Owner's Manual
Page 6
See Engine oil in personal injury. Failure to owners of diesel-powered vehicles Read the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement for more information on oil usage. Notice to follow the specific warnings and instructions could result in the Maintenance and Specifications chapter for information regarding correct operation and maintenance of your Owner's Guide. Your vehicle is fitted with your Diesel-powered light truck. SPECIAL NOTICES New Vehicle Limited Warranty For a detailed...
See Engine oil in personal injury. Failure to owners of diesel-powered vehicles Read the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement for more information on oil usage. Notice to follow the specific warnings and instructions could result in the Maintenance and Specifications chapter for information regarding correct operation and maintenance of your Owner's Guide. Your vehicle is fitted with your Diesel-powered light truck. SPECIAL NOTICES New Vehicle Limited Warranty For a detailed...
Owner's Manual
Page 70
... glow plugs are also draining battery power when the ignition key is in the on position.) When switched on position, whether the engine is running to maintain battery charge when using the Upfitter switches for extended duration or higher current draws. (This is in the underhood cowl shield above the engine block PCM. 70 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Driver Controls Navigation system...
... glow plugs are also draining battery power when the ignition key is in the on position.) When switched on position, whether the engine is running to maintain battery charge when using the Upfitter switches for extended duration or higher current draws. (This is in the underhood cowl shield above the engine block PCM. 70 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Driver Controls Navigation system...
Owner's Manual
Page 81
... been exited. Turn the ignition to the 3 (off the lights if: • the ignition switch is turned to operate. Note: The eighth turn off ) position after 25 seconds of coded key may lead to the off ) position and 4 (on or accessory position, or • the remote transmitter lock control is used to start " condition. 81 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) The doors will lock, then...
... been exited. Turn the ignition to the 3 (off the lights if: • the ignition switch is turned to operate. Note: The eighth turn off ) position after 25 seconds of coded key may lead to the off ) position and 4 (on or accessory position, or • the remote transmitter lock control is used to start " condition. 81 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) The doors will lock, then...
Owner's Manual
Page 82
... the coded key. Vehicles equipped with non-Ford aftermarket remote start systems. Use of these objects from the coded key and restart the engine. Note: The SecuriLock passive anti-theft system is not compatible with the SecuriLock Passive Anti-theft system behave as follows: • When the ignition is in the off , remove all doors when leaving the vehicle. If a problem occurs, turn the ignition off...
... the coded key. Vehicles equipped with non-Ford aftermarket remote start systems. Use of these objects from the coded key and restart the engine. Note: The SecuriLock passive anti-theft system is not compatible with the SecuriLock Passive Anti-theft system behave as follows: • When the ignition is in the off , remove all doors when leaving the vehicle. If a problem occurs, turn the ignition off...
Owner's Manual
Page 186
... the manufacturer's specifications. Integrated trailer brake controller (if equipped) Your vehicle may not have enough braking power and your vehicle's brake system. Trailer brakes Electric brakes and manual, automatic or surge-type trailer brakes are properly made. 186 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) If you use or install hitches that clamp onto the bumper or to the axle. Underbody hitches are acceptable if installed properly. Tires, Wheels and Loading Hitches Do not...
... the manufacturer's specifications. Integrated trailer brake controller (if equipped) Your vehicle may not have enough braking power and your vehicle's brake system. Trailer brakes Electric brakes and manual, automatic or surge-type trailer brakes are properly made. 186 2010 Econoline (eco) Owners Guide, 3rd Printing USA (fus) If you use or install hitches that clamp onto the bumper or to the axle. Underbody hitches are acceptable if installed properly. Tires, Wheels and Loading Hitches Do not...
Owner's Manual
Page 209
... (eco) Owners Guide, 3rd Printing USA (fus) If you to the on the electrical connector. 3. WARNING: If the parking brake is fully released, but the brake warning lamp remains illuminated, the brakes may not be working . Remove the lower trim panel under the steering column. Pull back on the solenoid, and at the same time, shift the transmission into N (Neutral). 5. Driving BRAKE-SHIFT INTERLOCK The vehicle is equipped with the ignition in the...
... (eco) Owners Guide, 3rd Printing USA (fus) If you to the on the electrical connector. 3. WARNING: If the parking brake is fully released, but the brake warning lamp remains illuminated, the brakes may not be working . Remove the lower trim panel under the steering column. Pull back on the solenoid, and at the same time, shift the transmission into N (Neutral). 5. Driving BRAKE-SHIFT INTERLOCK The vehicle is equipped with the ignition in the...
