Poulan PR500Y22P Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan PR500Y22P manuals!
Problems with Poulan PR500Y22P?
Ask a Question
Free Poulan PR500Y22P manuals!
Problems with Poulan PR500Y22P?
Ask a Question
Popular Poulan PR500Y22P Manual Pages
Owner Manual - Page 1
.... Replace blade. 3. Hard to suit. Raise rear of drive speed
1. Belt wear.
1. not filling
2. "Loose" drive control system. 4. PROBLEM
CAUSE
CORRECTION
Grass catcher 1. Empty grass catcher. 4. TROUBLESHOOTING (continued)
See appropriate section in manual unless directed to an authorized Service Center.
Loss of drive or slowing of lawn mower housing one (1) setting higher...
Owner Manual - Page 2
... through your nearest authorized service center. Control bar in engine. 6.
Set all times.
• Only allow children to observe the following safety instructions could be used , it cannot come in OFF position. 11. Clean underside of children.
PROBLEM
CAUSE
CORRECTION
Does not start
1. Too much grass. 3. Replace blade.
pedestrian controlled lawn...
Owner Manual - Page 3
...for proper operation and installation of accessories. DO... • Replace your gasoline ...will cause problems. ...trouble. • Always wear eye protection when operating machine. • Use extra care when approaching blind corners, shrubs, trees, or other safety protective devices in place.
• See manufacturer's instructions...
tended.
If this manual). the blade comes ...
Owner Manual - Page 4
... 18" HI-VAC MODELS ONLY: 1. ON ALL OTHER MODELS:
1. Reinstall "standard" knobs and carriage bolts to service or repair this unit. • Read the SAFETY RULES and this manual for safe keeping.
• When setting up . Repair, if necessary, before restarting.
• Never attempt to the rear. 2.
mance. Save this Operator's Manual in the parts bag. To ensure safe...
Owner Manual - Page 5
... in the operating position (standing behind the handle). Inspect moving parts for your engine manual. Replace if necessary. • Touch up your mower. If the opening...MODELS ONLY)
• Move height adjustment lever forward to raise mower to be sure to cool before painting.
SERVICE AND ADJUSTMENTS
4. TO REPLACE DRIVE BELT
1. ENGINE SPEED The engine speed has been factory set...
Owner Manual - Page 6
... height.
6
SERVICE AND ADJUSTMENTS
TO REPLACE DRIVE BELT
1. Remove rear baffle from the debris shield retainer and come into blade adapter and crankshaft.
7. Use block of this manual. lbs.
Remove...mower to spark plug.
21" (53cm) HI-VAC MODELS: Belt retainer
Belt keepers
Drive belt
22PLUS REAR WHEEL DRIVE MODELS:
1. Install new drive belt into place handle on the drive pulley)...
Owner Manual - Page 7
...
Upper handle
Flanged locknut
Washer
Wheel assembly
Rope guide
T-Knob
Engine starter rope
ASSEMBLE GRASS CATCHER (...instructions. SERVICE AND ADJUSTMENTS
• Position the blade adapter on the axle first as shown. • Install one assembly. 10. INSTALL REAR WHEELS ("HIGH WHEEL" MOWERS ONLY) Some high wheel models require washers which type of
rear wheel adjuster. • Install...
Owner Manual - Page 8
...NOTE: Protect your model has the boot, install on its side....manual for replacement. NOTE: Before tipping lawn mower to operate mower with rigid part of turning over frame. Pivot pins
Rear door
Grass catcher handle
SPARK PLUG BOOT On some models a spark plug boot is packed loose in place. Spark plug
Catcher
frame hook
8
Boot
SERVICE AND ADJUSTMENTS
REAR WHEEL DRIVE MODELS:
MODELS...
Owner Manual - Page 9
...it .
• Turn lawn mower on
crankshaft. • Install new belt by run-
See
engine manual for proper direction of the mowing season the battery should be ... (female). • Plug battery charger into 110 volt A.C. SERVICE AND ADJUSTMENTS
TO REMOVE / REPLACE DRIVE BELT
FRONT WHEEL DRIVE MODELS:
"STANDARD" OR "DUAL BAIL" MODELS:
• Remove drive cover. NOTE: Always use . PUSH...
Owner Manual - Page 10
...MODELS WITH FIXED SPEED ENGINES Engine speed was set at same height.
Be sure all wheels are at the factory for most lawns.
Replace...out of the rear of any service or adjustments:
• Release ...MODELS:
Adjust cutting height to be adjusted to
lawn mower or performing any adjustments or repairs. "MANUAL...• Make sure all moving parts have engines equipped
with bolt
and ...
Owner Manual - Page 12
...replace corroded muffler as follows: 1. NOTE: Before tipping lawn mower to mulching operation, install mulcher plate or plug into position or set...FUEL FILTER (KOHLER or B&S
PRO / ENDURANCE ENGINES ONLY)
The...manual. Tighten securely. IMPORTANT: Front wheels must be "locked" into the rear door. Refer to engine manual specifications. Service...(18" (45cm) HI-VAC MODELS ONLY)
Both rear wheels are ...
Owner Manual - Page 13
... TYPE "A" To convert to the mower. 6. Hinge rod
Discharge deflector
Install
Tab
mulcher plug
MOWER IS NOW READY FOR MULCHING
OPERATION
Housing opening ....instructions supplied with dry cloth. With the arrow at the factory. Replace locknuts and hubcaps. • If after cleaning, the drive wheels do not turn freely, contact your nearest authorized service center.
18" (45cm) HI-VAC MODELS...
Owner Manual - Page 15
...manual. CAUTION: Do not run better and last longer. • Follow the Maintenance Schedule in the Service...'s specifications. ...manual should be lubricated, use . Place the grass catcher on each 5 hours of season. 5 - Any replacement...instructed in place.
Keep unit well lubricated (See "LUBRICATION CHART").
FOR SIDE DISCHARGING • Rear mulcher plate or plug (if equipped)
installed...
Owner Manual - Page 16
...the lawn is left on the next pass. To prevent this manual. • The special mulching blade will recut
the grass clippings... and discharge chute
removed. 2. Side discharge deflector installed and
secured to be set in cloth grass catchers can become filled with dirt...without mulcher door closed;
Handle
21" (53cm) HI-VAC MODELS: Your lawn mower was shipped ready to mower housing with knob...
Owner Manual - Page 17
... manual. • Fill to the top of the lawn mower's lower handle as instructed ... not overfill. • Replace plug (oil fill cap/dipstick on models so equipped) and tighten....installed and discharge chute secured to lawn mower housing with knob.
4. To avoid
engine problems, the fuel system should be considered normal. • Place engine START/STOP switch (if
equipped) in the engine manual...
Poulan PR500Y22P Reviews
Do you have an experience with the Poulan PR500Y22P that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!