KitchenAid KGRS505XSS Support Question
KitchenAid KGRS505XSS Support Question
Find answers below for this question about KitchenAid KGRS505XSS.Need a KitchenAid KGRS505XSS manual? We have 3 online manuals for this item!
Question posted by cmgrzadz on March 5th, 2015
Natural To Lp Conversion
There are only 4 LP color orifices included in the kit, why is that? The BTU's aren't the same and the HVAC person that was here to install got so frustrated that he left after spending hours trying to figure it out. It has five burners, not sure why there would only 4 LP orifices to switch? Any help would be appreciated.
Current Answers
Answer #1: Posted by Brainerd on March 5th, 2015 8:17 AM
Brainerd
Member since:
May 24th, 2014 Points: 759,630
Member since:
May 24th, 2014 Points: 759,630
Hi, please contact their customer care:
Phone: 800-541-6390
How to reach a live person:
Hold on through prompts will take you to a customer service rep
Hours of Operation:
Mon-Fri: 8am-8pm EST
Sat: 10am-5pm
Click here to update this department.
Customer service link:
Click Here
I hope this helps you!
Please press accept to reward my effort or post again with more details if not satisfied.
Regards, Brainerd
Related KitchenAid KGRS505XSS Manual Pages
Use & Care Guide - Page 4
... and be seriously injured.
■ Proper Installation - Doing so blocks air flow through the oven and may also trap heat, causing a ...including the following:
■ WARNING: TO REDUCE THE RISK OF TIPPING OF THE
RANGE, THE RANGE MUST BE SECURED BY PROPERLY INSTALLED.... SAVE THESE INSTRUCTIONS
4 Connect anti-tip bracket to
persons, or damage when using the range, follow these instructions...
Use & Care Guide - Page 5
... a tripped circuit breaker or blown fuse. Center burner control knob (7,350 Btu/h) D. Failure to use with Natural gas.
Do not operate a burner while using empty cookware or without any cookware on the control panel. Check for use LP Gas, an LP Gas Conversion Kit is pressed completely down on some or all controls when not cooking...
Use & Care Guide - Page 6
... sure all controls are off and the oven and cooktop are ideal for proper size and shape as a guide when setting heat levels. Do not use oven cleaners, bleach or rust removers. 1....All surface burners will help avoid poor ignition and uneven flames. The center burner (7,350 Btu/h) is blue in color, not yellow. Burner Cap Alignment
Always keep the burner cap properly fitted in place when...
Use & Care Guide - Page 10
..." is extremely sensitive to the fumes given off the oven 12 hours after the oven is preheated, make sure the oven is preheated to the fumes may become over cooked. Preheat.... however, it is recommended for Lower calibrate or push START" scrolls twice from right to left in the oven during preheat, it will be French. ADJUSTMENT °F (ADJUSTMENT °C)
COOKS FOOD
10°...
Use & Care Guide - Page 11
...oven that is converted to LP gas, use racks 2 and 4 for best results when baking cakes on the rack as a guide. Lower front and slide back into the oven.
Use the following chart as shown. Slide rails B. Place cakes on 2 racks. To Replace Oven...by side.
3 or 4
Refer to circulate. The roll-out rack will fit in the oven. rack baking
2-rack baking
2 and 4, 2 and 5, or 3 and 5
B
A....
Use & Care Guide - Page 15
... rack(s) according to the "Positioning Racks and Bakeware" section.
■ When using convection temperature conversion for BAKED GOODS and OTHER FOODS, allow air to move freely around the food can differ from the oven.
Foods are not included because their cook time varies.)
Biscuits, Breads: quick and yeast Cakes and Cookies Casseroles Fish...
Use & Care Guide - Page 22
...oven door during a convection function will not operate
■ Is the oven door open ? See "Timed Cooking" section.
■ On some models, has a delay start been set ? Level the range. See "Bake," "Broil," "EasyConvect Conversion...the gas lines.
■ Is the electronic oven control set ? See the Installation Instructions.
See "Electronic Oven Control" section.
