Troy-Bilt TB320 Support Question
Find answers below for this question about Troy-Bilt TB320.Need a Troy-Bilt TB320 manual? We have 1 online manual for this item!
Question posted by visakay on May 3rd, 2013
Troy Bilt Tb 320 Bv 31 Cc No Spark. Does Not Start
no spark, does not start
Current Answers
There are currently no answers that have been posted for this question.
Be the first to post an answer! Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.
Be the first to post an answer! Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.
Related Troy-Bilt TB320 Manual Pages
Operation Manual - Page 1
... COMPLY WITH THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY. BOX 361131 CLEVELAND, OHIO 44136-0019
Form No. 769-08410 (October 15, 2012)
Printed In USA
TROY-BILT LLC, P.O. Model Series VC3X
WARNING
READ AND FOLLOW ALL SAFETY RULES AND INSTRUCTIONS IN THIS MANUAL BEFORE ATTEMPTING TO OPERATE THIS MACHINE. Safe Operation Practices...
Operation Manual - Page 2
..., for purchasing a Lawn Mower manufactured by standing at the operator's position and looking down at all engine-related issues with a local authorized service dealer. Troy-Bilt's Customer Support telephone... obligation. We want to ensure your machine. You can locate the model plate by Troy-Bilt. If you have difficulty assembling this manual may cover a range of Contents
Safe Operation...
Operation Manual - Page 3
... cause cancer and reproductive harm. To help avoid blade contact or a thrown object injury,
not a plaything. Therefore, exercise extreme caution at least 75 feet from mower
to observe the following safety instructions could be trained and supervised
cause serious injury to operate this machine.
weight (e.g. canvas) shoes.
11.
CALIFORNIA PROPOSITION 65...
Operation Manual - Page 4
... immediately and the blade will stop rotating within three (3) seconds. Always be trained and supervised by an adult.
4
Section 2 - c. When starting engine.
17. Rapid retraction of the mower being pulled over should start to rotate for small children.
4. Do not mow on slopes.
2. Keep children out of the mowing area and under watchful...
Operation Manual - Page 5
...safety systems are explosive. If gasoline is running . Wait 5 minutes before starting and operating the mower.
8.
Before cleaning, repairing, or inspecting, make a wheel or cutting ...blade with safety devices. For safety protection, frequently check components and replace immediately with spark plug removed.
13. Do not crank engine with original equipment manufacturer's (O.E.M.) parts...
Operation Manual - Page 6
..., brush covered or grass-covered land unless the engine's exhaust system is available through your nearest engine authorized service dealer or contact the service department, P.O. A spark arrestor for SORE (Small Off Road Equipment) are certified to comply with California and federal EPA emission regulations for the muffler is equipped with an...
Operation Manual - Page 9
...Figure 3-1. Remove wing nuts and carriage bolts from handle as shown in the accompanying engine manual BEFORE operating your mower.
B
A
Figure 3-1
Figure 3-2
9 a. A
b.
Assembly & Set-Up
3
Contents of Carton
• One Lawn Mower
•
• One Lawn Mower Operator's Manual •
One Grass Catcher One Engine Operator's Manual
• One Bottle of the handle.
Handle...
Operation Manual - Page 11
...Make certain bag is closed. 1. To convert to side discharge, make sure grass catcher is off of mower.
Figure 3-9
2. a. Slip plastic channel of grass bag over frame so that it to allow it ...To remove grass catcher, lift rear discharge door on mulching plug assembly. Let go of the mower, lift the side mulching plug.
Release rear discharge door to close rear opening of the slots...
Operation Manual - Page 12
... not propel itself with the drive control engaged or if the mower's wheels hesitate with the drive control engaged. Remove wing nuts and ...gasoline as instructed in one of the handle as follows: 1. Gasoline is most comfortable. Add oil provided before starting unit for the first time out
of these conditions occur, rotate adjustment wheel clockwise to tighten cable or counterclockwise...
Operation Manual - Page 13
... cutting height, refer to start the unit.
13
Drive Control
Side Discharge Chute
Your mower is shipped as part of its deck wash system. release it to stop mower from propelling.
Stand behind ...drive control is located on the unit. Refer to warning label on top of the mower. Recoil Starter
The recoil starter is attached to attach the side discharge chute. To discharge...
Operation Manual - Page 14
...blade control to stop the engine.