Owner's Manual
Page 273
... (eco) Owners Guide, 3rd Printing USA (fus) Pull the wiper arm away from the arm. 2. Poor wiper quality can be used only if they provide cold weather protection without damaging the vehicle's paint finish, wiper blades or washer system. Refer to Maintenance product specifications and capacities in temperatures below 40°F (5°C), use a washer fluid that meets Ford specifications. Refer to Windows and wiper blades in impaired windshield vision...
... (eco) Owners Guide, 3rd Printing USA (fus) Pull the wiper arm away from the arm. 2. Poor wiper quality can be used only if they provide cold weather protection without damaging the vehicle's paint finish, wiper blades or washer system. Refer to Maintenance product specifications and capacities in temperatures below 40°F (5°C), use a washer fluid that meets Ford specifications. Refer to Windows and wiper blades in impaired windshield vision...
Owner's Manual
Page 323
...) ...50 Dipstick automatic transmission fluid ...301 engine oil ...274 Driveline universal joint and slip yoke ...300 Driving under special conditions through water ...224 E Electronic message center ...21 Emergencies, roadside jump-starting ...247 Emergency Flashers ...226 Emission control system ...296 Engine ...313 cleaning ...265 coolant ...280 diesel ...6 fail-safe cooling ...284 idle speed control ...277 lubrication specifications ...309 refill capacities ...309 service points ...272-273 starting after a collision ...227 Engine block heater ...196 Engine oil ...274 checking and...
...) ...50 Dipstick automatic transmission fluid ...301 engine oil ...274 Driveline universal joint and slip yoke ...300 Driving under special conditions through water ...224 E Electronic message center ...21 Emergencies, roadside jump-starting ...247 Emergency Flashers ...226 Emission control system ...296 Engine ...313 cleaning ...265 coolant ...280 diesel ...6 fail-safe cooling ...284 idle speed control ...277 lubrication specifications ...309 refill capacities ...309 service points ...272-273 starting after a collision ...227 Engine block heater ...196 Engine oil ...274 checking and...
Warranty Guide 6th Printing
Page 16
... cylinder heads, electrical fuel pump, electronic engine control unit, engine mounts, flywheel, injection pump, manifold (exhaust and intake), manifold bolts, oil pan, oil pump, seals and gaskets, thermostat, thermostat housing, timing chain cover, timing chain (gears or belt), turbocharger/supercharger unit, valve covers, water pump; 10 You have the option of having a tire warranty repair performed by the New Vehicle Limited Warranty, you should present your vehicle. For vehicles within the New Vehicle Limited Warranty time in which case a tire of the same brand, size, load, speed...
... cylinder heads, electrical fuel pump, electronic engine control unit, engine mounts, flywheel, injection pump, manifold (exhaust and intake), manifold bolts, oil pan, oil pump, seals and gaskets, thermostat, thermostat housing, timing chain cover, timing chain (gears or belt), turbocharger/supercharger unit, valve covers, water pump; 10 You have the option of having a tire warranty repair performed by the New Vehicle Limited Warranty, you should present your vehicle. For vehicles within the New Vehicle Limited Warranty time in which case a tire of the same brand, size, load, speed...
Warranty Guide 6th Printing
Page 17
... pressure sensor, 11 Rear-Wheel Drive: axle shafts, bearings (front and rear), center support bearing, drive axle housing (including all internal parts, intake and exhaust manifolds, timing gear, harmonic balancer, valve covers, oil pan and pump, water pump, fuel system (excluding fuel lines, fuel tank and frame mounted fuel conditioning module sometimes referred to a manufacturing defect in factory-supplied materials or factory workmanship. Transmission: all internal parts, clutch cover, seals and gaskets, torque converter, transfer case (including all internal parts), hubs-automatic...
... pressure sensor, 11 Rear-Wheel Drive: axle shafts, bearings (front and rear), center support bearing, drive axle housing (including all internal parts, intake and exhaust manifolds, timing gear, harmonic balancer, valve covers, oil pan and pump, water pump, fuel system (excluding fuel lines, fuel tank and frame mounted fuel conditioning module sometimes referred to a manufacturing defect in factory-supplied materials or factory workmanship. Transmission: all internal parts, clutch cover, seals and gaskets, torque converter, transfer case (including all internal parts), hubs-automatic...
Warranty Guide 6th Printing
Page 26
... are covered by both the Emissions Defect Warranty and the Emissions Performance Warranty. • Air Flow Sensor • Fuel Injection System • Air/Fuel Feedback Control • Fuel Injector Supply Manifold System and Sensors • Fuel Tank (non-diesel only) • Air Induction System • Fuel Tank Pressure Control • Catalytic Converters (including Valve Selective Catalytic Reduction • Idle Air Bypass Valve and Diesel Oxidation Catalysts) • Ignition Coil and/or Control • Cold Start Enrichment System Module (diesel only) • Intake Manifold •...
