Owners Manual
Page 3
... basic maintenance of the motorcycle. The design and manufacture of this manual. It represents the high degree of craftsmanship and reliability that you and your Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this Yamaha motorcycle fully comply with the emissions standards for clean air applicable at the date of the Yamaha Road Star...
... basic maintenance of the motorcycle. The design and manufacture of this manual. It represents the high degree of craftsmanship and reliability that you and your Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this Yamaha motorcycle fully comply with the emissions standards for clean air applicable at the date of the Yamaha Road Star...
Owners Manual
Page 7
... spark plugs ...6-9 Canister (for California only) ...6-10 Engine oil and oil filter cartridge ...6-11 Transfer case oil ...6-14 Cleaning the air filter element ...6-16 Checking the throttle cable free play ...6-17 Valve clearance ...6-18 Tires (For spoke wheel model)...6-18 Tires (For cast wheel models) ...6-20 Spoke wheels ...6-22 Cast wheels ...6-23 Accessories and replacement parts ...6-23 Adjusting the clutch lever free play ...6-24 Adjusting the brake lever free play ...6-25 Adjusting the rear brake light switch...
... spark plugs ...6-9 Canister (for California only) ...6-10 Engine oil and oil filter cartridge ...6-11 Transfer case oil ...6-14 Cleaning the air filter element ...6-16 Checking the throttle cable free play ...6-17 Valve clearance ...6-18 Tires (For spoke wheel model)...6-18 Tires (For cast wheel models) ...6-20 Spoke wheels ...6-22 Cast wheels ...6-23 Accessories and replacement parts ...6-23 Adjusting the clutch lever free play ...6-24 Adjusting the brake lever free play ...6-25 Adjusting the rear brake light switch...
Owners Manual
Page 8
... the wheel bearings ...6-33 Battery ...6-33 Replacing the fuses ...6-34 Replacing the headlight bulb ...6-36 Tail/brake light ...6-37 Replacing a turn signal light bulb ...6-37 Replacing a license plate light bulb ...6-38 Supporting the motorcycle ...6-38 Troubleshooting ...6-39 Troubleshooting chart ...6-40 MOTORCYCLE CARE AND STORAGE ...7-1 Matte color caution ...7-1 Care ...7-1 Storage ...7-4 SPECIFICATIONS ...8-1 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION...
... the wheel bearings ...6-33 Battery ...6-33 Replacing the fuses ...6-34 Replacing the headlight bulb ...6-36 Tail/brake light ...6-37 Replacing a turn signal light bulb ...6-37 Replacing a license plate light bulb ...6-38 Supporting the motorcycle ...6-38 Troubleshooting ...6-39 Troubleshooting chart ...6-40 MOTORCYCLE CARE AND STORAGE ...7-1 Matte color caution ...7-1 Care ...7-1 Storage ...7-4 SPECIFICATIONS ...8-1 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION...
Owners Manual
Page 11
... any way reduce ground clearance or cornering clearance, 1-3 G limit suspension travel, steering travel or control operation, or obscure lights or reflectors. • Accessories fitted to improper weight distribution or aerodynamic changes. Keep the following in mind, as well as low and close to the motorcycle before riding. Since Yamaha cannot test all other accessories that would impair the performance of your...
... any way reduce ground clearance or cornering clearance, 1-3 G limit suspension travel, steering travel or control operation, or obscure lights or reflectors. • Accessories fitted to improper weight distribution or aerodynamic changes. Keep the following in mind, as well as low and close to the motorcycle before riding. Since Yamaha cannot test all other accessories that would impair the performance of your...
Owners Manual
Page 12
... is kept upright. If electrical accessories exceed the capacity of the motorcycle's electrical system, an electric failure could result, which could catch fire. SAFETY INFORMATION tor and may limit control ability, therefore, such accessories are poisonous and may cause loss of consciousness and death within a short time. When parking the motorcycle, note the following: • The engine and exhaust system may be hot...
