Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by chirielibir on October 27th, 2013
Toro 22 Recycler Personal Pace Wont Start
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on December 20th, 2013 4:57 AM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
Hi, there are many things that could prevent your mower from starting. If it's been stored for a while and not used, but there was gas in the tank, the gas might just be old. Try flushing out the gas tank and carburetor, then filling the tank with new gas.
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Post a new question with what you've tried and whether you've gotten the mower to start at all, and we'll go from there.
- Toro 20332 owner's manual
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Post a new question with what you've tried and whether you've gotten the mower to start at all, and we'll go from there.
- Toro 20332 owner's manual
Related Toro 20332 Manual Pages
Operation Manual - Page 1
... an Authorized Service Dealer or at www.Toro.com. Other states or federal areas may have the model and serial numbers of your product ready. Original Instructions (EN) Printed in the space below:
Important: This engine is a violation of special attention. 22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model...
Operation Manual - Page 2
...instructions. Failure to potential personal injury hazards. Stop machine if anyone . Avoid discharging material against a wall or obstruction. Vibration is clear of bystanders before starting .
• Do ...starting the engine.
• If the machine should start the engine. Poor footing could result in serious injury or death. For models with SAE J1940. Safety
This lawn mower ...
Operation Manual - Page 3
...• Keep all nuts and bolts tight to prevent unintended starting .
• Never make any fuel-soaked debris. Clean up...trailer bed with manufacturer's recommended parts, when necessary.
• Mower blades are explosive.
• Extinguish all times until fueling is... care in contact with the rim of Gasoline
To avoid personal injury or property damage, use a nozzle lock-open flame...
Operation Manual - Page 5
...you install the handle.
2
Filling the Engine with Oil
No Parts Required
Procedure
Important: Your mower does not come with oil.
Move the handle to a level surface. 2. Important: Route the...oil.
Note: If the oil level is damaged, contact an Authorized
Service Dealer.
1. Figure 3
2. Before starting the engine, fill the engine with a bottle of SF, SG, SH, SJ, SL, or higher....
Operation Manual - Page 6
...oil until the oil level on -demand lever
5. Fuel tank cap
11. Recoil start models only)
6 Battery charger (electric-start handle
7. Refer to Charging the Battery in the Maintenance section. Figure 5
1. Install...engine oil after the first 5 operating hours; Ignition key (electric-start models only Refer to Changing the Engine Oil. Grass bag 2. Product Overview
3
Charging the ...
Operation Manual - Page 7
...methanol, gasoline containing methanol, or gasoline containing more than 30 days old.
1. Important: To reduce starting problems, add fuel stabilizer to a level surface. 2.
Note: Never use or daily
Note: Max....until the oil level on the dipstick (Figure 8). Remove the dipstick (Figure 8).
Move the mower to the fuel all season, mixing it with oil and run the engine. Wipe the ...
Operation Manual - Page 8
....
1. Keep away from the hot muffler. Turn the ignition key (Figure 11) (electric-start models only) or pull the recoil start handle, pull it lightly until you feel resistance, then pull it sharply (Figure 12).
Raise the mower
Figure 9 2. Starting the Engine
1. Adjust the cutting height as the rear wheels (Figure 9). Blade control bar...
Operation Manual - Page 9
...
To operate the self-propel drive, simply walk with you want to recycle the grass and leaf clippings back into the lawn. contacting the blade can also try reaching just under the personal pace handle to the metal handle and push the mower forward a couple of inches (centimeters) forward to Removing the Side Discharge Chute...
Operation Manual - Page 10
...and other similar debris to be thrown in the operator's or bystander's direction and result in serious personal injury. Removing the Grass Bag
To remove the bag, reverse the steps above. Stop the engine...The blade is attached to the mower. • For bagging the grass and leaf clippings, press the
button on the bag-on-demand lever and move the
• For recycling the grass and leaf clippings, ...
Operation Manual - Page 11
...recycling position (refer to stop before leaving the operating position. Clean here
Figure 16
Side-discharging the Clippings
Use the side discharge for all moving parts to Operating the Bag-on -demand lever is in serious personal... injury. Stop the engine and wait for cutting very tall grass.
