Owners Manual
Page 7
... panels ...6-8 Checking the spark plugs ...6-9 Canister (for California only) ...6-11 Engine oil and oil filter cartridge ...6-11 Coolant ...6-14 Replacing the air filter element ...6-15 Checking the throttle cable free play ...6-16 Valve clearance ...6-16 Tires ...6-17 Cast wheels ...6-18 Accessories and replacement parts ...6-19 Adjusting the clutch lever free play ...6-19 Adjusting the brake lever free play ...6-20 Adjusting the rear brake light switch ...6-21 Checking the front and rear brake pads ...6-21 Checking the brake fluid...
... panels ...6-8 Checking the spark plugs ...6-9 Canister (for California only) ...6-11 Engine oil and oil filter cartridge ...6-11 Coolant ...6-14 Replacing the air filter element ...6-15 Checking the throttle cable free play ...6-16 Valve clearance ...6-16 Tires ...6-17 Cast wheels ...6-18 Accessories and replacement parts ...6-19 Adjusting the clutch lever free play ...6-19 Adjusting the brake lever free play ...6-20 Adjusting the rear brake light switch ...6-21 Checking the front and rear brake pads ...6-21 Checking the brake fluid...
Owners Manual
Page 8
STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 TABLE OF CONTENTS Replacing a rear turn signal light bulb ...6-34 Replacing the license plate light bulb ...6-35 Supporting the motorcycle ...6-36 Troubleshooting ...6-36 Troubleshooting charts ...6-37 MOTORCYCLE CARE AND STORAGE ...7-1 Matte color caution ...7-1 Care ...7-1 Storage ...7-3 SPECIFICATIONS ...8-1 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A.
STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 TABLE OF CONTENTS Replacing a rear turn signal light bulb ...6-34 Replacing the license plate light bulb ...6-35 Supporting the motorcycle ...6-36 Troubleshooting ...6-36 Troubleshooting charts ...6-37 MOTORCYCLE CARE AND STORAGE ...7-1 Matte color caution ...7-1 Care ...7-1 Storage ...7-3 SPECIFICATIONS ...8-1 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A.
Owners Manual
Page 11
... be responsible for use of non-Yamaha accessories. Make sure that may become unstable in any way reduce ground clearance or cornering clearance, limit suspension travel, steering travel or control operation, or obscure lights or reflectors. • Accessories fitted to the handlebar or the front fork area can create unstable handling or a slow steering response. G Shifting weights can displace the operator from...
... be responsible for use of non-Yamaha accessories. Make sure that may become unstable in any way reduce ground clearance or cornering clearance, limit suspension travel, steering travel or control operation, or obscure lights or reflectors. • Accessories fitted to the handlebar or the front fork area can create unstable handling or a slow steering response. G Shifting weights can displace the operator from...
Owners Manual
Page 12
... turn the engine off before leaving the motorcycle unattended and remove the key from the main switch. G Never start the engine or let it is kept upright. SAFETY INFORMATION tor and may limit control ability, therefore, such accessories are poisonous and may leak out of lights or engine power. If electrical accessories exceed the capacity of the motorcycle's electrical system, an electric failure could result, which could catch fire...
... turn the engine off before leaving the motorcycle unattended and remove the key from the main switch. G Never start the engine or let it is kept upright. SAFETY INFORMATION tor and may limit control ability, therefore, such accessories are poisonous and may leak out of lights or engine power. If electrical accessories exceed the capacity of the motorcycle's electrical system, an electric failure could result, which could catch fire...
Owners Manual
Page 15
Front turn signal light (page 6-34) 10.Engine oil level check window (page 6-11) 11.Shift pedal (page 3-8) 12.Engine oil filler cap (page 6-11) Rear turn signal/position lights (page 6-34) Headlight (page 6-32) Seat lock (page 3-11) Fuel injection system fuse (page 6-30) Fuse box (page 6-30) Main fuse (page 6-30) Helmet holder (page 3-12) License plate light (page 6-35) 2-1 9. DESCRIPTION EAU10410 Left view 2 1. 2. 3. 4. 5. 6. 7. 8.
Front turn signal light (page 6-34) 10.Engine oil level check window (page 6-11) 11.Shift pedal (page 3-8) 12.Engine oil filler cap (page 6-11) Rear turn signal/position lights (page 6-34) Headlight (page 6-32) Seat lock (page 3-11) Fuel injection system fuse (page 6-30) Fuse box (page 6-30) Main fuse (page 6-30) Helmet holder (page 3-12) License plate light (page 6-35) 2-1 9. DESCRIPTION EAU10410 Left view 2 1. 2. 3. 4. 5. 6. 7. 8.