... is kept upright. If electrical accessories exceed the capacity of the motorcycle's electrical system, an electric failure could result, which could catch fire. SAFETY INFORMATION tor and may limit control ability, therefore, such accessories are poisonous and may cause loss of consciousness and death within a short time. When parking the motorcycle, note the following: • The engine and exhaust system may be hot...
Owners Manual
Page 17
Transfer case oil level check bolt (page 6-14) 9. Shock absorber assembly spring preload adjusting nut (page 3-15) 2-3 DESCRIPTION EAU32230 Right view XV17AWX(C)/XV17ASX(C) 1 2 3 2 9 1. 2. 3. 4. 5. 6. 7. Main fuse and fuel injection system fuse (page 6-34) Fuel tank (page 3-9) Fuel tank cap (page 3-9) Brake pedal (page 3-8) Rear brake light switch (page 6-25) Engine oil filter cartridge (page 6-11) Air filter element (page 6-16) 8 7 6 5 4 8.
Transfer case oil level check bolt (page 6-14) 9. Shock absorber assembly spring preload adjusting nut (page 3-15) 2-3 DESCRIPTION EAU32230 Right view XV17AWX(C)/XV17ASX(C) 1 2 3 2 9 1. 2. 3. 4. 5. 6. 7. Main fuse and fuel injection system fuse (page 6-34) Fuel tank (page 3-9) Fuel tank cap (page 3-9) Brake pedal (page 3-8) Rear brake light switch (page 6-25) Engine oil filter cartridge (page 6-11) Air filter element (page 6-16) 8 7 6 5 4 8.
Owners Manual
Page 18
DESCRIPTION XV17ATX(C)/XV17ATSX(C) 1 2 3 4 2 10 9 1. 2. 3. 4. 5. 6. 7. 8. 9. Main fuse and fuel injection system fuse (page 6-34) Fuel tank (page 3-9) Fuel tank cap (page 3-9) Windshield (page 3-12) Brake pedal (page 3-8) Rear brake light switch (page 6-25) Engine oil filter cartridge (page 6-11) Air filter element (page 6-16) Transfer case oil level check bolt (page 6-14) 8 7 6 5 10.Shock absorber assembly spring preload adjusting nut (page 3-15) 2-4
DESCRIPTION XV17ATX(C)/XV17ATSX(C) 1 2 3 4 2 10 9 1. 2. 3. 4. 5. 6. 7. 8. 9. Main fuse and fuel injection system fuse (page 6-34) Fuel tank (page 3-9) Fuel tank cap (page 3-9) Windshield (page 3-12) Brake pedal (page 3-8) Rear brake light switch (page 6-25) Engine oil filter cartridge (page 6-11) Air filter element (page 6-16) Transfer case oil level check bolt (page 6-14) 8 7 6 5 10.Shock absorber assembly spring preload adjusting nut (page 3-15) 2-4
Owners Manual
Page 22
... the turn signal switch is also equipped with a selfdiagnosis device for 3.0 seconds. The electrical circuit of the warning light can be repeated until the malfunction is corrected: The fuel level warning light Engine trouble warning light " " This warning light comes on . EAU11361 will be checked by turning the key to "ON". NOTE: This model is pushed to "ON". When this occurs, have a Yamaha dealer check the vehicle. If the warning light...
... the turn signal switch is also equipped with a selfdiagnosis device for 3.0 seconds. The electrical circuit of the warning light can be repeated until the malfunction is corrected: The fuel level warning light Engine trouble warning light " " This warning light comes on . EAU11361 will be checked by turning the key to "ON". NOTE: This model is pushed to "ON". When this occurs, have a Yamaha dealer check the vehicle. If the warning light...
Owners Manual
Page 26
... then release the "SELECT" switch after the vehicle 3-6 Since this switch to the odometer or tripmeter mode. Push the " " or " " side of the "SELECT" switch to the center position. Push the "RESET" switch to " ". To signal a left-hand turn signal lights will return to " ". INSTRUMENT AND CONTROL FUNCTIONS 3. Horn switch " " 1. 2. 3. 4. Turn the key to " " for the low beam. Engine stop switch " / "SELECT" switch " / "RESET" switch Start switch " " " 4 " EAU12400 Dimmer switch " / " Set this switch to confirm...
