Installation Instructions
Page 3
...-.45/c8m") (1206-.01/c4m") 41" T-Series Grill 4(110-43.6/1c6m") 4(110-43.6/1c6m") (3823-.23/c4m") 4 Specifications (T-Series Grills) 30"W. & 41"W. LP/Propane gas cylinder with Type 1, QCC-1 connection or standard residential 1/2" (1.3 cm) ID gas service line. 9 volt DC battery for electronic ignition 120VAC/60HZ - 2' (61.0 cm) power cord supply cord with high capacity hose/regulator assembly for connection to rotisserie motor (except 030) 25,000 BTU...
...-.45/c8m") (1206-.01/c4m") 41" T-Series Grill 4(110-43.6/1c6m") 4(110-43.6/1c6m") (3823-.23/c4m") 4 Specifications (T-Series Grills) 30"W. & 41"W. LP/Propane gas cylinder with Type 1, QCC-1 connection or standard residential 1/2" (1.3 cm) ID gas service line. 9 volt DC battery for electronic ignition 120VAC/60HZ - 2' (61.0 cm) power cord supply cord with high capacity hose/regulator assembly for connection to rotisserie motor (except 030) 25,000 BTU...
Installation Instructions
Page 7
... following instructions are equipped with the outdoor grill must install a ground fault interrupt. o Never fill the cylinder beyond 80 percent full. Installer must be used for protection against shock hazard. Ensure there is not intended to adjacent vertical combustible construction. Replacement pressure regulators and hose assemblies must be easily accessible. 13 WDAARNNGIENRG This outdoor gas grill is adequate area for the rotisserie motor. T-Series Grills: • When using...
... following instructions are equipped with the outdoor grill must install a ground fault interrupt. o Never fill the cylinder beyond 80 percent full. Installer must be used for protection against shock hazard. Ensure there is not intended to adjacent vertical combustible construction. Replacement pressure regulators and hose assemblies must be easily accessible. 13 WDAARNNGIENRG This outdoor gas grill is adequate area for the rotisserie motor. T-Series Grills: • When using...
Installation Instructions
Page 11
... opening (s) shall have minimum dimensions so as to natural, you MUST use pipe sealant on flare fittings. This shall be accompanied by openings at both the upper and lower levels of the enclosure. The openings shall be installed in an easily accessible location. GAS CONVERSION To convert a grill from natural to LP/Propane or LP/Propane to permit the entrance of...
... opening (s) shall have minimum dimensions so as to natural, you MUST use pipe sealant on flare fittings. This shall be accompanied by openings at both the upper and lower levels of the enclosure. The openings shall be installed in an easily accessible location. GAS CONVERSION To convert a grill from natural to LP/Propane or LP/Propane to permit the entrance of...
Use and Care Manual
Page 4
... properly installed and connected to children around the grill at any time. wet potholders create steam and cause burns. Table of Contents Getting Started Important Safety Instructions 7 Features 10 Before Lighting Grill 11 Using Grill with Outdoor Approved Hoods _________ 11 Operation Lighting Grill 12 Using Grill 16 Cooking Tips 17 Grilling Tips 20 Smoker Box 21 Rotisserie 22 Product Care Cleaning and Maintenance 24 Battery Replacement 29 Troubleshooting 31 Service Information...
... properly installed and connected to children around the grill at any time. wet potholders create steam and cause burns. Table of Contents Getting Started Important Safety Instructions 7 Features 10 Before Lighting Grill 11 Using Grill with Outdoor Approved Hoods _________ 11 Operation Lighting Grill 12 Using Grill 16 Cooking Tips 17 Grilling Tips 20 Smoker Box 21 Rotisserie 22 Product Care Cleaning and Maintenance 24 Battery Replacement 29 Troubleshooting 31 Service Information...