... are covered by both the Emissions Defect Warranty and the Emissions Performance Warranty. • Air Flow Sensor • Fuel Injection System • Air/Fuel Feedback Control • Fuel Injector Supply Manifold System and Sensors • Fuel Tank (non-diesel only) • Air Induction System • Fuel Tank Pressure Control • Catalytic Converters (including Valve Selective Catalytic Reduction • Idle Air Bypass Valve and Diesel Oxidation Catalysts) • Ignition Coil and/or Control • Cold Start Enrichment System Module (diesel only) • Intake Manifold •...
Warranty Guide 6th Printing
Page 32
...; Idle Air Bypass Valve • Ignition Coil and/or Control Module • Intake Manifold • Intercooler Assembly - Engine Charger (diesel and 2.0L EcoBoost engine only) • Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System • PCV System and Oil Filler Cap Secondary Air Injection System Spark Control Components Spark Plugs and Ignition Wires Synchronizer Assembly • Thermostat • Throttle Body Assembly (MFI) • Transmission Control Module (TCM) and Solenoids • Turbocharger Assembly • Vacuum Distribution System WHAT IS COVERED?
...; Idle Air Bypass Valve • Ignition Coil and/or Control Module • Intake Manifold • Intercooler Assembly - Engine Charger (diesel and 2.0L EcoBoost engine only) • Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System • PCV System and Oil Filler Cap Secondary Air Injection System Spark Control Components Spark Plugs and Ignition Wires Synchronizer Assembly • Thermostat • Throttle Body Assembly (MFI) • Transmission Control Module (TCM) and Solenoids • Turbocharger Assembly • Vacuum Distribution System WHAT IS COVERED?
Tire Warranty 2nd Printing
Page 3
... should present your vehicle or in which 1 For vehicles within the New Vehicle Limited Warranty time in factory supplied material or workmanship for wear or other than Ford dealer facilities. Ford, Lincoln, and Mercury New Vehicle Limited Warranty: One or more separate warranties apply to the following mileage-based Reimbursement Schedule: MILES DRIVEN PERCENT OF PARTS COVERED BY FORD FOR FORD AND MERCURY PASSENGER CARS AND LIGHT TRUCKS 1 - 12,000 -100...
... should present your vehicle or in which 1 For vehicles within the New Vehicle Limited Warranty time in factory supplied material or workmanship for wear or other than Ford dealer facilities. Ford, Lincoln, and Mercury New Vehicle Limited Warranty: One or more separate warranties apply to the following mileage-based Reimbursement Schedule: MILES DRIVEN PERCENT OF PARTS COVERED BY FORD FOR FORD AND MERCURY PASSENGER CARS AND LIGHT TRUCKS 1 - 12,000 -100...
Tire Warranty 2nd Printing
Page 48
... Mileage warranty is the only express warranty given by PTNA, applicable to Pirelli original equipment passenger car radial and light truck radial tires. To locate an authorized Pirelli Dealer in your area, look at the Dealer Locator on the Pirelli web site at www.us.pirelli.com This is not applicable to tires fitted as misalignment, defective brakes, defective shock absorbers...
... Mileage warranty is the only express warranty given by PTNA, applicable to Pirelli original equipment passenger car radial and light truck radial tires. To locate an authorized Pirelli Dealer in your area, look at the Dealer Locator on the Pirelli web site at www.us.pirelli.com This is not applicable to tires fitted as misalignment, defective brakes, defective shock absorbers...
Owner Guide 3rd Printing
Page 184
... repair required. 184 2011 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Remember that the first 500 miles (800 km) of towing be checked or changed unless a leak is removed from the water. Launching or retrieving a boat Disconnect the wiring to the trailer before starting on a grade. Replace the rear axle lubricant any combination of the rear axle lube used, do not tow a trailer for the lubricant specification. Tires, Wheels and Loading Trailer towing...
... repair required. 184 2011 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Remember that the first 500 miles (800 km) of towing be checked or changed unless a leak is removed from the water. Launching or retrieving a boat Disconnect the wiring to the trailer before starting on a grade. Replace the rear axle lubricant any combination of the rear axle lube used, do not tow a trailer for the lubricant specification. Tires, Wheels and Loading Trailer towing...
Owner Guide 3rd Printing
Page 202
... dealer. 202 2011 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Use wheel chocks if appropriate. Locate the brake-shift interlock solenoid underneath the steering column. 4. Apply the parking brake, and turn the ignition to remove the lower trim panel under the steering column. WARNING: When doing this procedure, you verify that the brake lamps are working properly, the following procedure will be working . To avoid unwanted vehicle movement, always...
... dealer. 202 2011 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Use wheel chocks if appropriate. Locate the brake-shift interlock solenoid underneath the steering column. 4. Apply the parking brake, and turn the ignition to remove the lower trim panel under the steering column. WARNING: When doing this procedure, you verify that the brake lamps are working properly, the following procedure will be working . To avoid unwanted vehicle movement, always...
