Troy-Bilt TB320 Support Question
Troy-Bilt TB320 Support Question
Find answers below for this question about Troy-Bilt TB320.Need a Troy-Bilt TB320 manual? We have 1 online manual for this item!
Question posted by jmstopp on July 24th, 2014
My Tb320bv Starts Great But Will Not Run At Full Speed Under Wide Open Throttle.
I have cleaned the fuel tank, fuel lines, air cleaner and spark arrestor. Carb butterfly is wide open but engine not running at full speed.
Current Answers
Related Troy-Bilt TB320 Manual Pages
Operation Manual - Page 1
.... 769-08410 (October 15, 2012) Safe Operation Practices • Set-Up • Operation • Maintenance • Service • Troubleshooting • Warranty
Operator's Manual
Self Propelled Mower -
Operation Manual - Page 2
... obligation. Choose from the options below: ◊ Visit us directly. It was carefully engineered to operating the equipment. Failure to do NOT return the machine to safely and easily set...not be found at www.opei.org or the engine manufacturer's web site. Please be sure that this manual is responsible for purchasing a Lawn Mower manufactured by standing at the operator's position and...
Operation Manual - Page 3
...3.
General Operation
6.
1.
Therefore, exercise extreme caution at least 75 feet from mower
to avoid discharge of California to operate this manual
to protect your mowing pattern to...the safe operation practices in this machine before operation. CALIFORNIA PROPOSITION 65
WARNING: Engine Exhaust, some of age to cause cancer and reproductive harm.
replacement parts.
...
Operation Manual - Page 4
... vibrate abnormally, stop before operating this manual and on the machine and be trained and supervised by the manufacturer. Walk, never run into the mower.
5. Only use care and good judgement. When starting engine.
17. If situations occur which can cause serious personal injury. If the slope is a safety device.
Tall grass can cause...
Operation Manual - Page 5
... setting or over fill fuel tank. Never over -speed the engine. Engine exhaust contains carbon monoxide, an odorless and deadly gas.
2. According to another area. Never tamper with safety devices. Gasoline is complete. Use only an approved gasoline container.
3. Clean up . Wrap the blade or wear gloves, and use a nozzle lock-open flame, spark or pilot light as...
Operation Manual - Page 6
...states may include the following emission control systems: Engine Modification (EM), Oxidizing Catalyst (OC), Secondary Air Injection (SAI) and Three Way Catalyst (TWC) if so equipped. Box 361131 Cleveland, Ohio 44136-0019.
6
Section 2 - Important Safe Operation Practices Spark Arrestor
WARNING: This machine is equipped with a spark arrestor meeting applicable local or state laws (if any...
Operation Manual - Page 7
... understand and follow the warnings and instructions in this product.
HOT SURFACE Engine parts, especially the muffler, become extremely hot during operation.
Do not mow slopes ...176;. WARNING-GASOLINE IS FLAMMABLE Allow the engine to cool before refueling.
CARBON MONOXIDE Never run an engine indoors or in its proper place.
Allow engine and muffler to cool at least two ...
Operation Manual - Page 8
... Always mow across the face of slopes, never up or down slopes. Remove this page and fold along the dashed line. 2. Adjust gauge up and down until the left corner touches the slope (See Figure 1 and Figure 2). 5. ...
(OK) Figure 1
15° Slope
(TOO STEEP) Figure 2
15° Slope
15° dashed line
USE THIS SLOPE GAUGE TO DETERMINE IF A SLOPE IS TOO STEEP FOR SAFE OPERATION!
Operation Manual - Page 9
... remove adjacent hex head screws. A
b.
B
A
Figure 3-1
Figure 3-2
9 Assembly & Set-Up
3
Contents of Carton
• One Lawn Mower
•
• One Lawn Mower Operator's Manual •
One Grass Catcher One Engine Operator's Manual
• One Bottle of the handle.
While stabilizing mower so it doesn't move, pivot upper handle up and make sure they go on the...
Operation Manual - Page 10
c.
until holes in lower handle (shown in Figure 3-3 deck
cutaway) line up with holes in place. Figure 3-4.
C
Figure 3-6 a. d. Assembly & Set-Up
See Figure 3-4.... lower handle and tighten securely to secure the handle in handle bracket. b. Remove the T-bolts from engine and slip
starter rope into lower holes of the upper handle. Pull upward on handle, make sure ...
Operation Manual - Page 11
... hooks on the grass catcher.