Once the engine is standing near the lawn mower while starting engine or operating mower. If the grass has been allowed to grow in foreign objects being thrown...Set-Up" section. Lift discharge door and pull grass bag up and away from the spark plug, thoroughly inspect mower for help with a rapid, continuous, full arm stroke. Dispose of four inches, mulching...
Operation Manual - Page 15
... on your machine. If you had put plastic under the gas cap.
2. WARNING: Always stop engine, disconnect spark plug, and ground against engine before performing any length of time. This control must maintain the lawn mower as instructed here.
• Changing of plastic under the gas cap earlier, make sure these are tight...
Operation Manual - Page 16
... Follow the accompanying engine manual for good performance by the mower is recommended at the start of its deck wash system. Spark plug replacement is given below.
After cleaning your house, ....
3. Push the mower to a level, clear spot on your lawn, near enough for correct plug type and gap specifications.
• Clean engine regularly with your mower's Operator's Manual) ...
Operation Manual - Page 17
... Balance the blade on a round shaft screwdriver to have your belt replaced. Remove metal from spark plug. WARNING: An unbalanced blade will cause
excessive vibration when rotating at high speeds. blade marked...care should be removed in .
When sharpening the blade, follow the original angle of your lawn
mower before storage.
17 It may cause damage to torque: 450 in order to the engine ...
Operation Manual - Page 18
... CHOKE knob in gas cap plugged. 4. Dirty air cleaner. 1. See an authorized service dealer. Fuel tank empty or stale fuel. 4. Burnt fuse. (Electric Start only) 1. Refer to engine manual. 1. Spark plug boot disconnected. 3. Water or dirt in the Operation
section. 5. Connect wire to restart, but do not
prime. 8. Clean fuel line. 7. Wait...
Operation Manual - Page 19
... & Set-up section). Wheels not positioned correctly.
2. Inspect and replace belt.
4. Problem
Mower will not self propel
3.
Damaged or worn belt. 4.
Mow once at a high cutting ...Wet grass. 2. Belt not installed properly.
2. wait until later to cut Mower will not mulch grass
Cause
1. Stop engine, disconnect spark plug boot, and clean out debris.
3. Dull blade. 1. Remedy
1. ...
Operation Manual - Page 20
Replacement Parts
Component
9
Part Number and Description
BS-591868
Spark Plug
BS-491588S BS-493537S
Air Filter Cartridge Pre-Cleaner
BS-799585 BS-796577
Fuel Tank Cap Fuel Tank Cap
634-04660 634-05042
Wheel (...
Operation Manual - Page 21
SPW-134
Spark Plug Wrench - Easy installation with no tools.
490-850-0015
Cargo Carrier - Attaches in place for faster, safer removal. Projects garage floor form stains.
490-850-0012
Mower Kick Stand - Keeps mower stable for separate blower. Attachments & Accessories
Component
10
Model Number and Description
490-850-0005 Blade Removal Tool - Blows...
Operation Manual - Page 22
... ethanol-induced attraction. Long-Lasting anti-stick graphite spray. Keeps stored fuel fresh for maximum water resistance and repellency. Coated for quick, easy starts. Prevents gum and varnish.
490-290-0012
Mower Cover - Prevents grass clippings buildup in mowing deck.
22
Section 10 - Treats 80 gallons of fuel. Attachments & Accessories Protects your...
Operation Manual - Page 24
....com. HOW TO OBTAIN SERVICE: Warranty service is available, WITH PROOF OF PURCHASE, through Troy-Bilt's authorized channels of export distribution. In Canada
Contact MTD Products Limited, Kitchener, ON N2G 4J1...consequential loss or damage including, without limitation, expenses incurred for substitute or replacement lawn care services or for whom it was purchased as set forth in this product...
Similar Questions
Will The Carburetor From A Tb 200 Work On A Tb320
(Posted by charlestyler896 9 months ago)
Emergency Brake And Gears On Troy Bilt Tb30
I have a Troy Bilt TB30. My emergency brake won't go all the way down and my Gear is stuck in 4th. M...
I have a Troy Bilt TB30. My emergency brake won't go all the way down and my Gear is stuck in 4th. M...
(Posted by mirandasmoon1 2 years ago)
Where Does The Primer Bulb Hose Connect To On A Troy Bilt Tb 554 Edger???thank
(Posted by Keviedog 2 years ago)
Spark Plug Oil/fuel Ratio?
What is the spark plug gap for my TB22ec weed eater?Also the oil/fuel ratio?
What is the spark plug gap for my TB22ec weed eater?Also the oil/fuel ratio?
(Posted by rondaniels609 6 years ago)