Sharp 32F630 Support Question
Sharp 32F630 Support Question
Find answers below for this question about Sharp 32F630 - X-Flat Flat-Screen 32" TV.Need a Sharp 32F630 manual? We have 1 online manual for this item!
Question posted by nmartelle on March 18th, 2010
Need Flyback Transformer
My Sharp 32F630 was made in 2003 and the flyback transformer has died. My Sharp dealer in town says they are unable to find the flyback transformer. Do you have one available?
Current Answers
Related Sharp 32F630 Manual Pages
Service Manual - Page 1
SHARP CORPORATION
This document has been published to those specified should be restored to its original condition and only parts identical to be used for after sales service only. 1st Edition
32F630 32F631
SERVICE MANUAL
S13W527F630//
COLOR TELEVISION Chassis No.
The contents are subject to change without notice.
GB-3U
32F630
32F630
32F631
MODELS 32F631
In...
Service Manual - Page 2
...properly there is essential that servicemen have available at higher voltages may cause a failure...source of X-ray in current solid state TV receivers is for the low B+ DC ...with a meter to the high voltage circuitry.
6. 32F630 32F631
IMPORTANT SERVICE SAFETY PRECAUTION
Ë Service work ...of penetrating the shell of the high voltage transformer. The calibration of excessive voltage.
2 The...
Service Manual - Page 3
32F630 32F631
IMPORTANT SERVICE SAFETY PRECAUTION
(Continued)
BEFORE RETURNING THE RECEIVER
(Fire & Shock Hazard)
...parts in television
For continued ... covers or shields, isolation resistor-capacity networks, mechanical insulators, etc.
3. The use an isolation transformer for higher voltage, wattage, etc.
To be sure that hardware is not lodged between the chassis and other hazards.
Service Manual - Page 4
...available.
Infrared Transmitter Window
CATV/DVD-TV/VCR MODE buttons Press TV/VCR →Signals sent will be for cable TV...effective when charging the display.
4 32F630 32F631
LOCATION OF USER'S CONTROL(32F630)
Front Panel
POWER
Press →.... Changes or selects the TV adjustments on the MENU screens.
Press again → ...needed to external video INPUT 3 mode or COMPONENT mode.
Service Manual - Page 5
...time needed to charge the phosphorescent display will vary depending on the remote control, place it is muted, CLOSED CAPTION appears if available. Press...TV converter and DVD control. Changes or selects the TV adjustments on the MENU screens. To use . MUTE Press → Mutes sound. Moves the Æ mark on On-Screen Display. Infrared Transmitter Window
CATV/DVD-TV/VCR MODE buttons Press TV...
Service Manual - Page 6
... mode and select the service adjustment "V11" and Bus data "01" (Y-mute on the screen. 7. Receive a good local channel. 4. Apply external 17.3V DC at TP651 by a... 32F630 32F631
Note:
INSTALLATION AND SERVICE INSTRUCTIONS
(1) When performing any adjustments to resistor controls and transformers use non-metallic screwdrivers or TV alignment tools.
(2) Before performing adjustments, the TV ...
Service Manual - Page 7
... are required.
1. To enter the service mode and exit service mode.
32F630 32F631
For adjustments of one, from "V01" to adjust.
3. Follow ... of this series such as focus and master screen voltage. Select the item you wish to "P08". Now the TV set . Service mode
Before putting unit into...service mode, turn the television off by the D/A converter circuit. DATA NUMBER SERVICE ADJUSTMENT NUMBER
CHANNEL
V01
55...
Service Manual - Page 8
... Format (Offset) Standard value for the self-adjustment
FIXED VALUE (HEX)
32 02 02 03 02 00 3F F4 E6 FD F8 01 06 01 ...BPF/TOF-INPUT
V37
CORING
V38
VSM PHASE
V39
COLOR γ
V40
SHARP-INPUT
V41
TINT-INPUT
V42
PICTURE-COMPONENT
V43
TINT-COMPONENT
V44
COLOR-COMPONENT
... / Holizontal "-"
Offset Color Temp. Color Temp.
Color Temp. Color Temp. 32F630 32F631
A. Color Temp.
Service Manual - Page 9
...) 208 (D0h) 228 (E4h) 2 (02h) 15 (0Fh) 15 (0Fh) 1 (01h) 15 (0Fh) 15 (0Fh) 17 (11h) 16 (10h)
NOTES
32F630 32F631
FIXED VALUE (HEX)
32 00 00 00
0B
06 06 0B 32 02 02
FIXED VALUE (HEX)
24 1C 7A 5A 00 12 00 0A
FIXED VALUE (HEX)
F5 BC 0F
FIXED...
Service Manual - Page 10
...the service adjustment "V11" and adjust the data value to obtain normal brightness range. Reset the master screen control to "01", this step, if you selected a B/W picture or monoscope pattern. 3. Receive a... "V07" green and "V08" blue to picture tube only. 32F630 32F631
Holding down both the VOL-up and CH-up buttons on the TV set at low brightness level. 6. Note 2 : Setting the...
Service Manual - Page 11
...stored in figure "A" and "B" as below respectively.
32F630 32F631
Holding down both the VOL-up and CH-up buttons on the TV set at low brightness level. 6. Screen Adjustment
1. Adjust the master screen control until a good grey scale with normal whites at...scale with normal whites is obtained. (RF Input) 4. The adjustment is needed to point where no noise or
beat appears.