Use and Care Manual
Page 5
... use the grill as far away from behind the manifold cover. Keep area clear and free from combustible surfaces. • Spiders and insects can upset combustion air flow or trap excessive heat in the control area, resulting in melted knobs. • The handle of heat, ignite or cause metal parts to corrode. • Do not remove the plastic cover on pan handles or ignited by burners...
... use the grill as far away from behind the manifold cover. Keep area clear and free from combustible surfaces. • Spiders and insects can upset combustion air flow or trap excessive heat in the control area, resulting in melted knobs. • The handle of heat, ignite or cause metal parts to corrode. • Do not remove the plastic cover on pan handles or ignited by burners...
Use and Care Manual
Page 14
... will permanently discolor stainless steel. Lift side burners and separate air shutter from side burners. Place the trays in the the drip tray pans to clean or move. Product Care Cleaning and Maintenance Removing Optional Side Burners for cleaning 1 2 Remove the grates, burner bowls, and grate support. 3 Remove bolts from orifice. Use a flashlight to inspect the burner inlet to clean. Burner outlet 26 Cleaning and Maintenance TruSear™ Infrared Grill Burner (If Applicable...
... will permanently discolor stainless steel. Lift side burners and separate air shutter from side burners. Place the trays in the the drip tray pans to clean or move. Product Care Cleaning and Maintenance Removing Optional Side Burners for cleaning 1 2 Remove the grates, burner bowls, and grate support. 3 Remove bolts from orifice. Use a flashlight to inspect the burner inlet to clean. Burner outlet 26 Cleaning and Maintenance TruSear™ Infrared Grill Burner (If Applicable...
Use and Care Manual
Page 16
... from debris. Unsnap glass light cover using the flame parts? Remove the grill rack and the flavor generator plates. Make sure the ignitor tip is pressed. Is the gas supply or gas pressure low? Is the safety valve button being depressed long enough? Product Care Cleaning and Maintenance Replacing Interior Halogen Canopy Lights CAUTION DISCONNECT THE ELECTRIC POWER BEFORE REPLACING BULB. Replace with knob on glass bulb cover. 4. Check the air...
... from debris. Unsnap glass light cover using the flame parts? Remove the grill rack and the flavor generator plates. Make sure the ignitor tip is pressed. Is the gas supply or gas pressure low? Is the safety valve button being depressed long enough? Product Care Cleaning and Maintenance Replacing Interior Halogen Canopy Lights CAUTION DISCONNECT THE ELECTRIC POWER BEFORE REPLACING BULB. Replace with knob on glass bulb cover. 4. Check the air...
Use and Care Manual
Page 17
... household use . Specifications subject to commercial usage. FIVE YEAR LIMITED WARRANTY Any burner assemblies, TruSear™ infrared burner, infrared rotisserie burner, or porcelain grill grate which rusts through due to the claim. LIFETIME LIMITED WARRANTY Any stainless steel part or porcelain grill grate which fails due to remedy the defects or malfunctions, the owner is located on any claim of any reason, alteration, improper installation, improper operation, or repair or service...
... household use . Specifications subject to commercial usage. FIVE YEAR LIMITED WARRANTY Any burner assemblies, TruSear™ infrared burner, infrared rotisserie burner, or porcelain grill grate which rusts through due to the claim. LIFETIME LIMITED WARRANTY Any stainless steel part or porcelain grill grate which fails due to remedy the defects or malfunctions, the owner is located on any claim of any reason, alteration, improper installation, improper operation, or repair or service...
Quick Reference Guide
Page 1
... in operation. Adjust heat setting, if necessary. Use the "HIGH" position to start sparking. Lighting Infrared Rotisserie Burner (T-Series and E-Series Models) The location of soapy water near the gas supply valve and check the connections for 5-7 minutes. • Check to be lit by turning the control knob to dissipate and try again. The cover becomes extremely hot when being lit. Push and turn off . Flash tube...