■ Has a delay ...
Use & Care Guide - Page 24
... travel and transportation for future reference.
IMPLIED WARRANTIES, INCLUDING WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE,...misuse, abuse, fire, flood, acts of God, improper installation, installation not in accordance with the removal from your home of...KitchenAid brand of Whirlpool Corporation or Whirlpool Canada LP (hereafter "KitchenAid") will pay for Factory ...
Dimension Guide - Page 1
...Natural gas. Model/serial/rating plates (located behind the control panel has information on or shutting off gas to 152.4 cm) long 1.3 cm) or ³⁄₄" (1.9 cm) I . If the types of gas listed do not include the type of E.I .D., flexible metal appliance connector may result in
B. LP gas conversion:
Conversion... that a qualified electrical installer determine that can be ...
Installation Guide - Page 3
...
Parts supplied Check that the materials used . Longer screws are included. ■ LP/Natural Gas Conversion Kit (located on the rating number plate. Given dimensions are shown must be killed.
In Canada, the installation of range near
lower side)
■ Burner grates
■ Burner caps
■ Oven racks
■ 2 - #12 x 1⁵⁄₈" screws (for convenient use...
Installation Guide - Page 5
...LP, have a qualified person make sure gas pressure does not exceed 14" (36 cm) water column. IMPORTANT: This installation must conform with Natural gas. Type of local codes, with the local gas supplier. LP gas conversion: Conversion...: Leak testing of a qualified person include: licensed heating personnel, authorized gas company personnel, and authorized service personnel. See "Gas...
Installation Guide - Page 6
...applicable for proper operation: Natural gas: Minimum pressure: 5" WCP Maximum pressure: 14" WCP LP gas: Minimum pressure: ...install range. Remove oven racks and parts package from the range. Do not block access to remove.
1. Shutoff valve "open" position C. INSTALLATION... metal tubing when moving the range.
■ Must include a shutoff valve: The supply line must be disconnected ...
Installation Guide - Page 8
Install... use an adapter. If connected to the
smaller thread ends of a qualified person include: licensed heating personnel, authorized gas company personnel, and authorized service personnel. Apply... Connection
4. Check that connector is indicated. Align recess in burner caps with LP gas to LP, have ½" male
pipe thread) D. Typical flexible connection 1. Flexible connector...
Installation Guide - Page 11
... at the rear of a qualified person include: licensed heating personnel, authorized gas company personnel, and authorized service personnel.
Examples of the range. Regulator cap
3. GAS CONVERSIONS
Gas conversions from Natural gas to LP gas or from LP gas to do so can tip the range and be done by a qualified installer. A
B
A. See "Oven Door" section in death or serious...
Installation Guide - Page 12
...aside. 7. Turn the Number 0.070 Natural gas orifice hood counterclockwise to the side. A
A. Install the Number 0.047 LP gas orifice hood, turning it clockwise 4 or 5 turns. Do not overtighten. Bake burner screw
A. A B
A. A
A. Orifice cover
9. Number 0.070 Natural gas orifice hood
10. Igniter and wires B. A
A
A. Unscrew wing nut and remove oven baffle. Wing nut
6. Remove the...
Installation Guide - Page 13
B
3. Turn the Number 0.054 Natural gas broil burner orifice hood counterclockwise to reinstall the orifice covers, oven bake burners, oven baffles and oven bake covers in the
upper oven and replace with screw. Repeat steps 1 through 8 above for conversion of the oven cavity and attach with a Number 0.037 LP gas orifice spud. 14. Remove broil burner screw and set aside. 2. Position ...
Installation Guide - Page 14
...) nut driver to the end of the range. Gas tube opening C. A
A. LP Gas Orifice Spud Chart
Burner Rating
Color
Number
4,000 BTU
Yellow
70L
7,000 BTU
Black
81L
9,100 BTU
Green
97L
14,000 BTU
Red
111L
5. Replace the Natural gas orifice spud with literature package. See the "LP Gas Orifice Spud Chart."
6. Replace burner cap.
8. Using a Phillips or Torx®...
Installation Guide - Page 15
...orifice. Remove the oven bake burner screw and set the bake burner to the right. LP gas position B. Do not overtighten. To Convert Oven Bake Burners
To Convert Lower Oven Bake Burner: 1. See "Oven Door" section in the Use and
Care Guide for oven... 7. Natural gas position
4. Remove oven door. A
A
A. Oven baffle B. B A
A.
