Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by gettsmeja on July 13th, 2014
How To Troubleshoot A Toro 20332
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on July 22nd, 2014 3:35 AM
freginold
Member since:
December 20th, 2011 Points: 23,254,985
Member since:
December 20th, 2011 Points: 23,254,985
Hi, depending on what the problem is (won't start, doesn't cut well, etc.) how to troubleshoot it will vary. Here are some things that may help:
If your mower won't start at all, there are many things that could potentially cause that so you need to eliminate some of them to figure out what's causing it. If it's been stored for a while and not used, but there was gas in the tank, the gas might just be old. Try flushing out the gas tank and carburetor, then filling the tank with new gas.
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start. If you have a spark plug tester, you use that to see if the spark is getting to the plug -- if it's not, then you have a much deeper problem.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Try spraying some starting fluid into the carburetor (with the air filter removed and the mower off) then put the filter back on and try starting the mower -- if it starts then dies, there is probably a blockage in the carb.
Here are some links that may be useful:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
If your mower won't start at all, there are many things that could potentially cause that so you need to eliminate some of them to figure out what's causing it. If it's been stored for a while and not used, but there was gas in the tank, the gas might just be old. Try flushing out the gas tank and carburetor, then filling the tank with new gas.
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start. If you have a spark plug tester, you use that to see if the spark is getting to the plug -- if it's not, then you have a much deeper problem.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Try spraying some starting fluid into the carburetor (with the air filter removed and the mower off) then put the filter back on and try starting the mower -- if it starts then dies, there is probably a blockage in the carb.
Here are some links that may be useful:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
- Toro 20332 Common Maintenance Parts List
- Tips for Troubleshooting Lawn Mower Problems
- How to Troubleshoot a Lawn Mower with Starting Issues
Related Toro 20332 Manual Pages
Operation Manual - Page 1
....
Figure 2 1. This spark ignition system complies with a spark arrester muffler.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up Model... reproductive harm. It is not equipped with Canadian ICES-002.
© 2011-The Toro® Company 8111 Lyndale Avenue South Bloomington, MN 55420
Register at www.shoptoro.com....
Operation Manual - Page 2
...operating machine.
• See manufacturer's instructions for the cause immediately. walk; Safety
This lawn mower meets or exceeds the CPSC blade safety requirements for walk-behind the handle when the engine... significantly lower. The enclosed Engine Owner's Manual is used to alert you to potential personal injury hazards. Stop the blade when crossing gravel surfaces.
• Do not operate ...
Operation Manual - Page 3
...spillage and remove any adjustments or repairs with manufacturer's recommended parts, when necessary.
• Mower blades are sharp. Always place containers on a truck or trailer bed with a plastic ...up . Check their proper operation regularly.
• Keep machine free of Gasoline
To avoid personal injury or property damage, use extra caution when servicing them .
• Keep children out...
Operation Manual - Page 4
...Decals
Important: Safety and instruction decals are located near areas of hand or foot, mower blade-stay away from the original machine manufacturer.
94-8072
104-7953
1. Indicates ...-read the instructions before leaving the operating position; Cutting/dismemberment hazard of hand or foot, mower blade-do not discard. 2. Warning-read the Operator's Manual for information on slopes; Lock...
Operation Manual - Page 5
...the dipstick, slowly pour a small amount of oil into the oil fill tube, then remove the dipstick.
5.
Move the mower to the outside of the handle knobs as you
removed in the crankcase, then do the following: 1. Insert the dipstick fully...sheet that you install the handle.
2
Filling the Engine with Oil
No Parts Required
Procedure
Important: Your mower does not come with a bottle of oil.
Operation Manual - Page 7
... Add mark on the dipstick, slowly pour a small amount of 87 or higher) from igniting the gasoline, place the container and/or mower directly on the dipstick. Move the mower to the fuel all season, mixing it with gasoline. Fill the fuel tank with oil and run the engine.
Note: If the...
Operation Manual - Page 8
... can severely burn you. Set the front wheels to the handle slowly.
1.
Raise the mower
Figure 9 2.
Adjust the cutting height as the rear wheels (Figure 9). Turn the ignition.... Keep away from the hot muffler. Hold the blade control bar against the handle (Figure 10).
Lower the mower
Note: The cutting height settings are 1 inch (25 mm); 1-3/8 inches (35 mm); 1-3/4 inches (44 ...
Operation Manual - Page 9
... the personal pace handle to the metal handle and push the mower forward a couple of inches (centimeters) forward to Operating the Bag-on the upper handle and your elbows at your hands on -Demand Lever). Raise and hold your mower immediately and contact an Authorized Service Dealer. Recycling the Clippings
Your mower comes from the lawn. If...
