Toshiba 65HM167 Support Question
Toshiba 65HM167 Support Question
Find answers below for this question about Toshiba 65HM167 - 65" Rear Projection TV.Need a Toshiba 65HM167 manual? We have 3 online manuals for this item!
Question posted by rbaldene84420 on December 16th, 2011
Toshiba Lamp Ballast
how difficult is it to replace the lamp ballast on a 65hm167 model?
Current Answers
Answer #1: Posted by TVDan on December 16th, 2011 7:41 PM
TVDan
Member since:
August 8th, 2011 Points: 4,732,000
Member since:
August 8th, 2011 Points: 4,732,000
It is time consuming since you will need to spin the optical engine into a serviceable position. this will require the signal section to be loosened, the wire holders released on the far left side (as viewed from the rear), the three supports posts removed, a cover around the lens assembly and the triangle piece over the lamp area. Once these are removed the carefully spin the signal and engine clockwise together since the wires attaching the two are short. Care must be taken when the engine is move that the two wires that go to the lamp door interlock switch that is routed over the lamp area (under the triangle piece removed earlier) doesn't snag and come unplugged on either end. As you are spinning the engine you will see behind where the lamp is placed there is a sheet of metal, and behind it is the ballast. You will need to disassemble the lamp holding area to free the wires that come from the ballast and mate with the lamp cartridge. I suggest you take your time, and go from start to finish in the same day, as well as keeping the screws in piles as you complete a step.
TV Dan
Related Toshiba 65HM167 Manual Pages
Printable Spec Sheet - Page 1
...technology from Texas Instruments, and advanced optics, Toshiba micro-display projection TVs bring home the quality of 720p HD models, Full HD creates the pinnacle in picture quality.
PRELIMINARY
65HM167
65" Diagonal 1080p DLP® TV
shown on optional stand ST6587
1080p Full HD... resolution of the big theater screen experience. The Radiance150™ lamp produces bright, clear images.
Service Manual - Page 1
... Consumer Products National Service Division website at:
www7.toshiba.com
This model is classified as a green product (*1), as indicated by the underlined serial number. For (*1) and (*2), refer to GREEN PRODUCT PROCUREMENT and LEAD-FREE SOLDER.
© TOSHIBA CORPORATION 2008 SERVICE MANUAL
Projection Television
65HM167
Rev.1
For Technical Bulletins, Technical Tips, or other information...
Service Manual - Page 6
... REDUCE THE RISK OF ELECTRIC SHOCK, NEVER REMOVE TV COVERS, EXCEPT AS SPECIFIED HEREIN. The lamp has a limited service life that increases during use projection lamps as excessive mechanical abuse or handling by this happens). As is subjected to follow this TV is replaced. The strength of the lamp in the colors and/or brightness of the...
Service Manual - Page 8
....toshiba.ca; NOTE: The lamp unit contains mercury. Plug in the TV cabinet.
8.
however, if the lamp unit is installed securely;
For disposal or recycling information, contact your web browser to insert the hooks on
NOTE: If, after repeating steps 1-9, the problem still exists:
x In the U.S., call TACP Consumer Solutions at 1-800-631-3811. Replace...
Service Manual - Page 17
...
WARNING: All application and program data will be upgraded. LED Indication During the Software Updating Three LED indicators show the updating progress or status. x
After replacing SEINE or Main unit, perform the following .
16
DO NOT upgrade while the...
Owners Manual - Page 1
... TV, see "IMPORTANT NOTICE ABOUT HOT LAMP RESTART" on page 6.
© 2007 TOSHIBA CORPORATION All Rights Reserved
Owner's Record The model number and serial number are on -screen. Model number: Serial number:
YC/N VX1A000391A0
HM67 (E/F) Web 213:276 50HM67_EN.book Page 1 Thursday, March 29, 2007 11:28 AM
Integrated High Definition DLP® Projection Television
50HM67 57HM167 65HM167...
Owners Manual - Page 2
...user settings. See "Lamp unit replacement and care" in this Toshiba TV.
CAUTION: This television is intended to alert the user...lamp may fall over . Dispose of resulting in the literature accompanying the appliance. As a result, TVs may rupture.
Toshiba Cares!
WARNING
RISK OF ELECTRIC SHOCK DO NOT OPEN. Television Stand Model
50HM67
ST 5067
57HM167
ST 57167
65HM167...
Owners Manual - Page 3
...television. • ALWAYS contact a service technician to inspect the TV any vertical surface (such as radiators, heat registers, stoves, or other apparatus (including amplifiers) that no objects filled with liquids, such as specified in the "Lamp unit replacement... to project the picture, and requires special safety precautions: • See Chapter 9 for replacement of possible TV stand ...
Owners Manual - Page 4
... not specified in safe operating condition. Antenna lead-in Chapter 9. If this happens, turn off the TV for your TOSHIBA TV, follow this WARNING may rupture. Do not spray volatile compounds, such as specified in the "Lamp unit replacement and care" section in wire
Ground clamp
Antenna discharge unit (NEC Section 810-20)
Electric service...
Owners Manual - Page 5
..., 57HM167, and 65HM167 Televisions comply with the limits for help. 50HM67_EN.book Page 5 Thursday, March 29, 2007 11:28 AM
39) When the TV reaches the end of its useful life, ask a qualified service technician to properly dispose of the FCC rules. Note: The lamp unit contains mercury. Operation is : Toshiba America Consumer Products, L.L.C. 82...
