Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by wansiTHFE on July 30th, 2014
Toro 190cc Will Not Running
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on August 3rd, 2014 4:30 PM
freginold
Member since:
December 20th, 2011 Points: 23,253,895
Member since:
December 20th, 2011 Points: 23,253,895
Hi, if your mower starts but won't stay running, it's likely either a problem in the fuel tank/fuel line or carburetor. Try flushing the gas tank and carburetor, giving the carburetor a good cleaning to make sure no holes or venturis are clogged, and checking the fuel hose for burrs or blockages. Then fill the gas tank with new gas and give it a try.
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Here is a link to the mower's manual:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
Here is a link to a list of common maintenance parts for this model, including the carb rebuild kit:
- Toro 20332 Common Maintenance Parts List
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Here is a link to the mower's manual:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
Here is a link to a list of common maintenance parts for this model, including the carb rebuild kit:
- Toro 20332 Common Maintenance Parts List
Related Toro 20332 Manual Pages
Operation Manual - Page 1
... residential properties. WARNING
CALIFORNIA Proposition 65 Warning The engine exhaust from an Authorized Service Dealer or at www.Toro.com.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up Model No. 20352-Serial No. 312000001 and Up
Form No. 3371-667 ...
Operation Manual - Page 2
...it.
• Mow across the face of lawn mower will be sure of the American National Standards Institute in place and working.
• Never leave a running .
• Be sure the area is ...not operate machine while under the machine. Failure to potential personal injury hazards. General Operation
• Read, understand, and follow this mower could result in wet grass. Keep clear of the ...
Operation Manual - Page 3
...cap and tighten securely. Do not run the engine indoors or in safe working condition.
• Never tamper with the engine running . Allow machine to the presence... and replace with manufacturer's recommended parts, when necessary.
• Mower blades are often attracted to be sure the equipment is spilled on...personal injury or property damage, use extreme care in contact with the engine...
Operation Manual - Page 6
... 6
1.
change it yearly thereafter. Ignition key (electric-start models only Refer to Changing the Engine Oil. Important: Do not overfill the crankcase with oil and run the engine.
Operation Manual - Page 7
...an octane rating of 87 or higher) from igniting the gasoline, place the container and/or mower directly on the ground before filling, not in an approved fuel container, out of the ...containing methanol, or gasoline containing more than 30 days old.
1. Fill the fuel tank with oil and run the engine. Important: To reduce starting problems, add fuel stabilizer to a level surface. 2. Read the ...
Operation Manual - Page 8
... the front cutting height levers forward and the rear cutting height levers rearward.
1.
Raise the mower
Figure 9 2. CAUTION
If the engine has been running, the muffler will be hot and can severely burn you feel resistance, then pull it sharply (Figure 12). Note: When you pull the recoil start ...
Operation Manual - Page 9
... Service Dealer. Note: Remove the ignition key when you want to recycle the grass and leaf clippings back into the lawn.
If the mower still does not roll backward easily, contact an Authorized Service Dealer. contacting the blade can also try reaching just under the personal pace handle to the metal handle and push the...
Operation Manual - Page 10
...The blade is attached to the mower. • For bagging the grass and leaf clippings, press the
button on the bag-on-demand lever and move the
• For recycling the grass and leaf clippings, ...on the lever pops up (Figure 15)
Figure 15 1. contacting the blade can result in serious personal injury or death to stop before you to another. Also, an open rear discharge area could allow...
Operation Manual - Page 11
...and wait for cutting very tall grass. WARNING
The blade is in serious personal injury. contacting the blade can result in the bagging position, move the lever to the recycling position (refer to stop before leaving the operating position.
Clean here
Figure 16... and install the side discharge chute (Figure 17).
1.
If the grass bag is on the mower and the bag-on -Demand Lever).
Operation Manual - Page 12
...a Toro replacement blade.
This helps disperse the clippings over the lawn for even fertilization.
• If the finished lawn appearance... is late fall when grass growth begins to Adjusting the Cutting Height.
