Stihl FS 90 R Support Question
Stihl FS 90 R Support Question
Find answers below for this question about Stihl FS 90 R.Need a Stihl FS 90 R manual? We have 2 online manuals for this item!
Question posted by jerrywhittaker on March 31st, 2019
Replacing Stihl Fs90r Clutch Drum Housing
The clutch drum housing on my Stihl FS90r cracked. I have replacement parts but wanted to know if their is a specific sequence to placing the clutch drum housing, clutch drum, clips and collar?
Current Answers
Answer #1: Posted by Odin on April 1st, 2019 5:57 AM
Odin
Member since:
April 10th, 2010 Points: 41,236,640
Member since:
April 10th, 2010 Points: 41,236,640
Hope this is useful. Please don't forget to click the Accept This Answer button if you do accept it. My aim is to provide reliable helpful answers, not just a lot of them. See https://www.helpowl.com/profile/Odin.
Related Stihl FS 90 R Manual Pages
Product Instruction Manual - Page 3
...
40
Replacing the Starter Rope and
Rewind Spring
40
Storing the Machine
42
Sharpening Metal Cutting Blades 43
Maintenance and Care
44
Main Parts
46
Specifications
Special Accessories
Maintenance and Repairs
STIHL Incorporated Federal Emission Control Warranty Statement
STIHL Incorporated California Exhaust and Evaporative Emissions Control Warranty Statement
Trademarks
{
FS 90, FS 90...
Product Instruction Manual - Page 4
...Warning! The individual steps or procedures described in the manual may be on your STIHL dealer for assistance. N Lever (2) ... In addition to the operating instructions, this...made from those described in the illustration. Indicates an imminent risk of its individual components.
2
FS 90, FS 90 R Depending on the machine are supported by illustrations. Example:
N Loosen the screw (1). As ...
Product Instruction Manual - Page 11
... line contact, be fast enough for the clutch to idle.
Failure to follow this position ...loss of moisture, pitch, oil, fuel mix or grease.
002BA054 KN
002BA055 KN
FS 90, FS 90 R
9 Do not let the grip snap back, but guide the starter rope...when the engine starts at idle, attach the power tool to have your STIHL dealer check your harness (see the appropriate section of control, do not...
Product Instruction Manual - Page 13
... such objects that bystanders are approached.
FS 90, FS 90 R
11 The cutting attachment could cause damage to the ground. If the blade or head continues to loosen, see the chapter on "Proper Clothing") and ensure that could cause the power tool to superficial cracks. Replace a cracked, damaged or wornout head or a cracked, bent, warped, damaged, dull or...
Product Instruction Manual - Page 14
...parts of the engine by a chemical process in your muffler serviced and repaired by a STIHL servicing dealer. English
Warning!
Have your instruction manual.
12
FS 90, FS 90 R
To reduce the risk of burns do not continue work with a damaged or improperly mounted cylinder housing... an illustration of fire and burn injuries, the following specific safety precautions must be observed.
Product Instruction Manual - Page 15
....
STIHL FixCut mowing head Uses pre-cut lengths of wire could break off and be thrown at high speed toward the operator or bystanders. see "Main Parts" chapter in injury to important components (e.g.
FS 90, FS 90 R
13 Such damage could result in your instruction manual).
002BA354 KN 002BA177 KN
If the lawn edges are easily replaced.
Frayed...
Product Instruction Manual - Page 17
... will crack and / or break, avoid all rigid cutting blades"). Before starting the cut down small trees, STIHL recommends that the blade will reduce the risk of loss of kickout (blade thrust) with a larger diameter, since the blade may catch or jerk the trimmer / brushcutter forward. To reduce the risk that the
FS 90, FS 90...
Product Instruction Manual - Page 18
..., but rather only on blades.
Use only identical STIHL replacement parts for a component which has not been serviced or maintained properly or if nonapproved replacement parts were used by any maintenance or repair work not ...the spark plug and the ignition wire connector in serious or fatal injuries.
16
FS 90, FS 90 R To reduce the risk of loss of control and serious injury to remount...
Product Instruction Manual - Page 22
FS 90, FS 90 R English
Approved Power Tool Attachments
The following STIHL interchangeable attachments may be mounted on the basic machine:
FH
HT
Interchangeable attachment BF 1) FCS 2) 3) FH 1) HL 0° 2) HL 135° 1) 2) HT 2) KB (4601) 2) KW (4601) 2)
Use Soil cultivator Edger Scrub cutter Hedge trimmer Hedge trimmer Pole pruner Bristle brush Sweeper drum assembly
1) stop (barrier...
Product Instruction Manual - Page 29
...in the mowing head information sheet.
see "Mounting the deflector". The cutting edges of the lawn - STIHL AutoCut
N Hold the mowing head parallel above the surface of (2), (4) and (5) must point... for circular saw blades 200 (4, 5) -
FS 90, FS 90 R
27 approx. 1 1/4 in . (2.5 cm) long!
Fit the approriate limit stop .
