Troy-Bilt Mustang 50 Support Question
Troy-Bilt Mustang 50 Support Question
Find answers below for this question about Troy-Bilt Mustang 50.Need a Troy-Bilt Mustang 50 manual? We have 2 online manuals for this item!
Question posted by tmitchell89tm on August 14th, 2022
Throttle
I would like to know how to set up my choke, governor and overall throttle assembly
Current Answers
Related Troy-Bilt Mustang 50 Manual Pages
Operation Manual - Page 1
... WITH THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY. Printed In USA
TROY-BILT LLC, P.O. Safe Operation Practices • Set-Up • Operation • Maintenance • Service • Troubleshooting • Warranty
Operator's Manual
Mustang Series RZT
WARNING
READ AND FOLLOW ALL SAFETY RULES AND INSTRUCTIONS IN THIS MANUAL BEFORE ATTEMPTING TO OPERATE THIS...
Operation Manual - Page 3
... eyes. avoid discharging material against a wall or obstruction
Know how to stop the machine and disengage them
which ricochet...object injury,
bare feet or sandals. Do not operate the mower
anyone .
Contact with any type of power equipment, carelessness ...the blade(s). As with the blade(s) can cause serious personal
assemble and operate. Remove all controls and their proper operation. ...
Operation Manual - Page 4
...can hide obstacles.
serious personal injury. Keep all attachment clutches, set the parking brake
2. Do
manually on steep slopes.
The mower could result.
loaded
27. tractor may jack-knife and cause tractor... or thrown object injuries. Do not try to measure slopes before operating this
dump cart, lawn roller, etc.) on the slope gauge, do not mow it , do not operate this...
Operation Manual - Page 11
...and locate the clamp knob on the seat pan and into position before operating the mower. 1. See Figure 3-7.
50" Deck Shown
Flange Lock Nuts
Clamp Knob
Push Nuts
Carriage Bolts
Seat Adjustment
Positions
... 3-6 and securely tighten the hardware.
50" Deck Shown
Flange Lock Nuts
Figure 3-7
Discharge Chute
Deflector
Push Nuts
Carriage Bolts
Figure 3-6
Section 2 - Assembly & Set-Up
11
Operation Manual - Page 12
...each side of the console, and is also engaged. Refer to raise and lower the mower deck. When the levers are applicable to all tractor models and the tractor depicted may...Tank Cap
LH Drive
RH Drive
Control Lever Control Lever
4
Deck Lift Handle
Deck Height Index Throttle/Choke Control Hour Meter/ Indicator Panel
PTO Switch Ignition Switch Cup Holder
Storage Tray
LH Transmission Bypass...
Operation Manual - Page 14
...the "START" position. The maintenance interval lasts for five minutes after every 50 hours of maintenance intervals for possible causes. Indicator Panel Features
Battery Indicator
... ; Follow the oil change intervals provided in the digital display (tenths of the throttle or throttle/choke control. Illuminates to indicate the battery voltage has dropped below 11.5 (+0.5/-1.0) volts.
...
Operation Manual - Page 20
...lawn ''browned'' by hot exhaust from the switch. Always drive across slopes, not up and down . Always slow down or stop before crossing. Operating The PTO
Operate the PTO clutch as follows:
1. Advance the throttle...raise the deck or move the throttle/choke control to a non grassy area before turning.
3. Lower the mower deck to the desired height setting using the PTO switch and move...
Operation Manual - Page 22
...when mowing tall, dry grass.
5. Do not use
P
Every 10 Hours
P P
Every 25 Hours
P P
Every 50 Hours
Every 100 Hours
Prior to a water supply.
2. Pull back the lock collar of the nozzle adapter and push... than the operator's seat of the deck.
22 Not all features in the presence of the mower deck. engage deck in this manual are
applicable to an area within reach of the hose where...
Operation Manual - Page 27
...system checked by your Cub Cadet Service Dealer. Deck Removal
Remove the mower deck from the negative battery post. 3. The muffler at a MAXIMUM...-volt battery charger at the rear of Charge
100% 75% 50% 25%
Charging Time
Full Charge 90 Min. 180 Min. ...nut securing the red positive battery lead to their highest setting (lowest deck setting).
3. If the electrical system does not function, check...
Operation Manual - Page 35
...Throttle/Choke Control Cable
925-1745A
Ignition Key
631-04288 631-05058
Discharge Chute Assy., RZT L42/46 Discharge Chute Assy., RZT L50/54
634-04293-0931 Wheel Assembly, RZT L42/46/54 634-04128-0931 Wheel Assembly..., RZT L50
634-04237B 634-04711
Caster Wheel Assy., RZT L42 Caster Wheel Assy., RZT L46/50/54
Phone (800)...
Parts Manual - Page 2
... Lock, 3/8-16 GrF Spring, Extension, .75 x 5.06 Washer, Flat, .406 x .875 x.059 Spacer, Shoulder, .38 x 1.0 x .7 Spacer, Shoulder, .884 x 1.9 Pulley, Idler, 4.25" Dia. Part No. TroyBilt Mustang 50" RZT
Frame
1
5
3 5
8 10
7 3
5
2
6
9 4
Ref.