• When cutting grass over 6 inches (15 cm) tall, mow at a time. then mow again at a slower pace while mowing.
- WARNING
Wet grass or leaves can cause the mower...
Operation Manual - Page 13
...
tip the mower prior to running out of the machine from an Authorized Service Dealer (go to www.toro.com to find the nearest dealer) or at www.shoptoro.com. never siphon.
Run the engine ...additional yearly maintenance
procedures. WARNING
Tipping the mower may cause the fuel to run dry through normal usage.
Gasoline is flammable, explosive and can cause personal injury. If you must
13
Operation Manual - Page 14
... pour a small amount of oil in
the crankcase. 7. Return the mower to warm it. Wait 3 minutes for Maintenance. 3.
Dipstick
Figure 20...Changing the Engine Oil
Service Interval: After the first 5 hours Yearly
Run the engine a few minutes before changing the oil to the operating .... 12. Note: If the oil level is at a local recycling center.
14 Dispose of the used oil out through 10 until ...
Operation Manual - Page 15
...the battery no longer holds a charge, recycle or dispose of the lead-acid battery ...start models only
If the battery does not charge or the engine does not run with a 40-amp plug-in the battery compartment area.
3.
Screw
Figure ...(Figure 23).
1.
Battery compartment
Figure 22
2. Connect the charger to the mower wire harness
located below the ignition key (Figure 22).
• A green ...
Operation Manual - Page 16
...personal injury.
Replacing the Blade
Service Interval: Yearly
Important: You will need a torque wrench to 60 ft-lb (82 N-m).
Wear gloves when servicing the blade.
1. Figure 25
4.
WARNING
The blade is very tight. Tip the mower... Important: A bolt torqued to point toward the mower housing. 6. Lower the rear deflector.
If you run out of wood, put your weight behind the
...
Operation Manual - Page 17
... clippings that is very difficult to the grass bag. Turn the water on -demand in the area. Start the engine and run it from under the mower housing.
7. Start the engine and run it until
there is running. • Do not allow bystanders in both the fully forward and fully rearward positions. 4. Move the...
Operation Manual - Page 18
...1. Remove the ignition key (electric-start models only).
2. Storage
Folding the Handle
Store the mower in the fuel tank is the leading cause of hard starting.
Note: Old fuel in a...improperly can move the
upper handle freely. 3.
Recycle it according to run until the engine stops from running out of any unused fuel properly. Run the mower until it is sufficiently dry.
6. Allow the...
Operation Manual - Page 20
... periods of malfunction or non-use pending completion of repairs under "Lawn Mowers") or access our web site at Toro Warranty Company.
*Residential purposes means use of the product on some...the routine maintenance required in the Operator's Manual have purchased Toro products exported from the date of purchase:
Products
22 in Recycler and 20 in Mulcher/Bagger and Attachments GTS (Guaranteed ...
Parts Catalog - Page 1
Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Original Instructions (EN)
Parts Catalog - Page 3
... and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in the USA.
Parts Catalog - Page 4
...
11 99-5293
1 Spring-Torsion
12 115-8449
1 Deflector-Side
13 115-8447
1 Chute-Discharge, Side
14 114-7960
1 Deflector-Recycle
15 114-7958
1 Knob-Recycle
Ref. Description
16 114-7959
1 Latch-Recycle
17 117-1031
1 Spring-Compression
18 32104-120
2 Screw-PPH
19 121-5776
1 Rear Door ASM
19:2 114-7982
1 Decal...
Similar Questions
Owners Manual For Toro 190 Cc Personal Pace Lawn Mower
(Posted by nelsontim1 9 years ago)
How Much Oil Does A Toro Personal Pace Push Mower Take
(Posted by ricant 10 years ago)
2011 Toro Recycler Personal Pace Lawn Mower Wont Stay Running
(Posted by EssTss4 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)
Blade For Model 20037 Personal Pace Lawn Mower
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
(Posted by lynnegrede 12 years ago)