... then release the "SELECT" switch after the vehicle 3-6 Since this switch to the odometer or tripmeter mode. Push the " " or " " side of the "SELECT" switch to the center position. Push the "RESET" switch to " ". To signal a left-hand turn signal lights will return to " ". INSTRUMENT AND CONTROL FUNCTIONS 3. Horn switch " " 1. 2. 3. 4. Turn the key to " " for the low beam. Engine stop switch " / "SELECT" switch " / "RESET" switch Start switch " " " 4 " EAU12400 Dimmer switch " / " Set this switch to confirm...
Owners Manual
Page 27
... switch to starting the engine. To engage the clutch, release the lever. NOTE: The self-canceling system only operates when the vehicle is moving, so that the turn signal lights can also be pulled rapidly and released slowly for starting instructions prior to sound the horn. See "Multi-function meter unit" on when the key is turned to "ON" and the start switch is used to perform...
... switch to starting the engine. To engage the clutch, release the lever. NOTE: The self-canceling system only operates when the vehicle is moving, so that the turn signal lights can also be pulled rapidly and released slowly for starting instructions prior to sound the horn. See "Multi-function meter unit" on when the key is turned to "ON" and the start switch is used to perform...
Owners Manual
Page 30
... types of leaded gasoline will extend spark plug life and reduce maintenance costs. INSTRUMENT AND CONTROL FUNCTIONS ECA10070 CAUTION: Immediately wipe off spilled fuel with a clean, dry, soft cloth, since fuel may deteriorate painted surfaces or plastic parts. 3 EAU13361 Recommended fuel: UNLEADED GASOLINE ONLY Fuel tank capacity: 18.0 L (4.76 US gal) (3.96 Imp.gal) Fuel reserve amount (when the fuel level warning light comes on): 3.4 L (0.90 US...
... types of leaded gasoline will extend spark plug life and reduce maintenance costs. INSTRUMENT AND CONTROL FUNCTIONS ECA10070 CAUTION: Immediately wipe off spilled fuel with a clean, dry, soft cloth, since fuel may deteriorate painted surfaces or plastic parts. 3 EAU13361 Recommended fuel: UNLEADED GASOLINE ONLY Fuel tank capacity: 18.0 L (4.76 US gal) (3.96 Imp.gal) Fuel reserve amount (when the fuel level warning light comes on): 3.4 L (0.90 US...
Owners Manual
Page 43
... control. Exhaust fumes are poisonous, and inhaling them can cause loss of the following conditions must be sure to turn the main switch to "OFF" and then to " ". EWA10290 WARNING G G Before starting even though the engine will crank when pushing the start the engine after a turnover, be met: G The transmission is not raised completely, it in gear with a lean angle sensor to stop switch...
... control. Exhaust fumes are poisonous, and inhaling them can cause loss of the following conditions must be sure to turn the main switch to "OFF" and then to " ". EWA10290 WARNING G G Before starting even though the engine will crank when pushing the start the engine after a turnover, be met: G The transmission is not raised completely, it in gear with a lean angle sensor to stop switch...
Owners Manual
Page 45
... shock of time with the transmission in and use the clutch while changing gears to avoid damaging the engine, transmission, and drive train, which are shown in . 5. Pull the clutch lever to the next higher gear. Open the throttle gradually, and at the recommended shift points. Shift the transmission into first gear. If the engine is about to shift the transmission into the neutral position when the motorcycle is running...
... shock of time with the transmission in and use the clutch while changing gears to avoid damaging the engine, transmission, and drive train, which are shown in . 5. Pull the clutch lever to the next higher gear. Open the throttle gradually, and at the recommended shift points. Shift the transmission into first gear. If the engine is about to shift the transmission into the neutral position when the motorcycle is running...
