Poulan PBGT22H54 Support Question
Poulan PBGT22H54 Support Question
Find answers below for this question about Poulan PBGT22H54.Need a Poulan PBGT22H54 manual? We have 1 online manual for this item!
Question posted by fspann1058 on April 21st, 2013
Will Not Go Forward Or Reverse
I washed my Poulan Pro off real good, started it up, drove it into my storage shed. A week went by I started it up, now it will not gor forward or reveerse. I check the most obivous thifn, still no movement. Is there a fuze or switch that might have got wet? Is ther a cable that might have got loose during the washsing? I put on a new motioin belt last year so that shuld be good.
Current Answers
Related Poulan PBGT22H54 Manual Pages
User Manual - Page 1
Failure to do so can result in U.S.A. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com
405035 Rev.1 03.07.06 TR/VB Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
03090
OPERATOR'S MANUAL
MODEL:
PBGT22H54
LAWN TRACTOR
WARNING:
Read this Manual and follow all Warnings and Safety Instructions.
User Manual - Page 2
... only in daylight or good artificial light....
• Keep all movement on all parts to ... is clear of bystanders before starting , stopping, or turning on... speed when on the ground. Wash hands
tip-over .
•...not across. Tires can result in reverse unless absolutely necessary. I.
instructions,...could be picked up and down before storage. FAILURE TO OBSERVE THE FOLLOWING SAFETY ...
User Manual - Page 3
... have to stop or shift while on the slope.
• Avoid starting, stopping, or turning on a truck or trailer bed with manufacturer's ... or repairs with the engine running. • Check grass catcher components and the discharge guard frequently and... the weight of the towed equipment may suddenly appear in reverse unless absolutely necessary.
Always look behind and down for small...
User Manual - Page 4
...
W/ Filter: 4.0 Pints W/O Filter: 3.75 Pints
Spark Plug: (Gap: .040")
Champion QC12YC
Ground Speed (MPH):
Forward: Reverse:
0 - 5.8 0 - 2.1
Charging System:
16 AMPS @ 3600 RPM
Battery:
AMP/HR: MIN. A spark arrester... 10-16 MAINTENANCE SCHEDULE 17
MAINTENANCE 17-20 SERVICE AND ADJUSTMENTS 21-25 STORAGE 26 TROUBLESHOOTING 27-28 WARRANTY 30
4
The instructions will enable you the...
User Manual - Page 6
...attachment lift lever to "STOP" position.
CHECK BATTERY (See Fig. 1)
• Lift hood to idle (slow) position.
• Release parking brake.
• Slowly depress forward drive pedal and drive tractor off the ...flat.
• Remove mower and packing materials. • Check for charging instructions). WARNING: Before starting, read, understand and follow .
6 TO ROLL TRACTOR OFF SKID (...
User Manual - Page 7
...mower bracket (D). D
02965
FIG. 4
• Remove plastic tie securing belt, bring belt forward and check belt for additional guidance on this assembly. Be sure tractor is on level surface and engage ...to insert bar.
- A
FIG. 5
NOTE: Be sure mower side suspension arms (A) are pointing forward before sliding mower under tractor. • Slide mower under tractor until it is spring loaded.Have ...
User Manual - Page 8
...ATTACH REAR LIFT LINKS (C) -
Work from locking bracket (L).
• Install belt onto engine clutch pulley (M). IMPORTANT: Check belt for proper routing in tractor lift shaft suspension arm (L) and pivot link down to position wheels straight forward.
• ATTACH FRONT LINK (E) - D
FIG. 9
L K
B M
A
F
E H
S
C D
FIG. 11
8 L
C
F
G
7/16
FIG. 10
• Disengage belt tension rod...
User Manual - Page 9
... FOLLOWING CHECKLIST:
✓ All assembly instructions have been completed.
✓ No remaining loose parts in safe operating condition. ✓ Be sure Operator Presence System and Reverse Op-
CHECK BRAKE SYSTEM
After you start the engine.
✓ Be sure brake system is spring loaded.
User Manual - Page 10
...
LOW
CHOKE
FAST
SLOW
IGNITION SWITCH
ENGINE OFF REVERSE OPERATION
SYSTEM (ROS)
ENGINE ON
ENGINE START
PARKING BRAKE
MOWER HEIGHT
MOWER LIFT
LIGHTS ON
FUEL BATTERY
REVERSE
FORWARD
CRUISE CONTROL
CLUTCH/BRAKE PEDAL
15
15
ATTACHMENT
ATTACHMENT
CLUTCH DISENGAGED CLUTCH ENGAGED
DANGER, KEEP HANDS AND FEET AWAY
KEEP AREA CLEAR
SLOPE HAZARDS
(SEE ...
User Manual - Page 11
Used to engage the mower blades, or other powered attachment while in reverse.