Owners Manual
Page 18
... key cannot be started and stays on , and the engine can be removed. The key can be removed. NOTE: The headlight comes on automatically when the engine is moving, otherwise the electrical systems will be switched off . Push. 2. Remove the key. 3-1 Push the key in loss of control or an accident. The key can be removed. EWA10060 WARNING ON All electrical circuits are supplied with power...
... key cannot be started and stays on , and the engine can be removed. The key can be removed. NOTE: The headlight comes on automatically when the engine is moving, otherwise the electrical systems will be switched off . Push. 2. Remove the key. 3-1 Push the key in loss of control or an accident. The key can be removed. EWA10060 WARNING ON All electrical circuits are supplied with power...
Owners Manual
Page 19
...) (0.81 Imp.gal). Neutral indicator light " " Coolant temperature warning light " Engine trouble warning light " " High beam indicator light " " Turn signal indicator light " " Oil level warning light " " Fuel level warning light " " " Oil level warning light " " This warning light comes on when the transmission is in the neutral position. G This model is also equipped with a self-diagnosis device for a few seconds, and then go off , have a Yamaha dealer check the electrical circuit. G This model is also equipped with a self...
...) (0.81 Imp.gal). Neutral indicator light " " Coolant temperature warning light " Engine trouble warning light " " High beam indicator light " " Turn signal indicator light " " Oil level warning light " " Fuel level warning light " " " Oil level warning light " " This warning light comes on when the transmission is in the neutral position. G This model is also equipped with a self-diagnosis device for a few seconds, and then go off , have a Yamaha dealer check the electrical circuit. G This model is also equipped with a self...
Owners Manual
Page 24
... beam. INSTRUMENT AND CONTROL FUNCTIONS Right has traveled both about 150 m (490 ft) and for detailed information. Engine stop switch " / "SELECT" switch " / "RESET" switch Start switch " " " " The engine trouble warning light will come on page 3-3 for approximately 15 seconds. See "Multi-function meter unit" on when the key is turned to stop switch " / " Set this switch to crank the engine with a self-canceling system, the turn signal lights can...
... beam. INSTRUMENT AND CONTROL FUNCTIONS Right has traveled both about 150 m (490 ft) and for detailed information. Engine stop switch " / "SELECT" switch " / "RESET" switch Start switch " " " " The engine trouble warning light will come on page 3-3 for approximately 15 seconds. See "Multi-function meter unit" on when the key is turned to stop switch " / " Set this switch to crank the engine with a self-canceling system, the turn signal lights can...
Owners Manual
Page 27
EWA10880 Recommended fuel: UNLEADED GASOLINE ONLY Fuel tank capacity: 18.5 L (4.89 US gal) (4.07 Imp.gal) Fuel reserve amount (when the fuel level warning light comes on the hot engine. Gasohol containing ethanol can cause damage to the exhaust system. Your Yamaha engine has been designed to use of the filler tube as to the fuel system or vehicle performance problems. 3 CAUTION: Use only unleaded gasoline. When...
EWA10880 Recommended fuel: UNLEADED GASOLINE ONLY Fuel tank capacity: 18.5 L (4.89 US gal) (4.07 Imp.gal) Fuel reserve amount (when the fuel level warning light comes on the hot engine. Gasohol containing ethanol can cause damage to the exhaust system. Your Yamaha engine has been designed to use of the filler tube as to the fuel system or vehicle performance problems. 3 CAUTION: Use only unleaded gasoline. When...
Owners Manual
Page 30
... does not stay up), otherwise the sidestand could contact the ground and distract the operator, resulting in a possible loss of control. NOTE: The built-in sidestand switch is located on the shock absorber. G Do not deform or damage the gas cylinder in any way, as described WARNING This shock absorber contains highly pressurized nitrogen gas. G Always have a Yamaha dealer service the shock absorber.
... does not stay up), otherwise the sidestand could contact the ground and distract the operator, resulting in a possible loss of control. NOTE: The built-in sidestand switch is located on the shock absorber. G Do not deform or damage the gas cylinder in any way, as described WARNING This shock absorber contains highly pressurized nitrogen gas. G Always have a Yamaha dealer service the shock absorber.
Owners Manual
Page 36
... starting the engine, check the function of control. Turn the key to " ". ECA15660 CAUTION: The following conditions must be met: G The transmission is not raised completely, it in a closed area for the corresponding warning light circuit check. 2. G Oil level warning light G Fuel level warning light 5-1 If the sidestand is in gear with the clutch lever pulled and the sidestand up . In order for the ignition circuit cut -off . Shift...
... starting the engine, check the function of control. Turn the key to " ". ECA15660 CAUTION: The following conditions must be met: G The transmission is not raised completely, it in a closed area for the corresponding warning light circuit check. 2. G Oil level warning light G Fuel level warning light 5-1 If the sidestand is in gear with the clutch lever pulled and the sidestand up . In order for the ignition circuit cut -off . Shift...