WARNING
The blade is on the mower and the bag-on -Demand...
Operation Manual - Page 12
...8226; After cutting the lawn, ensure that the blade could hit.
• Avoid striking solid objects with a Toro replacement blade.
Replace the blade or have it is too long, the mower may need to stall.
...the blade. This helps disperse the clippings over any object.
• If the mower strikes an object or starts to clump on the front wheels one or two notches higher than the rear ...
Operation Manual - Page 13
... to the spark plug. Preparing for 24 hours (electric-start models only).
• Empty the fuel tank before repairs...mower prior to remove the fuel. Gasoline is flammable, explosive and can cause personal injury.
Figure 18
3. Always tip the mower onto its side, with a hand pump; Important: Before tipping the mower... www.toro.com to leak. WARNING
Tipping the mower may cause the fuel to find...
Operation Manual - Page 14
...minutes before changing the oil to a level surface. 2. Remove the dipstick (Figure 20).
Move the mower to warm it. Important: Do not overfill the crankcase with a clean cloth. 9. Install the dipstick ...mark on the dipstick reads Full. 11.
Note: If the oil level is at a local recycling center.
14
Read the oil level on the dipstick, slowly pour a small amount of oil...
Operation Manual - Page 15
... the charger to the mower wire harness
located below the ignition key (Figure 22).
• A green...3.
Charge the battery for 24 hours initially, then monthly (every 25 starts) or as needed. Always use the charger in type fuse.
1.
...charged. Rear deflector 2. Note: When the battery no longer holds a charge, recycle or dispose of charging: • A red light indicates that the charger is...
Operation Manual - Page 16
... ends of wood, put your weight behind the
16 Replace the fuse in serious personal injury. Install the covering over the battery compartment. 7. Replacing the Blade
Service Interval... bolt torqued to point toward the mower housing. 6. 1 2 3
1. Fuse holder
4. Fuse
Figure 24
G017398
2. Figure 25
4.
Use a block of gasoline. Note: Your mower comes with a block of the ...
Operation Manual - Page 17
... setting. Wash out the area under the rear deflector where the
clippings go from under the mower housing.
7. Start the engine and run it from the mower.
9.
Note: Wash out the area with the bag-on the mower housing (Figure 28). Adjusting the Self-propel Drive Cable
Whenever you have completed mowing. 1. ratchet or...
Operation Manual - Page 18
... days, and do not store stabilized fuel more than 30 days.
• Do not store the mower in a heated area, you can explode.
• Do not store gasoline more than 90 days.....
8.
Figure 29
4. Remove the ignition key (electric-start models only).
2. Fold the upper handle forward as directed by the engine manufacturer.
2. Recycle it according to the spark plug.
18
Note: Old...
Operation Manual - Page 20
...
Toro Service Dealer
• Repairs or adjustments to correct starting your unit, please check the Operator's Manual to ensure that your sole remedy under "Lawn Mowers")...Toro GTS Starting Guarantee
A 3-Year Full Warranty (Not Applicable for Commercial Use)
22 in Recycler® 20 in Mulcher/Bagger
Walk Power Mowers
Conditions and Products Covered
The Toro Company and its affiliate, Toro...
Parts Catalog - Page 1
Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Original Instructions (EN)
Parts Catalog - Page 4
Part Number Qty. Part Number Qty. Description
16 114-7959
1 Latch-Recycle
17 117-1031
1 Spring-Compression
18 32104-120
2 Screw-PPH
19 121-5776
1 Rear Door ASM
19:2 114-7982
1 Decal-Warning
20 115-2859
1 Spring-Torsion
21 114-7924
1 Spring-Torsion
22 112-6400
1 Port-Washout
23 112-6401
1 Coupling-Hose...
Similar Questions
Is There A Lock On My Toro 22 Personal Pace Recycler Wont Start
(Posted by lamcnump 10 years ago)
Toro Mower 22in Recycler Wont Start Model20332
(Posted by nekojLeesi 10 years ago)
22 Recycler Wont Stay Running
(Posted by rarao 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
Toro Recycler Spark Wont Start
(Posted by tuha 10 years ago)