cast wheel Rim size: 17M/C x MT5.50 Rear tire: Type: Tubeless Size: 190/60R17M/C 78H Manufacturer/model: DUNLOP/D251 Manufacturer/model: BRIDGESTONE/G850 RADIAL G Battery: Model: GT14B-4 Voltage, capacity: 12 V, 12.0 Ah Front brake: Type...
... RADIAL G Rear suspension: Type: Swingarm (link suspension) Spring/shock absorber type: Coil spring/gas-oil damper Wheel travel: 110.0 mm (4.33 in) Front wheel: Wheel type: Cast wheel Rim size: 18M/C x MT4.00 Electrical system: Ignition system: Transistorized coil ignition (digital) Charging system: AC magneto Rear wheel: Wheel type: Cast wheel Rim size: 17M/C x MT5.50 Rear tire: Type: Tubeless Size: 190/60R17M/C 78H Manufacturer/model: DUNLOP/D251 Manufacturer/model: BRIDGESTONE/G850 RADIAL G Battery: Model: GT14B-4 Voltage, capacity: 12 V, 12.0 Ah Front brake: Type...
Owners Manual
Page 82
SPECIFICATIONS Front turn signal/position light: 12 V, 23 W/8.0 W × 2 Rear turn signal light: 12 V, 21.0 W × 2 License plate light: 12 V, 5.0 W Meter lighting: LED Neutral indicator light: LED High beam indicator light: LED Turn signal indicator light: LED Fuel level warning light: LED Engine trouble warning light: LED Auxiliary DC connector fuse: 3.0 A Backup fuse: 10.0 A Fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse: 10.0 A Ignition fuse: 25.0 A ECU (Electronic Control Unit) fuse: 10.0 A Fuel injection system fuse: 15.0 A 8 8-3
SPECIFICATIONS Front turn signal/position light: 12 V, 23 W/8.0 W × 2 Rear turn signal light: 12 V, 21.0 W × 2 License plate light: 12 V, 5.0 W Meter lighting: LED Neutral indicator light: LED High beam indicator light: LED Turn signal indicator light: LED Fuel level warning light: LED Engine trouble warning light: LED Auxiliary DC connector fuse: 3.0 A Backup fuse: 10.0 A Fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse: 10.0 A Ignition fuse: 25.0 A ECU (Electronic Control Unit) fuse: 10.0 A Fuel injection system fuse: 15.0 A 8 8-3
Owners Manual
Page 89
... covered by an authorized Yamaha motorcycle dealer. MODELS EXCLUDED FROM WARRANTY include those resulting from this warranty. SPECIFIC EXCLUSIONS from defects in material or workmanship, which would cause it is designed, built, and equipped so as specified in material and workmanship for the balance of sale with headlight, stoplight, and turn signals shall be free from defects in the appropriate Owner's Manual...
... covered by an authorized Yamaha motorcycle dealer. MODELS EXCLUDED FROM WARRANTY include those resulting from this warranty. SPECIFIC EXCLUSIONS from defects in material or workmanship, which would cause it is designed, built, and equipped so as specified in material and workmanship for the balance of sale with headlight, stoplight, and turn signals shall be free from defects in the appropriate Owner's Manual...
Owners Manual
Page 90
... to Yamaha Motor Corporation, U.S.A. Each Yamaha motorcycle dealer is compiled from the purchase registrations sent to remain effective. The remainder of purchase. CUSTOMER SERVICE If your machine requires warranty service, you have any authorized Yamaha motorcycle dealer within the continental United States. Q. Specific examples include: Running the machine out of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes...
... to Yamaha Motor Corporation, U.S.A. Each Yamaha motorcycle dealer is compiled from the purchase registrations sent to remain effective. The remainder of purchase. CUSTOMER SERVICE If your machine requires warranty service, you have any authorized Yamaha motorcycle dealer within the continental United States. Q. Specific examples include: Running the machine out of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes...
Owners Manual
Page 93
... ...6-16 Air filter element...6-13 Auxiliary DC connector ...3-18 Fuel level warning light...3-2 Fuel tank cap...3-10 Fuses, replacing...6-26 Pre-operation check list ...4-2 R Rear brake light switch, adjusting ...6-17 Rear suspension, lubricating ...6-22 Rider seat ...3-12 H Handlebar switches ...3-7 Headlight bulb, replacing...6-27 Helmet holder...3-13 High beam indicator light...3-2 Horn switch ...3-8 B Battery ...6-24 Brake and clutch fluid levels, checking ...6-18 Brake and clutch fluids, changing...6-19 Brake and clutch levers, checking and lubricating ...6-21 Brake and shift pedals...
... ...6-16 Air filter element...6-13 Auxiliary DC connector ...3-18 Fuel level warning light...3-2 Fuel tank cap...3-10 Fuses, replacing...6-26 Pre-operation check list ...4-2 R Rear brake light switch, adjusting ...6-17 Rear suspension, lubricating ...6-22 Rider seat ...3-12 H Handlebar switches ...3-7 Headlight bulb, replacing...6-27 Helmet holder...3-13 High beam indicator light...3-2 Horn switch ...3-8 B Battery ...6-24 Brake and clutch fluid levels, checking ...6-18 Brake and clutch fluids, changing...6-19 Brake and clutch levers, checking and lubricating ...6-21 Brake and shift pedals...