Owners Manual - Page 6
...replace the lamp unit (- page 62).
9) Every time the TV power cord is plugged in eye fatigue.
Trademark Information
• WOW, SRS and l symbol are registered trademarks of precision technology; 50HM67_EN.book Page 6 Thursday, March 29, 2007 11:28 AM
Important notes about your DLP® projection TV...blinking. "Lamp unit replacement and care" on pages 63-65).
2) When the lamp mode is ...
Owners Manual - Page 7
..., 2007 11:28 AM
Contents
Chapter 1: Introduction 9 Welcome to Toshiba 9 Features of your new TV 9 Overview of steps for installing, setting up, and using your new TV 10 TV front and side panel controls and connections 11 TV back panel connections 12
Chapter 2: Connecting your TV 13 Overview of cable types 13 About the connection illustrations...
Owners Manual - Page 8
... PM
Chapter 9: Appendix 63 Lamp unit replacement and care 63 Replacing the lamp unit (User-replaceable component 63 When to replace the lamp unit 63 How to replace the lamp unit 64 Disposing of the used lamp unit 65 Specifications 66 Limited United States Warranty for DLP® Television Models 67 Limited Canadian Warranty for Toshiba Brand DLP® Television Models 68
Index 71
8
HM67...
Owners Manual - Page 9
... result in instability, causing possible injury or death. This digital television is required to a cable system providing such programming.
page 13).
• Channel Labeling allows you to Toshiba
Thank you 're watching (- Use with the TOSHIBA TV stand listed in most innovative DLP® projection TVs on the market.
Certain advanced and interactive digital cable services...
Owners Manual - Page 10
...® projection
TV" (- pages 11-12).
5 Connect your TV and other
device(s) (- page 29).
12 Program channels into the TV's channel memory
(- page 6).
• Place the TV on the applicable optional TV stand listed in the "Specifications" section (if available for your other electronic device(s) to the Troubleshooting Guide, Chapter 8. 15 For lamp unit replacement instructions, see...
Owners Manual - Page 60
... to reduce visible interference in rare instances, when viewing certain content (e.g..
television broadcasts, video games, DVDs), you cannot turn on the TV, the lamp will start out in High Bright mode but not powered on -screen. TV stops responding to controls • If the TV stops responding to the controls on the remote control or...
Owners Manual - Page 62
...lamp is not working "
"Lamp door is open." The lamp is not working properly after trying the solution, the problem still exists:
• In the U.S., call TACP Consumer Solutions at 1-800-631-3811. • In Canada, locate the nearest Toshiba...Consumer Solutions at 1-800631-3811 in Canada. Review "Lamp unit replacement and care" in again and turn ON the TV. Plug the power cord in Chapter 9 to ...
Owners Manual - Page 63
... colors and/or brightness of the lamp in this TV was designed for safe replacement by Toshiba may rupture (often making a loud noise when this TV is warranted only for this happens). The lamp has a limited service life that increases during use projection lamps as applicable. Note : The lamp is a mercury lamp with all projection TVs that can affect the useful service...
Owners Manual - Page 64
... 9: Appendix
How to follow this lamp.
Failure to replace the lamp unit
WARNING: RISK OF ELECTRIC SHOCK!
The lamp unit door is fully seated.
64
HM67 (E/F) Web 213:276 "Disposing of the used lamp unit" on page 65).
50HM67
3 On the lamp unit door on the lamp unit. Always turn off the TV and unplug the power cord. Failure...
Owners Manual - Page 65
...
65
HM67 (E/F) Web 213:276 Hand-tighten using a manual
screwdriver. If any
type of the lamp unit door inside the TV cabinet opening in this TV was designed for safe replacement ...3811. • In Canada, locate the nearest Toshiba authorized
service depot by the approved method for at certain temperatures.
CAUTION: NEVER clean a hot lamp with care. click "Home Entertainment," and then ...
Similar Questions
Toshiba 65hm167 Rear Projection Tv Black Dots On Sceen That Move
toshiba 65hm167 rear projection tv its old but has low hours. i movied in the back of an open truck....
toshiba 65hm167 rear projection tv its old but has low hours. i movied in the back of an open truck....
(Posted by m7xg7x 3 years ago)
Will Cleaning Any Part Of Toshiba 65 Rear Projection Hd Dlp Tv Get Rid Of White
dots
dots
(Posted by amlaet 10 years ago)
Toshiba Model#50a11 50' Rear Projection Tv Picture Went Black
Toshiba model #50A11 50" rear projection TV - pictuer suddenly went black. Has good audio, but no vi...
Toshiba model #50A11 50" rear projection TV - pictuer suddenly went black. Has good audio, but no vi...
(Posted by rfv57 11 years ago)
Toshiba 65hm167 65' Rear Projection Tv
what's wrong with my tv, the picture is full with little stars. I could still watch tv.
what's wrong with my tv, the picture is full with little stars. I could still watch tv.
(Posted by fernandobriceno25 12 years ago)
Toshiba Model 65hm167 65' Rear Projection
1000 white pixels are showing upon the screen with more growing every day. I know numerous other pe...
1000 white pixels are showing upon the screen with more growing every day. I know numerous other pe...
(Posted by srury 12 years ago)