Invacare M91 Support Question
Invacare M91 Support Question
Find answers below for this question about Invacare M91.Need a Invacare M91 manual? We have 1 online manual for this item!
Question posted by mike1man on May 17th, 2014
Battery Replacement
Starting left to right on battery light indicater. The light are two red, Two amber, and four green. Is this normal or is charger or batteries bad.
Current Answers
Related Invacare M91 Manual Pages
Owners Manual - Page 3
...2
REGISTER YOUR PRODUCT 6
SPECIAL NOTES 7
LABEL LOCATIONS 9
M91 Standard...9 M91 Heavy Duty...10 All Wheelchairs...10 TYPICAL PRODUCT PARAMETERS 11
PRONTO M91...11
SECTION 1-GENERAL GUIDELINES 13
Controller Settings/Repair or Service 13 Accessories Information ...13 Operation Information ...13 Batteries...15
Charging Batteries ...15 Grounding Instructions ...16 Rain Test...16 Weight Training...
Owners Manual - Page 4
... Indicator Light Diagnostics 29 Checking Battery Charge Level...30
SECTION 5-WHEELCHAIR OPERATION 31
Operating the Wheelchair...31 Turning the Power On/Off ...31 On/Off Button ...31 Using the Joystick to Drive the Wheelchair 31
SPJ™+ Joystick Switches and Indicators 33 On/Off Button ...33 Speedometer ...33 Speed Control Buttons...33 Joystick...34 Charger/Programming...
Owners Manual - Page 6
...Replacing Front/Rear Caster Assemblies 58 Adjusting Forks ...58
SECTION 11-BATTERIES 59
Installing/Removing the Batteries...60 Installing...60 Removing ...62
Connecting/Disconnecting the Battery Wiring Harness 62 Connecting ...63 Disconnecting ...63
Charging Batteries ...64 Battery Charger Operation...65
On-Board Battery Charger...65 Independent Charger...
1. Pronto® M91™ with product ...
Owners Manual - Page 7
... not perform that procedure. However, final selection of the type of wheelchair to meet many needs of wheelchairs should be replaced IMMEDIATELY. There are used by an individual rests solely with SureStep®... loads such as auto or aircraft safety belts. Part No 1141450
7
Pronto® M91™ with the user and his/her healthcare professional capable of the restraints made by...
Owners Manual - Page 15
...batteries.
Batteries
The warranty and performance specifications contained in this unit. Carefully read battery/battery charger information prior to the user. Attempting to "wedge" a battery into the battery case. Part No 1141450
15
Pronto® M91™ with the battery... NOT attempt to recharge the batteries and operate the wheelchair at least 16 AWG (American Wire Gauge...
Owners Manual - Page 16
...® M91™ with or for Invacare products.
Doing so will reduce the life of the battery tray. DO NOT under any circumstances, cut or remove the round grounding plug from a rain storm and retain wheelchair operation.
In addition, Invacare has placed RED/ORANGE warning tags on ‐board battery charger and an independent battery charger (plugged into...
Owners Manual - Page 17
... or cracked, replace IMMEDIATELY.
DO NOT use of its wheelchairs as a seat for bodily injury and the warranty is torn or cracked. SECTION 1-GENERAL GUIDELINES
Direct exposure to excessive rain or dampness may cause the wheelchair to malfunction electrically and mechanically, may cause the wheelchair to ensure that the RED and BLACK battery terminal caps are...
Owners Manual - Page 20
... may encounter, however ALL WARNINGS and CAUTIONS given in this manual MUST be replaced IMMEDIATELY. This wheelchair has been designed to use as a safety device withstanding high stress loads such as auto or aircraft safety belts.
Pronto® M91™ with "safety" as a tool to avoid hard braking or sudden stops. The techniques...
Owners Manual - Page 28
...
SYMPTOM
Batteries draw excessive current when charging. PROBABLE CAUSE
Battery failure.
Damaged motor coupling. Contact Dealer/Invacare for shorted cell. Engage motor lock. Replace if ...Invacare for shorted cell. Pronto® M91™ with each wheelchair. Check batteries for service.
Malfunctioning battery charger.
Battery indicator flashes the charge level is routed...
Owners Manual - Page 29
...Refer to Connecting/Disconnecting the Battery Wiring Harness on implies reduced battery charge. Battery charge is off . Left to the individual Electronics Manual supplied with each wheelchair
The joystick information gauge and the service indicator give indications of the type of error codes, refer to Right "chase" alter-
mode. If necessary, replace batteries.
the current state of...
Owners Manual - Page 30
... Don't tap on the terminals.
Check to the lowest level.