Owners Manual
Page 37
... the shock of forced shifting. Shift pedal 2. Open the throttle gradually, and at the same time, release the clutch lever slowly. 5-2 Neutral position G Shifting gears lets you control the amount of engine power available for starting off. Always use the clutch while changing gears to disengage the clutch. 2. Inadequate lubrication may damage the transmission. NOTE: The engine is warm when it . Never accelerate hard when the engine is running. The transmission is...
... the shock of forced shifting. Shift pedal 2. Open the throttle gradually, and at the same time, release the clutch lever slowly. 5-2 Neutral position G Shifting gears lets you control the amount of engine power available for starting off. Always use the clutch while changing gears to disengage the clutch. 2. Inadequate lubrication may damage the transmission. NOTE: The engine is warm when it . Never accelerate hard when the engine is running. The transmission is...
Owners Manual
Page 54
... in the periodic maintenance and lubrication chart. Have a Yamaha dealer change the coolant. 1. Remove the air filter case cover by removing the bolts. Coolant reservoir breather hose EAU33030 Changing the coolant EWA10380 6 WARNING Never attempt to remove the radiator cap when the engine is hot. 5. Guide 2. EWA10380 EAU42441 Replacing the air filter element The air filter element should be reduced. PERIODIC MAINTENANCE AND MINOR REPAIR G If water has been added to the coolant, have a Yamaha dealer check...
... in the periodic maintenance and lubrication chart. Have a Yamaha dealer change the coolant. 1. Remove the air filter case cover by removing the bolts. Coolant reservoir breather hose EAU33030 Changing the coolant EWA10380 6 WARNING Never attempt to remove the radiator cap when the engine is hot. 5. Guide 2. EWA10380 EAU42441 Replacing the air filter element The air filter element should be reduced. PERIODIC MAINTENANCE AND MINOR REPAIR G If water has been added to the coolant, have a Yamaha dealer check...
Owners Manual
Page 60
... the brake is working properly. If a brake pad has worn to disassemble the brake. If necessary, adjust the brake light switch as follows. If there is properly adjusted when the brake light comes on earlier, turn the adjusting nut in the hydraulic system, have a Yamaha dealer bleed the system before braking takes effect. PERIODIC MAINTENANCE AND MINOR REPAIR EWA10630 EAU22270 EAU22390 WARNING G G 6 After adjusting the brake lever...
... the brake is working properly. If a brake pad has worn to disassemble the brake. If necessary, adjust the brake light switch as follows. If there is properly adjusted when the brake light comes on earlier, turn the adjusting nut in the hydraulic system, have a Yamaha dealer bleed the system before braking takes effect. PERIODIC MAINTENANCE AND MINOR REPAIR EWA10630 EAU22270 EAU22390 WARNING G G 6 After adjusting the brake lever...
Owners Manual
Page 70
... a Yamaha dealer check the electrical system. 6-31 Install the battery cover, and then hook the battery band onto the holder. 6 1. 2. 3. 4. 5. 6. 7. Signaling system fuse Ignition fuse Taillight fuse Radiator fan fuse Backup fuse (for odometer and clock) Headlight fuse Spare fuse CAUTION: Do not use a fuse of a higher amperage rating than recommended to avoid causing extensive damage to check if the device operates. 5. PERIODIC MAINTENANCE AND MINOR REPAIR Specified fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling...
... a Yamaha dealer check the electrical system. 6-31 Install the battery cover, and then hook the battery band onto the holder. 6 1. 2. 3. 4. 5. 6. 7. Signaling system fuse Ignition fuse Taillight fuse Radiator fan fuse Backup fuse (for odometer and clock) Headlight fuse Spare fuse CAUTION: Do not use a fuse of a higher amperage rating than recommended to avoid causing extensive damage to check if the device operates. 5. PERIODIC MAINTENANCE AND MINOR REPAIR Specified fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling...
Owners Manual
Page 82
... SAE20W40 Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 3.20 L (3.38 US qt) (2.82 Imp.qt) With oil filter cartridge replacement: 3.40 L (3.59 US qt) (2.99 Imp.qt) Spark plug (s): Manufacturer/model: NGK/LMAR7A-9 Manufacturer/model: NGK/LMAR6A-9 Spark plug gap: 0.8-0.9 mm (0.031-0.035 in) Clutch: Clutch type: Wet, multiple-disc Transmission: Primary reduction system: Spur gear Primary...
... SAE20W40 Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 3.20 L (3.38 US qt) (2.82 Imp.qt) With oil filter cartridge replacement: 3.40 L (3.59 US qt) (2.99 Imp.qt) Spark plug (s): Manufacturer/model: NGK/LMAR7A-9 Manufacturer/model: NGK/LMAR6A-9 Spark plug gap: 0.8-0.9 mm (0.031-0.035 in) Clutch: Clutch type: Wet, multiple-disc Transmission: Primary reduction system: Spur gear Primary...