On the side of mower. Lift rear discharge door. Let go of the slots in Figure 3-8. Side Discharge Chute
Your mower is closed. 1. Follow steps below to attach grass... will be on mulching plug assembly. To remove grass catcher, lift rear discharge door on the mower. Lower the mulching plug. Assembly & Set-Up
11 Release rear discharge door to allow it...
Operation Manual - Page 12
...the handle in the
separate engine owner's manual. You will ... oil provided before starting unit for a change...mower does not propel itself with the drive control engaged or if the mower's wheels hesitate with wing nuts and carriage bolts removed earlier.
Refer to the separate engine owner's manual for additional engine...engine with gasoline as follows: 1. Gasoline is located above the rear left...
Operation Manual - Page 13
... with a water port on top of the mower.
Stand behind the unit and pull the recoil starter rope to bypass its surface as a mulcher.
Never attempt to start the unit.
13
Squeeze it against the upper... release it to the upper handle of the upper handle and is used to slow down or stop engine and blade. WARNING: Keep hands and feet away from the chute area on the unit. Refer to...
Operation Manual - Page 14
... object, stop the engine. Repeat until engine cranks. Stopping Engine
1. Using Your Lawn Mower
Be sure lawn is standing near the lawn mower while starting engine or operating mower.
Make sure that the unit has come to a complete stop the engine and blade. Lift discharge door and pull grass bag up and away from the spark plug, thoroughly inspect mower for any direction and...
Operation Manual - Page 15
... spark plug wire. Scrape and clean the underside of the deck with light oil.
Hold mower firmly. Keep the side with the air cleaner facing up of the engine causing a starting problem.
3. Oil can drain into the upper part of grass clippings or other debris. Lubrication
1. Follow the accompanying engine manual for lubrication schedule and instruction for this lawn mower...
Operation Manual - Page 16
... such as STA-BIL® to thoroughly dry.
16
Section 6- To service the air cleaner, refer to stop the engine and blade.
8.
Run the engine for your deck, restart the mower. CAUTION: Make certain the mower's discharge chute is recommended at the start of the engine clean to the water port on essential carburetor parts. Attach the hose coupler to...
Operation Manual - Page 17
... grease to prevent rusting.
• Refer to engine manual for correct engine storage instructions.
• Secure side discharge chute to handle as fertilizer. Using a light oil or silicone, coat the equipment, especially cables and all moving parts of your lawn mower for storage.
• Clean and lubricate mower thoroughly as described in the lubrication instructions.
•...
Operation Manual - Page 18
... top of engine. 1. Fill tank with primer).
5. Clean, adjust gap, or replace. 6. Open fuel valve. Clean fuel line; Adjust gap to engine manual. 6. See an authorized service dealer. Burnt fuse. (Electric Start only) 1. Engine oil level low. 2. Prime engine as instructed in fuel system. 5. See engine manual. 10. Spark plug fouled, faulty, or gap too wide. 2. Engine not primed...
Operation Manual - Page 19
... and replace belt.
4. Wheels not positioned correctly.
2. Remedy
1. Sharpen or replace blade. 1. Place front and rear wheels in same height
position.
2. Stop engine, disconnect spark plug boot, and clean out debris.
3. Problem
Mower will not self propel
3. Section 8 - Wet grass. 2. Check belt for proper pulley installation and movement.
2.
Belt not installed properly.
2.
Operation Manual - Page 22
... sun, rain and dust damage. Coated for quick, easy starts. Prevents grass clippings buildup in mowing deck.
22
Section 10 - Attachments & Accessories Keeps stored fuel fresh for maximum water resistance and repellency. Prevents gum and varnish.
490-290-0012
Mower Cover - Long-Lasting anti-stick graphite spray. Component
Model Number and Description
22216...
Similar Questions
Does The Tb230 Have A Fuel Filter.
My lawn mower running rough. I cleaned the air filter. new spark plug. cleaned plug nut at bottom of...
My lawn mower running rough. I cleaned the air filter. new spark plug. cleaned plug nut at bottom of...
(Posted by guitod 2 years ago)
1 Yr Old Tb320 Starts, Runs Rough Backfires To The Point Of Flames, Help.
(Posted by whatsgood2k13 4 years ago)
I Purchased A Tb330 This Spring And Love, But Now It Starts Hard, Runs Rough, Th
dies. It ran out of gas and I filled with regular (up to that point I used premium). I drained the t...
dies. It ran out of gas and I filled with regular (up to that point I used premium). I drained the t...
(Posted by timhatfi 8 years ago)
Cut Is Uneven, Blade Is Sharp Wheels Are Even. Not Even On Raise And Lowering
Won't mow evenly
Won't mow evenly
(Posted by treksterjsc 9 years ago)
Troy Bilt Tb 320 Bv 31 Cc No Spark. Does Not Start
no spark, does not start
no spark, does not start
(Posted by visakay 11 years ago)