Owners Manual
Page 60
... oils with a diesel specification of "CD" or oils of the check hole. 6 1 2 1. NOTE: The oil should be checked and the oil must be at the intervals specified in an upright position. Install the rider seat. Turn the engine off and check for oil leakage. Remove the oil check bolt, and then check the oil level in a false reading. 2. Install the engine oil filler cap. 6-14 PERIODIC MAINTENANCE...
... oils with a diesel specification of "CD" or oils of the check hole. 6 1 2 1. NOTE: The oil should be checked and the oil must be at the intervals specified in an upright position. Install the rider seat. Turn the engine off and check for oil leakage. Remove the oil check bolt, and then check the oil level in a false reading. 2. Install the engine oil filler cap. 6-14 PERIODIC MAINTENANCE...
Owners Manual
Page 66
... weight of cargo, rider, passenger, and accessories (windshield, saddlebags, etc. PERIODIC MAINTENANCE AND MINOR REPAIR EAU21421 6 Front tire: Size: 130/90-16M/C 67H Manufacturer/model: XV17ATX BRIDGESTONE/G703M XV17ATXC BRIDGESTONE/G703M XV17ATX DUNLOP/D404F XV17ATXC DUNLOP/D404F Rear tire: Size: 150/80B16M/C 71H Manufacturer/model: XV17ATX BRIDGESTONE/G702E XV17ATXC BRIDGESTONE/G702E XV17ATX DUNLOP/D404 XV17ATXC DUNLOP/D404 Tires (For cast wheel models) To ensure maximum performance, long service...
... weight of cargo, rider, passenger, and accessories (windshield, saddlebags, etc. PERIODIC MAINTENANCE AND MINOR REPAIR EAU21421 6 Front tire: Size: 130/90-16M/C 67H Manufacturer/model: XV17ATX BRIDGESTONE/G703M XV17ATXC BRIDGESTONE/G703M XV17ATX DUNLOP/D404F XV17ATXC DUNLOP/D404F Rear tire: Size: 150/80B16M/C 71H Manufacturer/model: XV17ATX BRIDGESTONE/G702E XV17ATXC BRIDGESTONE/G702E XV17ATX DUNLOP/D404 XV17ATXC DUNLOP/D404 Tires (For cast wheel models) To ensure maximum performance, long service...
Owners Manual
Page 92
... in) Compression ratio: 8.36 :1 Starting system: Electric starter Lubrication system: Dry sump Fuel: Recommended fuel: Unleaded gasoline only Fuel tank capacity: 18.0 L (4.76 US gal) (3.96 Imp.gal) Fuel reserve amount: 3.4 L (0.90 US gal) (0.75 Imp.gal) Fuel injection: Throttle body: Manufacturer: MIKUNI Type/quantity: AC40/1 Spark plug (s): Manufacturer/model: NGK/DPR7EA-9 Manufacturer/model: DENSO/X22EPR-U9 Spark plug gap: 0.8-0.9 mm (0.031-0.035 in) Engine oil: Type: YAMALUBE 4 (20W-40...
... in) Compression ratio: 8.36 :1 Starting system: Electric starter Lubrication system: Dry sump Fuel: Recommended fuel: Unleaded gasoline only Fuel tank capacity: 18.0 L (4.76 US gal) (3.96 Imp.gal) Fuel reserve amount: 3.4 L (0.90 US gal) (0.75 Imp.gal) Fuel injection: Throttle body: Manufacturer: MIKUNI Type/quantity: AC40/1 Spark plug (s): Manufacturer/model: NGK/DPR7EA-9 Manufacturer/model: DENSO/X22EPR-U9 Spark plug gap: 0.8-0.9 mm (0.031-0.035 in) Engine oil: Type: YAMALUBE 4 (20W-40...