... in operation. Adjust heat setting, if necessary. Use the "HIGH" position to start sparking. Lighting Infrared Rotisserie Burner (T-Series and E-Series Models) The location of soapy water near the gas supply valve and check the connections for 5-7 minutes. • Check to be lit by turning the control knob to dissipate and try again. The cover becomes extremely hot when being lit. Push and turn off . Flash tube...
Quick Reference Guide
Page 2
...) 455-1200 (050311) Viking Quick Reference Guide Outdoor Gas Grills Once lit, the rotisserie burner will permanently discolor stainless steel. Extinguish any spills immediately. • DO NOT use abrasive cleaners, steel wool pads, or abrasive cloths on the left side of the grill Skewer Rotisserie fork Motor To load the skewer, slide one of the grill. Wipe up any open flames. 3. Gear box Thumb screws Mounting...
...) 455-1200 (050311) Viking Quick Reference Guide Outdoor Gas Grills Once lit, the rotisserie burner will permanently discolor stainless steel. Extinguish any spills immediately. • DO NOT use abrasive cleaners, steel wool pads, or abrasive cloths on the left side of the grill Skewer Rotisserie fork Motor To load the skewer, slide one of the grill. Wipe up any open flames. 3. Gear box Thumb screws Mounting...
Outdoor Products
Page 4
... better heat control • Allows heat to heavy-duty rotisserie system n Removable smoker box accommodates wood chips or large wood chunks • Hinged design allows easy operation when adding smoker chips n Smoker box can easily be replaced with grilling grate for use of canopy provides ample lighting for nighttime grilling (E Series only) n NEW Control Panel Illumination (E Series only) • Dedicated LED lighting above every control knob • Accentuates grill face and improves nighttime visibility n Stainless steel...
... better heat control • Allows heat to heavy-duty rotisserie system n Removable smoker box accommodates wood chips or large wood chunks • Hinged design allows easy operation when adding smoker chips n Smoker box can easily be replaced with grilling grate for use of canopy provides ample lighting for nighttime grilling (E Series only) n NEW Control Panel Illumination (E Series only) • Dedicated LED lighting above every control knob • Accentuates grill face and improves nighttime visibility n Stainless steel...
Outdoor Products
Page 11
.../Propane to natural gas (TNK-VGBQ, TNK-VGIQ) • Includes all grills; two additional rotisserie forks (two forks come standard with all hardware necessary to convert any size outdoor gas grill Optional rotisserie basket may be used to outdoor warming drawers. provides protection against burns n Gas conversion kits - available for wok cooking, in 6" and 8" widths n Rotisserie forks (RFK) - designed to protect grill on side burners n Stainless steel grill grates (SS2TG, SS3TG, SS4TG) n Stainless steel knobs (SKGQ) n Rotisserie...
.../Propane to natural gas (TNK-VGBQ, TNK-VGIQ) • Includes all grills; two additional rotisserie forks (two forks come standard with all hardware necessary to convert any size outdoor gas grill Optional rotisserie basket may be used to outdoor warming drawers. provides protection against burns n Gas conversion kits - available for wok cooking, in 6" and 8" widths n Rotisserie forks (RFK) - designed to protect grill on side burners n Stainless steel grill grates (SS2TG, SS3TG, SS4TG) n Stainless steel knobs (SKGQ) n Rotisserie...
Outdoor Products
Page 12
... burner rangetop may be installed separately from outdoor gas grills (VGRT244T) n Heavy-duty fully porcelain-coated removable "V" grates provide continuous front-to-rear surface for easy movement of large pots n Removable stainless steel grate support with separately removable stainless steel burner bowls enhances cleanability n Removable stainless steel cover adds protection from the elements n Removable stainless steel drip tray with roller-bearing glides, full-length handle, solid welded/finished end caps, and removable grease pan n Push-button electronic ignition powered...