Replacing mowing line and/or cutting blade
Proceed as ...
Product Instruction Manual - Page 32
... 1/4 turn ). One of the STIHL filling system (special accessory). If the grip is not flush with the surface and the lug on the clip does not engage entirely in an ...upright position;
the raised positioning marks must line up. N Always position the machine so that the filler cap is installed as it is not properly closed and the steps
30
FS 90, FS 90...
Product Instruction Manual - Page 38
...) from around
the filter. N Replace damaged parts.
This avoids unnecessary high loads during...is a noticeable loss of any major hardware.
36
FS 90, FS 90 R As a temporary measure you need it .
After...housing (4) and remove it again. Empty the fuel tank and keep the machine in the filter housing and fit the cover. Installing the filter
N Install the filter element in a dry place...
Product Instruction Manual - Page 42
... rotor and starter grip.
40
FS 90, FS 90 R N Remove the remaining rope from
the housing.
if no grease can be seen on the inside, then screw in direction of operation
N Unscrew the locking screw (1) -
233BA010 KN
249BA061 KN 249BA013 KN
English
Lubricating the Gearbox
1 2
Replacing the Starter Rope and Rewind Spring
Replacing the Starter Rope
3 4
5
N Check...
Product Instruction Manual - Page 43
...housing and uncoils: Refit it with a simple overhand knot.
the spring clip must point counterclockwise - Replacing a broken rewind spring
N Remove the rope rotor as shown in chapter on "Replacing the starter rope". N Position the new spring housing... and working inwards.
249BA018 KN
FS 90, FS 90 R
41 N Reinstall the rope rotor -
N Push the spring housing into the starter cover.
N ...
Product Instruction Manual - Page 47
...
sharpen
X
Gear lubrication
check top up
Safety information sticker
replace
1) STIHL recommends STIHL servicing dealers
X X
X
before starting work at the end of work and/or daily whenever tank is refilled weekly monthly yearly if faulty if damaged as required
English
X
X
X
X
X
X X
FS 90, FS 90 R
45
check
X
Antivibration elements (rubber buffers,
springs)
have them...
Product Instruction Manual - Page 51
... can be performed only by an authorized STIHL servicing dealer using original STIHL replacement parts. Original STIHL parts can be available for your product. Displacement...FS 90:
12.8 lbs. (5.8 kg)
FS 90 R:
12.1 lbs. (5.5 kg)
FS 90, FS 90 R
English
Maintenance and Repairs
Users of this unit should carry out only the maintenance operations described in some cases, by the STIHL part...
Product Instruction Manual - Page 52
... any emission-related part on your engine is performed at no
cost to explain the Emission Control System Warranty on your equipment type engine. The warranty repairs will begin on your instruction manual.
Warranty Period
The warranty period will be free from the date of sale, to
50
FS 90, FS 90 R English
STIHL Incorporated Federal...
Product Instruction Manual - Page 53
... part still under warranty. FS 90, FS 90 R
51 However, if you for the cost of time up to the first scheduled replacement point for Warranty Service
Bring the product to make a Claim for that part. Warranty Work
STIHL Incorporated shall remedy warranty defects at any of the following list specifically defines the emission-related warranted parts:
- Clamps
- Any warranted part...
Product Instruction Manual - Page 54
... non exempted add-on or modified part.
52
FS 90, FS 90 R
The warranty repairs should however be liable to the owner. STIHL Incorporated also warrants to abuse, neglect...'s Warranty Responsibilities
This emissions control system is defective, the part will be repaired or replaced by STIHL Incorporated
STIHL Incorporated warrants to the ultimate purchaser and each subsequent purchaser ...
Product Instruction Manual - Page 55
... required by the Emission Warranty Parts List (see below ) must be warranted for
English
damages to the owner if it must be repaired or replaced by the manufacturer according to the first scheduled replacement point for
FS 90, FS 90 R
that is performed at any authorized STIHL servicing dealer and present the signed STIHL product registration card, or the...
Similar Questions
Hardware To Attach Blade To Collar
I'm looking for part numbers for the nut and washer that attach the blade to the collar of an FS90 W...
I'm looking for part numbers for the nut and washer that attach the blade to the collar of an FS90 W...
(Posted by ERIC18537 1 year ago)
How To Remove Clutch Drum From Drum Housing On Stihl Fs90r Weedeater
Removing metalshaft rod and clutch drum on my fs90r weedeater
Removing metalshaft rod and clutch drum on my fs90r weedeater
(Posted by charlesmurray294 1 year ago)
Replacement Part Sg71
My Stihl SG71 sprayer broke where the pump handle connects to the part it connects to. I would need ...
My Stihl SG71 sprayer broke where the pump handle connects to the part it connects to. I would need ...
(Posted by Richardgolda 3 years ago)
Replacment Of Clutch
How do you remove the clutch shoes which there is 2 is it pressed or screwed
How do you remove the clutch shoes which there is 2 is it pressed or screwed
(Posted by smyslinski 10 years ago)