Push the bake burner cover to the side.
A.
Remove oven racks ...
Installation Guide - Page 16
... screw. Repeat steps 1 through 8 above for conversion of the oven while changing the orifice hood. Turn the Number 0.047 LP gas orifice hood counterclockwise to remove.
A
A. Install the Number 0.054 Natural gas broil burner orifice hood, turning it clockwise 4 or 5 turns. Do not overtighten. Remove the Number 0.037 LP gas orifice spud in the oven back. Remove broil burner screw and...
Installation Guide - Page 17
... end of the oven cavity and attach with screw.
Broil burner orifice hood B. Remove the burner caps. 3.
Burner base screws
B. Natural Gas Orifice Spud Chart
Burner Rating
Color
Number
5,000 BTU
Green
107N
7,300 BTU
Yellow
125N
9,200 BTU
Orange
142N
10,000 BTU
Clear
149N
15,000 BTU
White
180N
16,000 BTU
Black
195N
5. Replace the LP gas orifice spud with...
KitchenAid Knowledge Base Results
We have determined that the information below may contain an answer to this question. If you find an answer, please remember to return to this page and add it here using the "I KNOW THE ANSWER!" button above. It's that easy to earn points!-
Setting the Self-Clean cycle
...cycle is complete and the oven cools, "Self Clean Complete" will also appear on the display as a guide to a powdery ash. Also, make sure the door is completely closed...Includes 30-minute cool-down time) 1 (Quick) 2 hours 30 minutes 2 3 hours 3 (Regular) 3 hours 30 minutes 4 4 hours 5 (Maxi) 4 hours 30 minutes Once the oven... -
General cleaning tips for my electric or gas range
...oven door exterior Use glass cleaner and a soft cloth or sponge. To clean the oven roasting racks Remove racks or they will help...stainless steel surfaces Rainbow colors in the dishwasher....sure knob is properly seated on some models) Make sure the drawer is cool. To clean the oven cavity: IMPORTANT: enter your model number below to your Use and Care Guide. Surface burners... -
Cleaning the Pro Line Coffee Mill
... Line Coffee Mill? Cleaning the Cutting Burrs If the mill is removed. Make sure the mill is switched off and unplugged. If the burr-shaft assembly does not slide out with the...motor housing, rotate the assembly until it from the motor housing. Answers others found helpful Adjusting Pro Line Coffee Grinder Burrs Foreign objects - After the faceplate screws have retaining ...
Similar Questions
Need Help With Conversion Lp
what color orfice spud do we use for the center 5th burner? Converting to lp gas.7350 btu...?
what color orfice spud do we use for the center 5th burner? Converting to lp gas.7350 btu...?
(Posted by akatesmith 6 years ago)
Where Is The Serial # Located On My Kitchenaid Kgrs505xss Double Oven Gas Stove?
Where is the serial # located on my KitchenAid KGRS505XSS double oven gas stove? Is the serial # loc...
Where is the serial # located on my KitchenAid KGRS505XSS double oven gas stove? Is the serial # loc...
(Posted by ardezz 8 years ago)
Kitchenaid Double Oven Gas Range Kgrs505xss Will Not Light
(Posted by Mahuang 10 years ago)
How To Convert From Natural To Lp Gas Whirlpool Kgrs505xss Manual
(Posted by nicgmsf 10 years ago)
Are Both Ovens Convection In Model Kgrs505xss
looking at various options for convection ovens. Wanted to know if the dual ovens in model Kgrs505x...
looking at various options for convection ovens. Wanted to know if the dual ovens in model Kgrs505x...
(Posted by louwchilds 10 years ago)