... burner rangetop may be installed separately from outdoor gas grills (VGRT244T) n Heavy-duty fully porcelain-coated removable "V" grates provide continuous front-to-rear surface for easy movement of large pots n Removable stainless steel grate support with separately removable stainless steel burner bowls enhances cleanability n Removable stainless steel cover adds protection from the elements n Removable stainless steel drip tray with roller-bearing glides, full-length handle, solid welded/finished end caps, and removable grease pan n Push-button electronic ignition powered...
Outdoor Products
Page 40
...cm) to grill Grill Burner Rating T Series - 25,000 BTU NAT./22,500 BTU LP (7.3 kW NAT./6.5 kW LP) E Series - 29,000 BTU NAT./28,000 BTU LP (8.5 kW NAT./8.2 kW LP) Smoker Burner Rating 15,000 BTU NAT./13,500 BTU LP (4.4 kW NAT./4.0 kW LP) Rotisserie Infrared Burner Rating 15,... 460 lb. (208.8 kg) 40 LP/Propane gas cylinder with high-capacity hose/regulator assembly for electronic ignition 120V AC/60Hz; 24" (61.0 cm) 3-wire with grounded 3-prong plug attached to rotisserie motor E Series - 120V AC/60Hz; 3' (91.4 cm) power cord supply cord with 3-prong grounded plug attached...
...cm) to grill Grill Burner Rating T Series - 25,000 BTU NAT./22,500 BTU LP (7.3 kW NAT./6.5 kW LP) E Series - 29,000 BTU NAT./28,000 BTU LP (8.5 kW NAT./8.2 kW LP) Smoker Burner Rating 15,000 BTU NAT./13,500 BTU LP (4.4 kW NAT./4.0 kW LP) Rotisserie Infrared Burner Rating 15,... 460 lb. (208.8 kg) 40 LP/Propane gas cylinder with high-capacity hose/regulator assembly for electronic ignition 120V AC/60Hz; 24" (61.0 cm) 3-wire with grounded 3-prong plug attached to rotisserie motor E Series - 120V AC/60Hz; 3' (91.4 cm) power cord supply cord with 3-prong grounded plug attached...
Outdoor Products
Page 51
... most current specification sheets, call Dimension Express from brochure data only. This will send you information on how to change without notice. Enter the code #8051 for important clearance/installation information. com. See installation instructions for Viking products. Dimension Express Customer Service number is (775) 833-3633. © 2011, Viking Range Corporation Specifications subject to use the system and the corresponding model code numbers. All gas cooking products...
... most current specification sheets, call Dimension Express from brochure data only. This will send you information on how to change without notice. Enter the code #8051 for important clearance/installation information. com. See installation instructions for Viking products. Dimension Express Customer Service number is (775) 833-3633. © 2011, Viking Range Corporation Specifications subject to use the system and the corresponding model code numbers. All gas cooking products...
Specs
Page 1
... design allows easy operation when adding smoker chips o 12,500 BTU burner underneath can be adjusted for maximum smoking performance o Smoker box can be replaced with grilling grate for better heat control o Design allows heat to the drip tray, assisting in the upper right corner of full-width removable stainless steel drip tray, and individual removable trays within main tray • Exclusive "trays within grill, a Viking exclusive feature o Rotisserie motor assembly is supported by heavy...
... design allows easy operation when adding smoker chips o 12,500 BTU burner underneath can be adjusted for maximum smoking performance o Smoker box can be replaced with grilling grate for better heat control o Design allows heat to the drip tray, assisting in the upper right corner of full-width removable stainless steel drip tray, and individual removable trays within main tray • Exclusive "trays within grill, a Viking exclusive feature o Rotisserie motor assembly is supported by heavy...
Specs
Page 2
... for easy grill lighting • 25,000 BTU stainless steel grill burners produce intense searing heat across entire grilling surface • Heavy-duty, porcelain-coated removable "V" grates provide continuous front-to-rear surface for very smooth and easy operation • Control Panel Illumination o Dedicated LED lighting above every control knob accentuates grill face and improves nighttime visibility • Updated Side Burner Grate Design o Spider grate design matches Viking indoor range line • Power Porcelain™...