Parts Manual - Page 3
TroyBilt Mustang 50" RZT
Front Axle
4
9
6 10
11
9
13
9 12
1
15 14
5
4 2
7 13
3
9
8 15
Ref. Description
1 603-04370 Bracket, Castor Wheel
2 603-04385A Axle, Front Pivot
3 634-04323A Wheel Assembly, 13 x 5-6
734-04255
Tire, 13 x 5-6
4 710-04186 Screw, Hex Lock, 1/2-13 x 1.25 GR5
5 710-04652 Screw, Hex Cap, 1/2-20 x 7.25 Gr5
6 710-0514 Screw...
Parts Manual - Page 4
TroyBilt Mustang 50" RZT
18 9
Electrical
4 14
10 4
3 9
18
2 6
15 12
11 6
1 16
13 8 7
5
9 17
Section of Main Wire Harness (Reference Only)
Parts Manual - Page 5
...-04237A † 725-04621
Description
Screw, Hex Wash. Pole - TroyBilt Mustang 50" RZT
Electrical
Ref. Hd. Brake/Rev Solenoid Switch, Outer Seat Spring Switch, Inner Seat Spring Key Battery, 235 CCA Plate, Insulator Boss Plate, Insulator Tie, Cable Screw, Shoulder, #10-32 x .5 Harness Assembly, Wire Neutral Switch, PTO Switch, Ignition Switch, Interlock, (NO...
Parts Manual - Page 7
.... Tapp., 1/4-20 x .5 Screw, Hex Wash. Hd Tapp, #12-16 x .50 Screw, Hex Wash. Tapp. , 1/4-20 x 1.5 Screw, Hex Wash. No.
1...Throttle Control Console, RH Graphic, Instruction" Graphic, Troy-Bilt Strip, Trim Spring, Compression, 1.28 x 3.125 Pad, Foot Washer, External Tooth, 3/8 Bumper Seat Bracket, Seat Pivot Nut, Hex Insert Flange Lock, 1/4-20 GrF Screw, Shoulder, .374 x 1.16 TroyBilt Mustang 50...
Parts Manual - Page 9
Part No. TroyBilt Mustang 50" RZT
Operator's Controls
Ref. No.
1 603-04160B 2 603-04387 3 603-04388 4 647-04065 5 647-04099 6 703-05387B 7 703-05396... 36 738-0507B 37 741-0225 38 741-3074 39 747-04225A 40 747-04401A 41 747-04637 42 748-04169
Description
Shaft Assembly, Deck Lift Lever, Lapbar, RH Lever, Lapbar, LH Rod, Brake Shaft, Damper Control Bracket, Lapbar Pivot Handle, Brake Bracket...
Parts Manual - Page 11
...Graphic, Danger
777I22282
Graphic, Instruction
777D11833 Graphic, 50"
2 618-04125A Spindle Assembly
3 631-04070A Chute Assembly, Discharge
777S30284
Graphic, Danger
4 683-0254 ...50 756-04216 Pulley, V Type, 5.39 Tapp, 5/16-12 x .75
12 710-1260A Screw, Hex Wash. Hd. No
Description
23 732-0306A Spring, Compression
24 732-0459 Spring, Extension, .94 Dia. TroyBilt Mustang 50" RZT
11
Mower...
Parts Manual - Page 12
TroyBilt Mustang 50" RZT
12
Engine Connections
23
20
7
9 17
32
24 13
22
10
27
31
4
16
30
11
28
8 1
26 12 25
2
18 6
5 12
3
18 29 6
33
6
14
21
15
19
Parts Manual - Page 13
...16 GR2
14 717-04183 Clutch Assembly, Electric PTO
15 726-0197
Tie, Clutch Wire
16 726-0205
Clamp, Hose
17 731-04914 Knob, Throttle Control
18 736-0148
Washer, ...04131 Washer, Flat, .438 x 1.75 x .25
22 746-04066 Cable, Throttle, 34.25 Lg
23 746-04214 Cable, Choke, 61Lg
24 747-04228A Wire, Tank Mounting
25 751-0564B Deflector, Muffler
26 751...Mustang 50" RZT
13
Engine Connections
Ref.
Parts Manual - Page 14
...14 x 1.6
2 618-04431A Transmission Assembly, LH
3 618-04432A Transmission Assembly, RH
4 634-04171 Wheel Assembly, 18 x 9.5 x 8
734-1729
Tire, 18 x 9.5 x 8
734-0255
Valve Assembly
603-04175
Rim Assembly
6 710-0395 Screw, Hex Cap... 10.2
16 754-04043 V-Belt, Type A Sec x 57.7 TroyBilt Mustang 50" RZT
14
Hydro Transmissions & Rear Wheels
8
7 12
10 4
1
8
8
16
2
14
13
4
5 15 6
...
Similar Questions
Need New Motor Engine For Troy Bitl Riding Lawn Mower 15.5
(Posted by janicesutton60 2 years ago)
My Mustang Rzt 50 Was Running Fine I Got Off For A Minute ,got Back On And It Wo
I was using my mustang rzt 50 it was running fine. I got off of it for a minute got ck on and it won...
I was using my mustang rzt 50 it was running fine. I got off of it for a minute got ck on and it won...
(Posted by mob816 8 years ago)
Lawn Mower
What kind of oil do I use in my troy bilt 140cc 110b push behind mower is it ok to use 10w30
What kind of oil do I use in my troy bilt 140cc 110b push behind mower is it ok to use 10w30
(Posted by sgilbert491974 9 years ago)
What Oil Filter Should I Use On Mustang 50 Zero Turn Mower
(Posted by Clcneale 9 years ago)