Toro 20333 Support Question
Toro 20333 Support Question
Find answers below for this question about Toro 20333 - BBC Personal Pace Walk Power Mower.Need a Toro 20333 manual? We have 2 online manuals for this item!
Question posted by wilslking on August 8th, 2014
How To Replace Cable Brake On Toro Mower
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Toro 20333 Manual Pages
Operation Manual - Page 1
...Lawn Mower
Model No. 20333-Serial No. 312000001 and Up Model No. 20333C-Serial No. 312000001 and Up
Form No. 3371-840 Rev A
Operator's Manual
Replacement parts are responsible for operating the product properly and safely.
Introduction
Model No. This rotary-blade, walk-behind lawn mower... the US Environmental
© 2011-The Toro® Company 8111 Lyndale Avenue South Bloomington...
Operation Manual - Page 2
...near or under the influence of this symbol to potential personal injury hazards. Only use accessories approved by the blade....ditches, or embankments. Safety
This lawn mower meets or exceeds the CPSC blade safety requirements for walk-behind the handle when the ... operate mower in daylight or good artificial light.
• Do not operate machine while under the machine. Replacements may ...
Operation Manual - Page 3
...components and the discharge guard frequently and replace with manufacturer's recommended parts, when necessary.
• Mower blades are explosive.
• Extinguish...not alert to cool before filling.
• Remove gas-powered equipment from a gasoline dispenser nozzle.
• Keep the...ground away from your view of Gasoline
To avoid personal injury or property damage, use a nozzle lock-...
Operation Manual - Page 4
...: Safety and instruction decals are located near areas of hand or foot, mower blade-disconnect the spark plug wire and read the Operator's Manual.
2.
... hazard of potential danger. Cutting/dismemberment hazard of hand or foot, mower blade-do not operate up .
108-8117
1. Replace damaged decals. Warning-read the instructions before leaving the operating position; Cutting...
Operation Manual - Page 5
... into the upper handle (Figure 3).
1. Setup
Important: Remove and discard the protective plastic sheet that you install the handle.
Remove the handle knobs from the mower housing (Figure 4). Important: Route the cables to the operating position. 3. Figure 3
Figure 4
2.
Operation Manual - Page 9
... to mow. 1. You can also try reaching just under the personal pace handle to the handle (Figure 16).
Engaging the Blade
When you start your mower (Figure 14) is a toggle switch (with both an "I"...engine stops.
3.
Note: If the mower does not freely roll backward after self-propelling, stop walking, hold down the switch in place, and allow the mower to roll a couple of inches (...
Operation Manual - Page 10
... the factory ready to recycle the grass and leaf clippings back into a ball small enough to go under the mower housing (about 5 inches (13 cm) in diameter).
4. If it into the lawn. The blade brake clutch may be deteriorating and, if ignored, could result in an unsafe operating condition. Important: When you release...
Operation Manual - Page 11
...correct position.
If the side discharge chute is on the mower, remove it is seated in serious personal injury.
Install the grass bag, ensuring that the pins ... Lever).
WARNING
The blade is in serious personal injury or death to collect grass and leaf clippings from the lawn. Rear deflector
Figure 19 3. WARNING
A ...a new Toro replacement bag.
If the bag-on-demand lever is sharp;
Operation Manual - Page 12
... discharge area could allow small stones and other similar debris to be thrown in the operator's or bystander's direction and result in serious personal injury or death to the mower.
• For bagging the grass and leaf clippings, press the button on the bag-on-demand lever and move the lever forward...
Operation Manual - Page 13
... with a Toro replacement blade. For example,
13 Figure 22
Removing the Side Discharge Chute
To remove the side discharge chute, lift up the side deflector, remove the side discharge chute, and lower the side discharge deflector.
Walk at a time. Cutting Grass
• Cut only about a third of the grass blade at a slower pace while...
Operation Manual - Page 15
... engine stops within 3 seconds after releasing the blade control bar. • Check the blade brake clutch operation. • Clean grass clippings and dirt from the normal operating position. Important: Refer... can cause personal injury. never siphon. Use a screw driver to running out of the machine from under the mower.
• Replace the air filter;
If you must tip the mower prior to ...
Operation Manual - Page 16
...oil with the air filter up to warm it. Dipstick
Figure 26
3. Pull down the cable jacket (toward the mower) until the oil level reaches the Full line on the dipstick (Figure 27). 2.