Fully charge a new battery before operating the wheelchair. SECTION 4-SAFETY INSPECTION/TROUBLESHOOTING
NUMBER OF
FLASHES
3 4 5 6 7
8 9 10 11
ERROR CODE DESCRIPTION
Left Motor Fault Right Motor Fault Left Park Brake Fault Right Park Brake Fault
Remote Fault
Controller Fault Communications Fault
General Fault Incompatible or...
Owners Manual - Page 32
...wheelchair as slowly as possible by the setting of the proportional control and allow you to a stop smoothly. Move the joystick RIGHT.
Adjust speed.
To slow the wheelchair to start...
To Move Right
Joystick
To Move Left
To Move Backward
FIGURE 5.2 Operating the Wheelchair
Pronto® M91™ with SureStep®
32
Part No 1141450 SECTION 5-WHEELCHAIR OPERATION
The ...
Owners Manual - Page 33
... Button
This button is used to show the maximum speed. The bottom left GREEN LED flashes to lock or unlock the joystick (if programmed). The right‐most LED indicates current maximum speed setting.
It is located at 20% speed. SECTION 5-WHEELCHAIR OPERATION
SPJ™+ Joystick Switches and Indicators
NOTE: For the following information...
Owners Manual - Page 52
... mounting screw and coved washer that secure the heel loop to the footrest. Heel Loop
Articulating Footplate
FIGURE 9.12 Composite/Articulating Footplate Heel Loop Replacement
Pronto® M91™ with SureStep®
52
Part No 1141450 Remove the mounting screw and locknut that secures the lower half of the footrest to FIGURE...
Owners Manual - Page 59
... SureStep® Part No 1141450
59
Pronto® M91™ with skin and eyes. The use of rubber gloves is the most convenient method and assures that battery installation and battery replacement always be used -
For proper battery connection, batteries MUST use , make sure all attaching hardware is battery acid in an upright position. Determine source of...
Owners Manual - Page 60
... the Off position and disconnect joystick. Pronto® M91™ with the rear battery. NOTE: Have the following to the front of FIGURE 11.1).
8. If necessary, disconnect right and left motor leads to allow unobstructed access to position the battery into the battery tray. Refer to Connecting/ Disconnecting the Battery Wiring Harness on page 69.
3. Remove the...
Owners Manual - Page 62
... one battery at a time starting with the FRONT battery. Remove the seat. If necessary, disconnect the wiring harness from battery tray.
11. Place the wheelchair in Lifting Strap‐ Use the battery lifting strap to the POSITIVE (+) terminal.
ƽWARNING
DO NOT remove fuse or mounting hardware from controller (RED connector). If necessary, disconnect right and left motor leads...
Owners Manual - Page 65
... .
If the On/Off LED indicator is "Blinking" RED, this procedure, refer to be used. NOTE: If the batteries need to be charged more often or take longer to charge than normal, they may need to FIGURE 11.4 on page 66.
NOTE: Charge indicator light is called "charge rate". DO NOT under any circumstances...
Owners Manual - Page 66
... Outlet
Female Connector on AC Power Cord
(Connects to AC Receptacle on Charger)
Male Connector on AC Power Cord (Connects to the wheelchair.
When the On/Off LED indicator light is off, charger is removed. When the Charge LED indicator light is solid GREEN, the batteries are charging. 6. If charging instructions are not supplied, consult a qualified technician...
Owners Manual - Page 71
... THE WARRANTY SHALL NOT APPLY TO PROBLEMS ARISING FROM NORMAL WEAR AND TEAR OR FAILURE TO ADHERE TO THE... REPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT PURSUANT TO THE TERMS CONTAINED HEREIN. Part No 1141450
71
Pronto® M91™ with... rights and you purchased your exclusive remedy under this warranty. Invacare warrants all electronics and electrical components (excluding batteries),...
Similar Questions
The Battery Lights Are Not Staying Lit Moving? Why?
(Posted by Lashleykileykjl 2 years ago)
Lift Seat Remove To Change Batteries
How do I remove the seat on power lift equiped chair to remove upper shroud and replace batteries.
How do I remove the seat on power lift equiped chair to remove upper shroud and replace batteries.
(Posted by ThrockShots 2 years ago)
How Do I Replace The Batteries On My Ato Tdx Sp - Cg Invacare Wheelchair
(Posted by cwjohnsonjr55 2 years ago)
Invacare Tdxsp Displaying Right Motor Fault And Will Not Drive
My client has a Invacare ATO_TDXSP-CG and a few days ago it started displaying, "right motor fault"....
My client has a Invacare ATO_TDXSP-CG and a few days ago it started displaying, "right motor fault"....
(Posted by smgoulding1 5 years ago)
Replacment Power Cord
where can I get a replacement power cord for pronto sure step M91 electric chair
where can I get a replacement power cord for pronto sure step M91 electric chair
(Posted by mmak 10 years ago)