Tecumseh Products TM049 Support and Manuals
Get Help and Manuals for this Tecumseh Products item
View All Support Options Below
Free Tecumseh Products TM049 manuals!
Problems with Tecumseh Products TM049?
Ask a Question
Free Tecumseh Products TM049 manuals!
Problems with Tecumseh Products TM049?
Ask a Question
Most Recent Tecumseh Products TM049 Questions
Correct Gas-oil Ratio
Hi,I have 2004 Jiffy ice auger with Tecumseh TM049XA engine. Some engine's service manuals requires ...
Hi,I have 2004 Jiffy ice auger with Tecumseh TM049XA engine. Some engine's service manuals requires ...
(Posted by beaverua1 8 years ago)
Popular Tecumseh Products TM049 Manual Pages
Operator Manual - Page 1
How to Get Service 3 III. Starting Your Engine 6 VI. Stopping Your Engine and Short-Term Storage 8 VII. Warranty Information 22
Visit our web site at www.TecumsehPower.com
Register Your Tecumseh Engine Maintenance Tips Parts Look-Up System Great Tecumseh Apparel
LOG ON! Safety Definitions ii I. Oil and Fuel Specifications 4 IV. Maintenance 8 VIII. Maintenance Intervals 14
...
Operator Manual - Page 2
...
Or
Tecumseh Contact Information
For engine adjustments, repairs or warranty service not covered in italic type.
Before operating this engine it is your responsibility to important information and is placed in this Operator's Manual. Follow these basic rules for your nearest Authorized Tecumseh Servicing Dealer. Tecumseh Power Company is no longer owned by Tecumseh Products Company nor...
Operator Manual - Page 4
... spark plug wire securely away from metal parts where arcing could result in serious injury or death. Disconnecting/Connecting Spark Plug
Figure 2. Consult your local Authorized Tecumseh Servicing Dealer, call 1-800-558-5402, or go -karts or mini-bikes could occur.
• Attach the spark plug wire to operate at negative terminal first, if engine is equipped with the governor setting...
Operator Manual - Page 5
... manual, contact your engine, indicates the engine's model number, engine type, specification of engine and the date of internal combustion engines and wish to repair and service your emission decal. See Figure 4. This handbook covers repairs and adjustments not covered within this power equipment. Service procedures should be clearly understood and practiced when servicing Tecumseh Engines...
Operator Manual - Page 7
...
An adult should fuel this
engine. Gasoline (fuel) vapors are gone. Fuel vapors can explode. Mixing Fuel and Oil" instructions on page 6.
3. NOTE Replace a damaged or missing fuel fill cap only with a genuine Tecumseh replacement fuel fill cap. Check the Following Equipment
1. Spark Plug Wire
Figure 7. If fuel mixture is free of ignition until fuel vapors are highly...
Operator Manual - Page 8
Move choke control lever to start or troubleshoot this
manual, contact your Authorized Tecumseh Servicing Dealer. See Figure 14.
Switch in . Only allow children to start engine if an
adult has determined they are unable to "FULL CHOKE" position (see equipment manufacturer's instructions) your engine, DO NOT attempt to start this engine after a short shutdown, move choke lever...
Operator Manual - Page 10
... so may result in bruised fingers and
accidental equipment movement which could occur.
• Attach the spark plug wire to "STOP" or "OFF" (see equipment manufacturer's instructions). See Figure 18.
• Turn off the engine after use and remove ignition key, if provided.
1. Optional Air Vents
Connected
Disconnected
Figure 17. See Figure 16.
Avoid Accidental...
Operator Manual - Page 11
...
Page 9 A.
Replace spark plug if porcelain is recommended that the engine be used for a Tecumseh Resistor Spark Plug.
2 1
I
3
3
+
4
5
6
1. Electrodes 3. See Figure 19.
Spark Plug
Check spark plug yearly or every 50 operating hours. 1. trodes are:
• Pitted
• Burned
• Fouled with wire feeler gauge and set
gap to an Authorized Tecumseh Servicing Dealer.
Air...
Operator Manual - Page 12
... equipment manufacturer's instructions and contact an Authorized Tecumseh Servicing Dealer. For operation at altitudes up to
distribute oil. 5. NOTE Contact your Authorized Tecumseh Servicing Dealer.
Servicing Flocked Screens
1. Air dry.
The filters in any engine adjustments. Thoroughly clean the inside of engine governor. II. Saturate with the governor setting can be affected...
Operator Manual - Page 15
... use or operate engine on your Authorized Tecumseh Servicing Dealer. Carefully disconnect spark plug wire from spark plug hole. Spark arrester must be installed.
181-1277-14
Two-Cycle Engine • Horizontal/Vertical Crankshaft • Air-Cooled
Page 13 Remove spark plug.
3.
II. Oil Cylinder Bore
WARNING When lubricating cylinder bore, fuel may need to be replaced to allow...
Operator Manual - Page 16
... also call Tecumseh Power Company at 1-800-558-5402 or visit www.TecumsehPower.com to perform maintenance intervals yourself, contact your dealer. ALWAYS promptly follow maintenance intervals listed. See Table 4. or 3 mos.
50 hrs. or seasonally
50 hrs.
Maintenance Intervals
Procedure
Time
Clean Cooling Fins
Clean Foam Filter
Replace Flocked Screen
Replace Spark Plug
Clean Muffler...
Operator Manual - Page 17
Clean Muffler & Cylinder Exhaust Ports
NOTE For this maintenance procedure it is recommended that the engine be taken to an Authorized Tecumseh Servicing Dealer.
181-1277-14
Two-Cycle Engine • Horizontal/Vertical Crankshaft • Air-Cooled
Page 15 Replace Spark Plug Date Owner/Dealer Date Owner/Dealer Date Owner/Dealer Date Owner/Dealer Date Owner/Dealer Date...
Operator Manual - Page 22
... on your small off -road engines must be completed in USA/Canada call 1-800-558-5402.
You are pleased to explain the Federal and California Emission Control Systems Warranty on your Operator's Manual, but Tecumseh Power Company will be repaired or replaced by contacting either an Authorized Tecumseh Servicing Dealer and/or Tecumseh Power Company, c/o Service Manager, 900 North Street...
Operator Manual - Page 23
... WARRANTY
Emission Control System Warranty ("ECS Warranty") for 1995 and later model year California small off-road engines (for such emission-related parts.
8. GENERAL EMISSIONS WARRANTY COVERAGE: Tecumseh Power Company warrants to the original, end-use purchaser of "repair or replace as specified in the Operator's Manual shall be charged for diagnostic labor which is in the Operator...
Operator Manual - Page 24
... the operation of the engine model number on engine and 10 years (the first 5 years covering parts and labor only;
TecumsehPower
Tecumseh Power Company • Grafton, Wisconsin 53024-1499 • USA Telephone: 1-800-558-5402
Visit us at its parts, other uses, including use for transporting any damage or loss incurred in an Instruction Manual for Member States of...
Tecumseh Products TM049 Reviews
We have not received any reviews for Tecumseh Products yet.