Dispose...cable support nut (Figure 28).
1. Figure 28 This figure is out of SF, SG, SH, SJ, SL, or higher.)
5. Refer to check the oil level with the dipstick. Install the cover.
Replace ...
Operation Manual - Page 17
... blade or have it sharpened and balanced, or replace it immediately. If the blade is damaged or cracked, replace it .
Tip the mower onto its side with the air filter up .
3. Refer to Preparing for Maintenance. 2. Blade nuts 2. Blade brake clutch shield
4. Stiffener
3.
Disconnect the spark plug wire from the spark plug. Refer to...
Operation Manual - Page 18
... more clippings that come out from the inside of the
shield and around all the parts. 8. Lower the mower to Adjusting the Cutting Height.
2. Refer to its lowest cutting height setting.
6. Install the blade brake clutch shield that you
previously removed. 9. Install the blade and the stiffener that you previously
removed (Figure...
Operation Manual - Page 19
... the cables to 15 ft-lb (20 N-m). 9. Recycle it according to run until you can explode. • Do not store gasoline more than 30 days. • Do not store the mower in ...of the year, add fuel stabilizer to prevent cylinder corrosion during the off-season. 8.
Preparing the Mower for Storage
WARNING
Gasoline vapors can no longer start models only). 2. On the last refueling of ...
Operation Manual - Page 20
...Walk Power Mowers
Conditions and Products Covered
The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly promise to repair the Toro...Lawn Mowers") or access our web site at www.Toro.com. The Toro GTS (Guaranteed to an Authorized Toro... blades, cable/linkage adjustments, or brake and clutch...you are using Toro-approved replacement parts. To ...
Parts Catalog - Page 1
Form No. 3371-848 Rev A
22in Recycler® Lawn Mower
Model No. 20333-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com. Original Instructions (EN)
Parts Catalog - Page 2
...: phillips pan head thread forming PRH: phillips round head PTH: phillips truss head PTO: power-take-off RH: right hand ROPS: roll-over protection system
RRB: rear roller brush SFH...To order replacement parts, please supply the part number, the quantity, and the description of each part within the service assembly. List of Abbreviations
AR: as required ASM: assembly BBC: blade brake control BHTF...
Parts Catalog - Page 6
...Washer-Flat
9 3296-73
2 Nut-Lock, NI
10 120-3327 11 603773 12 32144-102 13 107-0758
1 Brake Arm ASM 2 Nut 3 Screw-HWH 1 Spacer-Bearing
14 100-1048
3 Bearing-Ball
15 108-3790
1 Retainer-... 54-9190
2 Nut-Lock
33 3229-5
1 Screw-CARR
34 106-6801 35 121-2371
1 Anchor-Cable, BBC 1 Decal-Shroud
● Not serviced separately
■ Obtain parts from www.briggsandstratton.com
3371-848A
6
...
Parts Catalog - Page 10
...
1 Screw-HH
3 108-3788-03 1 Bail-Brake
4 115-8439
1 Cable-Brake, BBC
5 3290-337
1 Nut-Speed
6 106-9169 7 107-7462
1 Screw-HWH 1 Spring-Torsion
8 107-7463
1 Spacer
9 106-6802
1 Lever
10 32128-17
1 Nut-Lock, Flange
11 112-8884 12 104-9368
1 Knob-BBC 1 Plug-Dome
13 614249
2 Tie-Cable
3371-848A
10
D4 Upper Handle...
Similar Questions
How To Replace Cable Brake On Toro 20333 Lawnmower
(Posted by CyaRJ 9 years ago)
How To Replace Cable-brake Toro 20333
(Posted by unwilpjlay 10 years ago)
How To Replace Torsion Spring On Toro Personal Pace Mower
(Posted by nirCar 10 years ago)
When Should You Replace Traction Belt On Toro Personal Pace Mower
(Posted by lhm87tahi 10 years ago)
How To Install And Tighten Cable Brake On Toro Pp Model #20333
ive replaced a cable brake before they seem to brake at the handle..cheap plastic...but i cant seem ...
ive replaced a cable brake before they seem to brake at the handle..cheap plastic...but i cant seem ...
(Posted by jqlew77 11 years ago)