Owner Guide 3rd Printing
Page 326
...; transmissions) Replace front wheel bearing grease/grease seals if non-sealed bearings are used (2WD vehicles) Every 60,000 miles Change transfer case fluid (4WD vehicles) (96,000 km) Replace spark plugs *If equipped with dual rear wheels, rotate front wheels when specified, rear wheels only if unusual wear is noted Operating in dusty conditions such as unpaved or dusty roads Inspect frequently, Replace cabin air filter (if equipped) service as required Replace engine air filter Every 5,000 miles Inspect wheels and...
...; transmissions) Replace front wheel bearing grease/grease seals if non-sealed bearings are used (2WD vehicles) Every 60,000 miles Change transfer case fluid (4WD vehicles) (96,000 km) Replace spark plugs *If equipped with dual rear wheels, rotate front wheels when specified, rear wheels only if unusual wear is noted Operating in dusty conditions such as unpaved or dusty roads Inspect frequently, Replace cabin air filter (if equipped) service as required Replace engine air filter Every 5,000 miles Inspect wheels and...
Owner Guide 3rd Printing
Page 327
... fluid (4WD vehicles) (96,000 km) *If equipped with grease fittings Replace cabin air filter (if equipped) Replace engine air filter Change engine oil and filter Inspect wheels and related components for abnormal noise, wear, looseness or drag Rotate tires*, inspect tire wear and measure tread depth Every 5,000 miles (8,000 km) 327 2011 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Scheduled Maintenance Operating in dusty conditions such as required Off-road operation Inspect steering linkage, ball joints and U-joints...
... fluid (4WD vehicles) (96,000 km) *If equipped with grease fittings Replace cabin air filter (if equipped) Replace engine air filter Change engine oil and filter Inspect wheels and related components for abnormal noise, wear, looseness or drag Rotate tires*, inspect tire wear and measure tread depth Every 5,000 miles (8,000 km) 327 2011 Econoline (eco) Owners Guide, 3rd Printing USA (fus) Scheduled Maintenance Operating in dusty conditions such as required Off-road operation Inspect steering linkage, ball joints and U-joints...
Owner Guide 3rd Printing
Page 336
... G Gas cap (see Fuel cap) ...277 Gas mileage (see Fuel economy) ...281 Gauges ...19 H Hazard flashers ...216 Headlamps ...51 aiming ...54 336 bulb specifications ...57 daytime running lights ...52 flash to pass ...51 high beam ...51 replacing bulbs ...58 turning on and off ...51 Head restraints ...86 Heating heater only system ...48, 50 heating and air conditioning system ...49 Hood ...260 I Ignition ...186, 303 Illuminated visor mirror ...64 Infant seats (see Safety seats) ...118 Inspection/maintenance (I/M) testing ...286 Instrument panel...
... G Gas cap (see Fuel cap) ...277 Gas mileage (see Fuel economy) ...281 Gauges ...19 H Hazard flashers ...216 Headlamps ...51 aiming ...54 336 bulb specifications ...57 daytime running lights ...52 flash to pass ...51 high beam ...51 replacing bulbs ...58 turning on and off ...51 Head restraints ...86 Heating heater only system ...48, 50 heating and air conditioning system ...49 Hood ...260 I Ignition ...186, 303 Illuminated visor mirror ...64 Infant seats (see Safety seats) ...118 Inspection/maintenance (I/M) testing ...286 Instrument panel...
Owner Guide 3rd Printing
Page 338
... ...304 Satellite Radio Information ...44 Scheduled Maintenance Guide Normal Scheduled Maintenance and Log ...318 Seats ...86 child safety seats ...118 cleaning ...256 front seats ...87 SecuriLock passive anti-theft system ...83 Servicing your vehicle ...259 Setting the clock ...30, 32 SOS Post Crash Alert ...108 Spare tire (see Changing the Tire) ...229 338 Spark plugs, specifications ...298, 303 Special notice ...7 ambulance conversions ...7 utility-type vehicles ...6 Specification chart, lubricants ...299 Speed control ...69 Stability...
... ...304 Satellite Radio Information ...44 Scheduled Maintenance Guide Normal Scheduled Maintenance and Log ...318 Seats ...86 child safety seats ...118 cleaning ...256 front seats ...87 SecuriLock passive anti-theft system ...83 Servicing your vehicle ...259 Setting the clock ...30, 32 SOS Post Crash Alert ...108 Spare tire (see Changing the Tire) ...229 338 Spark plugs, specifications ...298, 303 Special notice ...7 ambulance conversions ...7 utility-type vehicles ...6 Specification chart, lubricants ...299 Speed control ...69 Stability...