Home » Stihl » Lawn & Garden » Stihl FS 110 R

Stihl FS 110 R Support Question

Find answers below for this question about Stihl FS 110 R.
Need a Stihl FS 110 R manual? We have 3 online manuals for this item!

Stihl Overview Questions Manuals Reviews Videos Research

Question posted by ualemp1704 on December 23rd, 2014

Engine Stalls When Open Throttle. Old Fs110r C1q

Replaced carb diapragms etc. after cleaning all ports with carb cleaner. Fuel delivery ok. Tank vent ok. Impulse hose clear and feel pulse when cranking. Plug replaced. When starts if I open throttle it stalls. Mix screw adjustments no help. If spray carb cleaner around carb base where bolts on at engine it accclerates then dies unless keep spraying. Did not do compression ck yet but feels like good compression at start pull cord.Next shot will be head gasket. Any other ideas? Thanks

I Know the Answer!

I have the same question
Request More Information

Current Answers

Answer #1: Posted by zzed41 on December 25th, 2014 3:44 AM

This answer was accepted by the poster of the original question.

zzed41

Member since:
December 12th, 2014

Points: 914,010

1,100
points

Hi! If carb cleaner is making it start then it dies, I suggest you check the spark plugs of the engine.

Hope this helps! If it does, please click on the Accept Answer button. I will greatly appreciate it! :)

Related Stihl FS 110 R Manual Pages

Product Instruction Manual - Page 3

... the Cutting Attachment 25 4-MIX Engine 28 Fuel 29 Fueling 30 Fitting the Harness 31 Balancing the Trimmer/Brushcutter 32 Starting / Stopping the Engine 33 Operating Instructions 36 Cleaning the Air Filter 36 Engine Management 36 Adjusting the Carburetor 37 Spark Arresting Screen in Muffler 38 Spark Plug 39 Lubricating the Gearbox 40 Replacing the Starter Rope and Rewind...

Product Instruction Manual - Page 8

...from escaping gas vapor and fumes, remove the fuel filler cap on the fuel used, the weather conditions and the tank venting system. Grip the shaft in well-ventilated areas...running. 6 FS 110, FS 110 R Never remove the fuel filler cap while the engine is an extremely flammable fuel. Use extreme caution when handling gasoline or fuel mix. Fueling Instructions Warning! Fuel your STIHL ...

Product Instruction Manual - Page 9

... clothing immediately. Fold the grip flush with the raised positioning FS 110, FS 110 R 7 this happens, change your clothing. Insert the cap in the fuel tank opening lining up ) until it will go (approx. 1/4 turn the cap (with grip Warning! Take care not to get fuel on the fuel tank opening with the top of the cap may be equipped with...

Product Instruction Manual - Page 10

... before using the power tool. Warning! Replace damaged heads or blades before starting, particularly the throttle trigger, throttle trigger lockout, slide control / stop switch, cutting attachment, deflector and harness. Always keep them free of all times (see chart in your instruction manual). 8 FS 110, FS 110 R Check that the spark plug boot is equipped with the proper deflector...

Product Instruction Manual - Page 11

...FS 110, FS 110 R 9 Place the power tool on how to the spring hook of your unit with incorrect idle adjustment. Warning! Important Adjustments Warning! For directions on firm ground or 000BA007 KN 000BA006 KN other solid surface in an open...speed, see the appropriate section of your size before starting -throttle, engine speed will be absolutely sure that the cutting attachment ...

Product Instruction Manual - Page 13

... perpendicular to the ground may be in particular those with the engine and attachment stopped. During cutting, check the tightness and the condition of certain dusts, especially organic dusts such as you do not have an allergic or asthmatic reaction. FS 110, FS 110 R 11 Warning! This trimmer / brushcutter is released (flywheel effect). Warning! The...

Product Instruction Manual - Page 14

... the power tool to kick out or could be observed. 12 FS 110, FS 110 R The retaining nut may result in such situations. Replace a cracked, damaged or wornout head or a cracked, bent, warped...shut off the engine and remove the spark plug boot before cleaning. In addition, be cleaned off the trimmer / brushcutter, which is hot. Warning! To reduce risk of the engine (e.g. English ...

Product Instruction Manual - Page 15

... PolyCut mowing head Uses either nylon lines or nonrigid, pivoting polymer blades. FS 110, FS 110 R 13 An improperly mounted or damaged cylinder housing or a damaged / deformed muffler shell may interfere with trees or bordered by a simple adjustment (see the chapter on the engine and reduces its proper length. If you suspect a clogged screen, have...

Product Instruction Manual - Page 18

... replaced by the special limit stop deflector (see chapter on one with a bicycle handle. This limit stop the engine and make a warranty claim for maintenance and repair. Before starting ...injury from the nearest coworker. Wear gloves when handling or performing maintenance on blades. 16 FS 110, FS 110 R Use of at least two tree lengths from thrown objects or operator contact with ...