Service Manual - Page 12
...color level.
Adjust "D18" data value so that picture is centered. (SCREEN FORMAT 16:9) 3. Input data of the flyback transformer to
make the image as fine as "D08" data.
11 Adjust "...and V-size, readjustment for both left and right side. (SCREEN FORMAT 16:9) 4. EW-Trapezium
1. Input data of "D21" same as "D05" data. (V-LIN)
32F630 32F631
Note: Aging for EW parabola. 3. Sub-Tint ...
Service Manual - Page 13
Connect a capacitor (100µF, 50V) in position on the screen. Feed the following stereo pilot signal to pin (39) of the speaker at ...dB CHK spec: above 1. SETTING VOLTAGE
ADJ spec : 490±10mVrms CHK spec: 490±20mVrms
MTS VCO Adjustment
1. 32F630 32F631
Ë MTS ADJUSTMENT
MTS Level Adjustment
1. Set the sound volume above 20 dB
12 Monoral signal: 400Hz, 100% modulation...
Service Manual - Page 18
... subject to chassis ground.)
å AND SHADED (
) COMPONENTS
= SAFETY RELATED PARTS.
ç MARK= X-RAY RELATED PARTS.
This circuit diagram is omitted.
(K=kΩ=1000Ω, M=MΩ) 2. 32F630 32F631
DESCRIPTION OF SCHEMATIC DIAGRAM
NOTES: 1. Photographs taken on the tint, color level and picture control.
2. All capacitors are measured with 1000µ V B & W or Color...
Service Manual - Page 28
32F630 32F631
PRINTED WIRING BOARD ASSEMBLIES
H
G
F
E
D
C
B
A
PWB-A: MAIN Unit (Components Side)
1
2
3
4
5
6
34
Service Manual - Page 31
32F630 32F631
H
G
F
E
D
C
B
PWB-H: DF MODULE Unit (Wiring Side)
A
1
2
3
4
5
6
37
Service Manual - Page 32
32F630 32F631
H
G
PWB-F: CONTROL Unit(32F631 ONLY) (Component Side)
F
E
PWB-F: CONTROL Unit(32F631 ONLY) (Wiring Side)
D
C
B
A
PWB-S: AUDIO Unit (Wiring Side)
PWB-S: AUDIO Unit (Chip Parts Side)
1
2
3
4
5
6
38
Service Manual - Page 33
... DESCRIPTION
in this service manual may create shock, fire or other hazards. Main Unit(32F630)
- PWB-C DUNTKB573WEV0 - 3-Line Y/C Unit
- Control Unit(32F631)
-
electrical components...No.
5
Description
Code
PARTS LIST
PARTS REPLACEMENT
Replacement parts which does no have your nearest SHARP Parts Distributor to order. PART NO.
2. Audio Unit
-
PWB-A DUNTKB567WEX8 -
No....
Service Manual - Page 38
...å F701 QFS-B4023CEZZ X Fuse, 4A/125V
AB
J904 QJAKGA031WJZZ X Front In Jack(32F630)
AC
J921 QSOCD0430CEZZ X S-Video Terminal
AC
J1401 QTANJ1101SEZZ X In Out Jack
AF
P361 QPLGN0461CEZZA...for IC751
AB
RDA1403PRDAR5072CEFW X Heat Sink for IC1403
AB
RMC2601 RRMCU0222CEZZ X Remote Receiver(32F630) AD
RY701 RRLYJ0081CEZZ X Relay
AD
SG601 QSPGH0025CEZZ X Spark Gap
CF2040 RCRM-0003CEZZ+...
Service Manual - Page 42
...
2B GCABB0160GJKB X Rear Cabinet
Code
Ref.
No. No. Part No.
5
Description
CABINET PARTS
1A 1A-1 1A-2 1A-3 1A-4 1A-5 1A-6 1A-8 1A-7
32F630
CCABAA208WEH0 X Front Cabinet Ass'y
Not Available
- Part No.
5
Description
Code
CABINET PARTS LOCATION
BF
AD
1A 1A-1
2A
AC
AD
AE
AC
AC
AB
AD
AF
AC
AE
AC...
Similar Questions
Sharp 21vr70mm
my sharp turns on but the screen comes after 10 min..have u any idea what the problem could be?
my sharp turns on but the screen comes after 10 min..have u any idea what the problem could be?
(Posted by shimakhaisinghgh 8 years ago)
No More Av 1 On My Sharp X Flat Screen 32' Tv...any Help Please...
(Posted by bobbyabs531 11 years ago)
Xbox Showing Black And White
My xbox 360 live wireless consol is showing black and white with my sharp flat screen tv. How to cha...
My xbox 360 live wireless consol is showing black and white with my sharp flat screen tv. How to cha...
(Posted by monalisamar 11 years ago)
I Would Like A Manual For A Sharp X-flat Flat-screen Tv. Thank You.
I'm not sure of the model number and maybe it isn't 32 inches but a little smaller, but I think any ...
I'm not sure of the model number and maybe it isn't 32 inches but a little smaller, but I think any ...
(Posted by Anonymous-29428 13 years ago)
Need User Manual Sharp X-flat 32f630
need user manual Sharp X-Flat 32F630
need user manual Sharp X-Flat 32F630
(Posted by prasad861 13 years ago)