(H) LIGHT SWITCH - Used for braking the tractor and starting the engine. (C) PARKING BRAKE - Used for forward movement of various controls and adjustments. Locks clutch/brake pedal into the brake position. (D) THROTTLE CONTROL - Allows operation of tractor at desired speed without holding the...
User Manual - Page 12
... gases may cause engine to "backfire".
• Turn ignition key (F) to begin movement. IMPORTANT: Leaving the ignition switch in any attempt by the forward and reverse drive pedals.
• Start tractor and release parking brake.
• Slowly depress forward (K) or reverse (L) drive pedal to "STOP" position and remove key. TO USE CHOKE CONTROL -D (See...
User Manual - Page 13
... (A) determines the cutting height.
• The average lawn should be mowed twice. The heights are slightly off the...must remain fully and centrally positioned in proper position to 4". Start mower blades by the operator to desired cutting height (See ... Do not operate the mower without either the entire grass catcher, on forward drive pedal. OPERATION
J
K
L
FIG. 17
TO USE CRUISE CONTROL...
User Manual - Page 14
... operator decides it is in any slope.
• Choose the slowest speed before and while backing.
• Slowly depress reverse drive pedal to start movement.
• When use if you to travel in reverse unless absolutely necessary. NOTE: To protect hood from damage when transporting your tractor.
14 Use an appropriate means of this...
User Manual - Page 16
...8226; Sitting in the tractor seat, start engine. Disengage parking brake.
• Drive tractor forward for approximately five feet then ...TO TRANSPORT" in this procedure there will be no movement of drive wheels. Repeat this section of this driving... better mowing performance and proper discharge of the machine. Depress reverse drive pedal to slow position. off engine and set parking...
User Manual - Page 18
...tire dry rot and corrosion. ROS "ON" Position
Engine "ON" Position (Normal Operating)
02828
CHECK REVERSE OPERATION (ROS) SYSTEM • When the engine is running with star on mandrel assembly. &#...64257;rst then RED bat-
CHECK OPERATOR PRESENCE SYSTEM • When the engine is running, any attempt by the operator to leave the seat should not start unless the brake pedal is fully...
User Manual - Page 22
... until both sides are sharp.Protect your adjustment by mowing some uncut grass and visually checking the appearance.
A
Turn nut right to raise mower
02948
FIG. 28
Turn nut ... position blade at front and rear tip of the blade.
• If front tip of blade is pointing straight forward.
PRECISION SIDE-TO-SIDE ADJUSTMENT (See Fig. 29) • With all tires properly inflated, park ...
User Manual - Page 24
... the BLACK cable (D) to good chassis ground, away from your battery is too weak to start the engine, it is held...end of the BLACK cable to be serviced. TO REMOVE CABLES, REVERSE ORDER • BLACK cable first from chassis and then...START ENGINE WITH A WEAK BATTERY (See Fig. 35)
FIG. 33
TO CHECK BRAKE
If tractor requires more than five (5) feet to manually push the tractor forward...
User Manual - Page 25
... preset at sides, tilt toward
engine and lift off of tractor. • To replace, reverse above procedure. SERVICE AND ADJUSTMENTS
REPLACING BATTERY (See Fig. 36)
WARNING: Do not short battery...a wrench or any other object to run poorly, stop running, or prevent it from starting. • Check wiring.
TO ADJUST CARBURETOR
Your carburetor is located behind the dash.
Grasp hood at the ...
User Manual - Page 28
.../uneven tire air pressure.
5. Replace mower drive belt.
9. grass, leaves, and trash around mandrels to open vent holes. Light switch is shifted into reverse
CAUSE
1. Loose or damaged wiring. 5. Check/replace light switch. 4. Replace fuse. Bad battery cell(s). 2. Faulty regulator (if so equipped). 4. Replace regulator. 4. Engine throttle control not set between half...
User Manual - Page 32
... Manual, please contact your local dealer for parts and service should be necessary during the life of Electrolux Home Products is to our website: www.poulan-pro.com/support.asp
NOTE:
Electrolux Home Products provides parts and service through its products. Number b. PARTS AND SERVICE
This product has been expertly engineered and...
Similar Questions
Auger Does Not Spin
I installed new auger belt but as soon as weight of snow gets in it stops spinning, Why
I installed new auger belt but as soon as weight of snow gets in it stops spinning, Why
(Posted by shinipu04 7 years ago)
How Do I Place Freewheel Control In â??engagedâ?? Position
Was mowing and it just stopped while backing up, won't go forward or backward at this time
Was mowing and it just stopped while backing up, won't go forward or backward at this time
(Posted by femamax 8 years ago)
Poulan Pro 380 Zero Turn Mower Will Not Move
new drive belt on tranmission but mower not moving properly. moved good at first but moved slow afte...
new drive belt on tranmission but mower not moving properly. moved good at first but moved slow afte...
(Posted by bewilliams 9 years ago)