Operation Manual - Page 10
...stop before you to either collect or recycle grass and leaf clippings while the grass bag is sharp; Grass bag pin (2)
2.
WARNING
The blade is attached to the mower. • For bagging the grass ...16) before cleaning the bag-on the lever pops up . contacting the blade can result in serious personal injury or death to another.
Bag-on -demand lever from the bag-on-demand door and the ...
Operation Manual - Page 11
... the blade can result in the bagging position, move the lever to the recycling position (refer to stop before leaving the operating position. Figure 17
Removing the...11 If the grass bag is on the mower and the bag-on -Demand Lever). Stop the engine and wait for cutting very tall grass.
WARNING
The blade is in serious personal injury.
Clean here
Figure 16
Side-discharging the...
Operation Manual - Page 12
...) tall, mow at a slower pace while mowing.
- Wet grass and leaves tend to clump on the lawn, set the front wheels at 2-1/8-... blade when necessary with a Toro replacement blade. Set the cutting height on your mowing speed if the mower does not cut the leaves ...the spark plug, and examine the mower for even fertilization.
• If the finished lawn appearance is unsatisfactory, try one notch...
Operation Manual - Page 13
...hand fuel pump to remove the fuel.
tip the mower prior to running out of the machine from an Authorized Service Dealer (go to www.toro.com to your engine operator's manual for any ...the engine and wait for additional maintenance procedures. Gasoline is flammable, explosive and can cause personal injury. never siphon. Refer to your engine operator's manual. • Refer to your engine...
Operation Manual - Page 14
... oil level is at a local recycling center.
14 Figure 19
Changing the Engine Oil
Service Interval: After the first 5 hours Yearly
Run the engine a few minutes before changing the oil to the operating position. 6. Wipe the dipstick clean with oil and run the engine. Move the mower to open the air filter...
Operation Manual - Page 15
Battery 4. Connect the charger to the mower wire harness
located below the ignition key (Figure 22).
• A green light indicates that the ... engine does not run with a 40-amp plug-in type fuse.
1. Note: When the battery no longer holds a charge, recycle or dispose of California to local codes. Remove the screw that the charger is charging the
battery.
2. This state lasts only a...
Operation Manual - Page 16
..., contact an Authorized Service Dealer. Important: A bolt torqued to Preparing for Maintenance. 2. Fuse
Figure 24
G017398
2. Note: Your mower comes with the screw that you run out of wood, put your weight behind the
16 Install the new blade and all mounting ...(Figure 26). If the blade is sharp;
Wear gloves when servicing the blade.
1. Replace the fuse in serious personal injury.
Operation Manual - Page 18
... the upper handle forward as directed by the engine manufacturer.
2. Figure 29
4. Preparing the Mower for 24 hours (electric-start the engine, it in a heated area, you can damage the... the steps above. Removing the Mower from the spark plug.
7. Storage
Folding the Handle
Store the mower in the fuel tank is the leading cause of hard starting. Recycle it stops. Disconnect the wire...
Operation Manual - Page 20
...Toro GTS Starting Guarantee
A 3-Year Full Warranty (Not Applicable for Commercial Use)
22 in Recycler® 20 in Mulcher/Bagger
Walk Power Mowers
Conditions and Products Covered
The Toro Company and its affiliate, Toro...repairs under "Lawn Mowers") or access our web site at 866-214-9807 (U.S. Such routine maintenance, whether performed by a dealer or by an Authorized Toro Service Dealer is...
Parts Catalog - Page 1
Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com. Original Instructions (EN)
Parts Catalog - Page 3
... and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in the USA. All Rights Reserved
Parts Catalog - Page 4
... Chute and Rear Door Assembly
Ref. Description
16 114-7959
1 Latch-Recycle
17 117-1031
1 Spring-Compression
18 32104-120
2 Screw-PPH
19...1 Housing ASM
1:2 94-8072
1 Decal-Danger
1:3 115-4676
1 Decal-Recycler
1:4 112-8867
1 Decal-Port, Washout
2 114-7963-01 1 Baffle-Front
5 114-7961
1 Baffle-Rear
6 115-4677
1 Chute-Recycle
7 46-8091
9 Screw-HWH
8 112-6416
1 Bracket-Cover
9 99...
Similar Questions
Owners Manual For Toro 190 Cc Personal Pace Lawn Mower
(Posted by nelsontim1 9 years ago)
How Much Oil Does A Toro Personal Pace Push Mower Take
(Posted by ricant 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)
Blade For Model 20037 Personal Pace Lawn Mower
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
(Posted by lynnegrede 12 years ago)