... for easy grill lighting • 25,000 BTU stainless steel grill burners produce intense searing heat across entire grilling surface • Heavy-duty, porcelain-coated removable "V" grates provide continuous front-to-rear surface for very smooth and easy operation • Control Panel Illumination o Dedicated LED lighting above every control knob accentuates grill face and improves nighttime visibility • Updated Side Burner Grate Design o Spider grate design matches Viking indoor range line • Power Porcelain™...
Specs
Page 4
...Gas fittings, regulator, and installer-supplied shut-off valve must be placed directly adjacent to combustible material, or any surface that is a rotisserie motor, and a min. Allow at a window, less than 24" (61.0 cm) to combustible and/or non-combustible construction below the cooking surface. 3. Ultra-Premium T-Series/E-Series Gas Grill Dimensions & Specifications CLEARANCE DIMENSIONS... use, the grill will produce a lot of 8" (20.3 cm) from the back above the cooking surface for smoke to open fully and for the rotisserie motor. OUTDOOR-COOKING 53"W. PLANNING AND DESIGN GUIDE ...
...Gas fittings, regulator, and installer-supplied shut-off valve must be placed directly adjacent to combustible material, or any surface that is a rotisserie motor, and a min. Allow at a window, less than 24" (61.0 cm) to combustible and/or non-combustible construction below the cooking surface. 3. Ultra-Premium T-Series/E-Series Gas Grill Dimensions & Specifications CLEARANCE DIMENSIONS... use, the grill will produce a lot of 8" (20.3 cm) from the back above the cooking surface for smoke to open fully and for the rotisserie motor. OUTDOOR-COOKING 53"W. PLANNING AND DESIGN GUIDE ...
Specs
Page 6
...) flare adapter. Natural gas models • Water column pressure o Operating pressure-4.0" WCP o Supply pressure of codes, the installation must comply with 3/8" (0.95) flare adapter. LP/propane tank installations • Water column pressure o Operating pressure-10" WCP • Includes high-capacity hose/regulator assembly for instructions on installing gas supply lines. amp usage-6.0 PLUMBING • Not applicable Burner rating Standard SS grill burners (each) GourmetGlo™ rotisserie burner Side grill burners (each) TruSear infrared burner VGBQ530-4RE2...
...) flare adapter. Natural gas models • Water column pressure o Operating pressure-4.0" WCP o Supply pressure of codes, the installation must comply with 3/8" (0.95) flare adapter. LP/propane tank installations • Water column pressure o Operating pressure-10" WCP • Includes high-capacity hose/regulator assembly for instructions on installing gas supply lines. amp usage-6.0 PLUMBING • Not applicable Burner rating Standard SS grill burners (each) GourmetGlo™ rotisserie burner Side grill burners (each) TruSear infrared burner VGBQ530-4RE2...
Specs
Page 8
... with heat-sealed vinyl protective cover • Unique Viking design allows light to mount securely to rotisserie motor and to be removed quickly for storage Model VQL Description Grill lights SS Grill Grates • Heavy-duty 3/8"- thick stainless steel Approx. lbs. (kg) 7 (3.2) 8 (3.6) Rotisserie Baskets • For use ) • Ninety-day limited warranty-cosmetic parts such as glass, painted, & decorative items * For complete warranty see Use & Care Guide. all grill Warming...
... with heat-sealed vinyl protective cover • Unique Viking design allows light to mount securely to rotisserie motor and to be removed quickly for storage Model VQL Description Grill lights SS Grill Grates • Heavy-duty 3/8"- thick stainless steel Approx. lbs. (kg) 7 (3.2) 8 (3.6) Rotisserie Baskets • For use ) • Ninety-day limited warranty-cosmetic parts such as glass, painted, & decorative items * For complete warranty see Use & Care Guide. all grill Warming...