Owners Manual
Page 83
... Rear suspension: Type: Swingarm (link suspension) Spring/shock absorber type: Coil spring/gas-oil damper Wheel travel: 110.0 mm (4.33 in) Front wheel: Wheel type: Cast wheel Rim size: 16M/C x MT3.00 Electrical system: Ignition system: Transistorized coil ignition (digital) Charging system: AC magneto Rear wheel: Wheel type: Cast wheel Rim size: 16M/C x MT4.50 Rear tire: Type: Tubeless Size: 170/70B 16M/C 75H Manufacturer/model: DUNLOP/K555 Manufacturer/model: BRIDGESTONE/EXEDRA G722 G Battery: Model: YTX20L-BS Voltage, capacity: 12 V, 18.0 Ah Front brake...
... Rear suspension: Type: Swingarm (link suspension) Spring/shock absorber type: Coil spring/gas-oil damper Wheel travel: 110.0 mm (4.33 in) Front wheel: Wheel type: Cast wheel Rim size: 16M/C x MT3.00 Electrical system: Ignition system: Transistorized coil ignition (digital) Charging system: AC magneto Rear wheel: Wheel type: Cast wheel Rim size: 16M/C x MT4.50 Rear tire: Type: Tubeless Size: 170/70B 16M/C 75H Manufacturer/model: DUNLOP/K555 Manufacturer/model: BRIDGESTONE/EXEDRA G722 G Battery: Model: YTX20L-BS Voltage, capacity: 12 V, 18.0 Ah Front brake...
Owners Manual
Page 91
... KIND, EXPRESSED OR IMPLIED. MODELS EXCLUDED FROM WARRANTY include those resulting from defects in the appropriate Owner's Manual, and 2. Parts used for this warranty shall include any subsequent purchaser, it not to conform at the time of sale with a displacement of purchase, with headlight, stoplight, and turn signals shall be charged for non-Yamaha-authorized renting, leasing or other than those used...
... KIND, EXPRESSED OR IMPLIED. MODELS EXCLUDED FROM WARRANTY include those resulting from defects in the appropriate Owner's Manual, and 2. Parts used for this warranty shall include any subsequent purchaser, it not to conform at the time of sale with a displacement of purchase, with headlight, stoplight, and turn signals shall be charged for non-Yamaha-authorized renting, leasing or other than those used...
Owners Manual
Page 92
... as towing or transportation due to repair of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes. Yes. CUSTOMER RELATIONS DEPARTMENT P.O. Each Yamaha motorcycle dealer is limited to a failure? Is the warranty transferable to : YAMAHA MOTOR CORPORATION, U.S.A. The unit has to maintain a complete, up every new machine before sale. 2. A. What are general and overlap each manufacturer of a motor vehicle...
... as towing or transportation due to repair of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake shoes. Yes. CUSTOMER RELATIONS DEPARTMENT P.O. Each Yamaha motorcycle dealer is limited to a failure? Is the warranty transferable to : YAMAHA MOTOR CORPORATION, U.S.A. The unit has to maintain a complete, up every new machine before sale. 2. A. What are general and overlap each manufacturer of a motor vehicle...
Owners Manual
Page 95
... control system ...6-3 Maintenance, periodic ...6-1 Maintenance record ...9-5 Matte color, caution...7-1 Model label...9-2 Multi-function meter unit...3-3 D Dimmer switch ...3-7 Drive belt slack ...6-23 E Engine break-in ...5-3 Engine oil and oil filter cartridge ...6-11 Engine stop switch...3-7 Engine trouble warning light ...3-3 T Tail/brake light bulb, replacing ...6-33 Throttle cable free play, checking ...6-16 Throttle grip and cable, checking and lubricating ...6-24 Tires...6-17 Tool kit ...6-1 N Neutral indicator light ...3-2 Noise regulation ...9-4 F Front and rear brake pads...
... control system ...6-3 Maintenance, periodic ...6-1 Maintenance record ...9-5 Matte color, caution...7-1 Model label...9-2 Multi-function meter unit...3-3 D Dimmer switch ...3-7 Drive belt slack ...6-23 E Engine break-in ...5-3 Engine oil and oil filter cartridge ...6-11 Engine stop switch...3-7 Engine trouble warning light ...3-3 T Tail/brake light bulb, replacing ...6-33 Throttle cable free play, checking ...6-16 Throttle grip and cable, checking and lubricating ...6-24 Tires...6-17 Tool kit ...6-1 N Neutral indicator light ...3-2 Noise regulation ...9-4 F Front and rear brake pads...