Owners Manual
Page 94
... wheel XV17AWX Cast wheel XV17AWXC Cast wheel Rim size: 16M/C x MT3.50 Rear suspension: Type: Swingarm (link suspension) Spring/shock absorber type: Coil spring/gas-oil damper Wheel travel: 110.0 mm (4.33 in) Electrical system: Ignition system: TCI (digital) Charging system: AC magneto 8 Fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling system fuse: 15.0 A Ignition fuse: 20.0 A Fuel injection system fuse: 15.0 A 8-3 Front brake: Type: Dual disc brake Operation: Right hand operation Recommended fluid: DOT 4 Battery: Model: GT14B-4 Voltage, capacity: 12 V, 12.0 Ah Headlight: Bulb...
... wheel XV17AWX Cast wheel XV17AWXC Cast wheel Rim size: 16M/C x MT3.50 Rear suspension: Type: Swingarm (link suspension) Spring/shock absorber type: Coil spring/gas-oil damper Wheel travel: 110.0 mm (4.33 in) Electrical system: Ignition system: TCI (digital) Charging system: AC magneto 8 Fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling system fuse: 15.0 A Ignition fuse: 20.0 A Fuel injection system fuse: 15.0 A 8-3 Front brake: Type: Dual disc brake Operation: Right hand operation Recommended fluid: DOT 4 Battery: Model: GT14B-4 Voltage, capacity: 12 V, 12.0 Ah Headlight: Bulb...
Owners Manual
Page 102
... with headlight, stoplight, and turn signals shall be one (1) year from defects in material or workmanship, which would cause it is designed, built, and equipped so as specified in the appropriate Owner's Manual, and 2. All parts replaced under this warranty shall include parts replaced due to : 1. SPECIFIC EXCLUSIONS from this warranty shall be inspected and registered for non-Yamaha-authorized renting, leasing...
... with headlight, stoplight, and turn signals shall be one (1) year from defects in material or workmanship, which would cause it is designed, built, and equipped so as specified in the appropriate Owner's Manual, and 2. All parts replaced under this warranty shall include parts replaced due to : 1. SPECIFIC EXCLUSIONS from this warranty shall be inspected and registered for non-Yamaha-authorized renting, leasing...
Owners Manual
Page 103
.... Since all warranty matters are still not satisfied and require additional assistance, please write to -date list of all costs of the dealership. Completely set up -to : YAMAHA MOTOR CORPORATION, U.S.A. If a question or problem arises regarding the warranty, first contact the owner of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes. Q. CONSUMER INFORMATION WARRANTY QUESTIONS AND...
.... Since all warranty matters are still not satisfied and require additional assistance, please write to -date list of all costs of the dealership. Completely set up -to : YAMAHA MOTOR CORPORATION, U.S.A. If a question or problem arises regarding the warranty, first contact the owner of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes. Q. CONSUMER INFORMATION WARRANTY QUESTIONS AND...
Owners Manual
Page 106
... D Dimmer switch ...3-6 Drive belt slack...6-28 E Engine break-in...5-4 Engine oil and oil filter cartridge...6-11 Engine stop switch ...3-7 Engine trouble warning light...3-2 T Tail/brake light...6-37 Throttle cable free play, checking ...6-17 Throttle grip and cable, checking and lubricating ...6-29 Tires (For cast wheel models)...6-20 Tires (For spoke wheel model)...6-18 Tool kit...6-1 N Neutral indicator light...3-2 Noise regulation...9-4 F Front and rear brake pads, checking ...6-26 Front fork, checking ...6-31 Fuel ...3-9 P Panels, removing and installing...6-8 Parking ...5-4 Part...
... D Dimmer switch ...3-6 Drive belt slack...6-28 E Engine break-in...5-4 Engine oil and oil filter cartridge...6-11 Engine stop switch ...3-7 Engine trouble warning light...3-2 T Tail/brake light...6-37 Throttle cable free play, checking ...6-17 Throttle grip and cable, checking and lubricating ...6-29 Tires (For cast wheel models)...6-20 Tires (For spoke wheel model)...6-18 Tool kit...6-1 N Neutral indicator light...3-2 Noise regulation...9-4 F Front and rear brake pads, checking ...6-26 Front fork, checking ...6-31 Fuel ...3-9 P Panels, removing and installing...6-8 Parking ...5-4 Part...