Product Instruction Manual - Page 26

... full throttle, starting throttle and idle positions. N Tighten down the screw firmly. 002BA142 KN 2 3 1 Deflector for mowing attachments 2 Deflector for correct operation in the same way. N Insert the screws (3) and tighten them down the throttle trigger lockout (1) and squeeze the throttle trigger (2) (full throttle) - STOP 2 1 N Press down firmly. 002BA380 KN 24 FS 110, FS 110 R this...

Product Instruction Manual - Page 35

...carabiner. 2 1 1 Throttle trigger lockout 2 Throttle trigger 3 Slide control FS 110, FS 110 R 33 Floating positions Detaching the unit from the harness 002BA034 KN A Mowing tools (A) such as mowing heads, grass cutting blades and brush knives N should "hover" about 8 in. (20 cm) above the ground. N Press down the screw on handlebar STOP- English Starting / Stopping the Engine Controls...

Product Instruction Manual - Page 36

... 2 Throttle trigger 3 Slide control Positions of the arrow on the drive tube. 34 FS 110, FS 110 R English Control handle on the engine support and the deflector. This is not touching the ground or any other obstacles. normal run position - the engine can start 6 START - N Hold the unit with fuel. tion if the engine has been running or can start - START STOP Starting...

Product Instruction Manual - Page 37

... the direction of throttle cable - N Open the throttle slightly. N Set the slide control, lockout lever and throttle trigger to 20 pulls may be necessary. N Start the engine by pulling the starter rope briskly - 10 to the starting throttle position. see chapter on the stop symbol (h) to STOP-0. N Dry the spark plug. N Move the slide control to e - FS 110, FS 110 R 35 As soon...

Product Instruction Manual - Page 39

.... N Check the air filter and clean or replace as necessary. N Check that the throttle cable is 3/4 turn for about 3 minutes. N Check the spark arresting screen and clean or replace as necessary. N Carefully turn open . N Warm up the engine for adjustment N Carry out the standard setting without disturbing the high speed screw (H). N Open the throttle wide. Readjust idle It is not...

Product Instruction Manual - Page 41

... KN 002BA363 KN If engine is down firmly. Wrong fuel mix (too much oil in operation. Dirty air filter. - Removing the spark plug N Move the slide control to form on power, difficult to start or runs poorly at part load. 1 2 Warning! Too much engine oil in the gasoline), a dirty air filter and unfavorable running conditions, e.g. FS 110, FS 110 R 39

Product Instruction Manual - Page 46

... X X readjust idle speed Spark plug adjust electrode gap replace after every 100 hours of operation visual inspection X Cooling air intakes clean Valve clearance check and adjust if necessary, one time after 139 hours of work and/or daily whenever tank is refilled weekly monthly yearly if faulty if damaged as required X X X X X X X X X X X X X X X X X FS 110, FS 110 R

Product Instruction Manual - Page 49

... cutting work . 20 Barrier Bar Helps keep user's feet and legs clear of the engine. 8 Slide Control For starting the engine. 4 Spark Plug Boot Connects the spark plug with the ignition lead. 5 Muffler with Skirt for all Mowing Attachments 5 Skirt 6 Metal Mowing Tool 002BA114 KN FS 110, FS 110 R 47 Spark arresting screen is designed to reduce the risk of...

Product Instruction Manual - Page 53

Any manufacturer-approved or equivalent replacement part may be used for any warranty maintenance or repairs on the application of the recommended 2-stroke fuel-oil mixture (see also instruction "Fuel"). Intake Manifold - Fuel Tank - Fuel Line - Fasteners Where to make a Claim for Warranty Service Bring the product to the owner. FS 110, FS 110 R 51 Diagnosis You, as non-defective, STIHL...

Product Instruction Manual - Page 54

... dealer as soon as : Air Filter, Carburetor, Fuel Pump, Choke (Cold Start Enrichment System), Control Linkages, Intake Manifold, Magneto or Electronic Ignition System (Ignition Module), Spark Plug, Catalytic Converter (if applicable), Fuel Tank, Fuel Cap, Fuel Line, Fuel Line Fittings, Clamps, Fasteners. As the small off-road equipment engine owner, you warranty coverage if your small off...

Product Instruction Manual - Page 55

... for the remaining warranty period. 3. Emission Warranty Parts List Air Filter, Carburetor, Fuel Pump, Choke (Cold Start Enrichment System), Control Linkages, Intake Manifold, Magneto or Electronic Ignition System (Ignition Module), Spark Plug, Catalytic Converter (if applicable), Fuel Tank, Fuel Cap, Fuel Line, Fuel Line Fittings, Clamps, Fasteners Where to make a Claim for English damages to...