Honeywell HW4000 Support Question
Honeywell HW4000 Support Question
Find answers below for this question about Honeywell HW4000 - Portable Generator NOT.Need a Honeywell HW4000 manual? We have 1 online manual for this item!
Question posted by blueoreo8 on February 28th, 2012
Miller Welder
I have a milleer 140 auto set wire welder input power 115v , 20a 60 Hz single phase rated output 63A, 21 VDC at 20% duty cyle amp range 30-140A Max open circuit Voltage 28 rated output KW 2.4 and 1.8 I was told by the air gas dealer that this gen. will run this welder with no problem I did some checking around first before I bought this gen. honeywell HW4000 I tryed it out I can weld for about a min. then the main braker pops what do I need to do? do I need to go and get a adapter cord to go in the 120/240 plug. thanks hope to here from you soon Travis
Current Answers
Related Honeywell HW4000 Manual Pages
Owners Manual - Page 1
HW4000 Portable Generator
Owner's Manual
Portable Gasoline Generator
Read and Save These Instructions For product inquiries or support, please visit www.honeywellgenerators.com or call toll-free at 1-888-494-3571.
Owners Manual - Page 5
... ...24 Spark Plug Service ...24 Cleaning Spark Arrestor Screen ...25 Transporting Generator ...26 Storing Generator ...26
TROUBLESHOOTING ...29 SPECIFICATIONS ...31
WARRANTIES ...33
NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY 33 NORTHSHORE POWER SYSTEMS LIMITED WARRANTY 35
INDEX ...37 HW4000 MAINTENANCE PARTS 39
HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
i
Owners Manual - Page 7
...generator must read, understand, and follow these instructions can result in death or serious injury to the operator or to bystanders. Safety Messages
Signal Words
Safety messages are open... help prevent personal injury and equipment damage. HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
1
Generator exhaust contains carbon monoxide. Indicates a situation which...
Owners Manual - Page 8
... equipment to isolate generator from
buildings and other equipment during operation and remains hot for backup power, notify utility company. After refueling, make sure the tank cap is stored. • NEVER overfill the fuel tank (there should be sure the area is dry before storing the generator indoors.
2
www.honeywellgenerators.com
HW4000 Portable Generator Owner's Manual
Owners Manual - Page 11
... loss or damage is heavy! HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
5 Failure to closely follow all instructions and precautions can cause you and others to be seriously hurt or killed. ‰ Owner's Manual
Inspect for Damage
Carefully inspect generator for operation. Open carton completely by using the generator must read and understand all safety...
Owners Manual - Page 17
...feedback into utility lines. Electrical current can be connected to feedback into generator. What is either a manual switch, an automatic switch or a combination of generator without backfeeding onto utility.
Electrical current from utility line, allowing for Backup Power
HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
11 Such feedback may explode, burn, or...
Owners Manual - Page 19
... overload or short-circuit by stopping flow of fuel from fuel tank to Operation section (page 15) for power. F-Fuel Valve Controls flow of electricity between generator and appliance. H-Choke Control Controls choke valve. Choke control must be removed. I
D
A
H G
F
E
B
C
FIGURE 12: HW4000 Portable Generator
K L
A-Power Control Center Household Outlets 120V 20 Amp Duplex outlets to...
Owners Manual - Page 21
... inside a home Only use and match amp and voltage ratings of engine oil to accumulate.
If generator is tilted or overturned, fuel spillage may enter generator. For initial start generator: 1. HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
15 If generator is placed on . Starting generator with electrical appliances plugged
in this Owner's Manual...
Owners Manual - Page 22
... turned on.
16
www.honeywellgenerators.com
HW4000 Portable Generator Owner's Manual Rules for 2-3 minutes. 3. ON/OFF position
3.
Apply a swift, single pull to start generator with suitable carburetor jetting, engine horsepower will be connected to run for Powering Appliances
FIGURE 16: Recoil Starter Handle
6. Stopping Generator
2. Stopping Generator
In an emergency: Press and...
Owners Manual - Page 23
.... Typical Appliance Running Wattages
HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
17
Power rating information can result in good working order.
• Plan carefully: Before using an extension
cord to connect appliance to add power rating (watts) of each appliance and verify that total wattage does not exceed rated output of generator has been exceeded.
•...
Owners Manual - Page 24
... power rating of generator.
18
www.honeywellgenerators.com
HW4000 Portable Generator Owner's Manual Typical Appliance Running Wattages
* Allow up to three times normal running watts for starting or cycling compressor of motorized appliances include refrigerators, water pumps, and furnace blowers. Powering Appliances
Appliance
Typical Running Watts
Toaster oven
1225
VCR/DVD
17-21 / 20...
Owners Manual - Page 25
...HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
19 If engine must be run, be sure area is a poison you cannot see or smell.
Always follow inspection and maintenance recommendations and schedules in dusty areas. ‡ It is recommended that this owner's manual.
Using a generator...
Before each use
X X X
First month or 20 hours of use
X
Every 3 months or 50 ...
Owners Manual - Page 29
... operating under normal load, drain fuel (page 27) and refill with persistent spark knock or pinging can cause fire or explosion. Rinse air filter thoroughly. 6. HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
23 Air Filter Maintenance
4. Be careful not to loosen and remove.
2B. iNOTE: Occasional, light spark knock, "pinging", or rattling...
Owners Manual - Page 34
THIS PAGE INTENTIONALLY LEFT BLANK
28
www.honeywellgenerators.com
HW4000 Portable Generator Owner's Manual
Owners Manual - Page 35
...HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
29
Have appliance serviced by qualified repair facility.
* Master circuit breaker controls power...20). No power at AC receptacle
1 Electrical overload on
circuit, wait 3 minutes,
Set
and then push to reset cir-
Replace defective
cord set .
3 Connected electrical appliance/
equipment is a poison you are open...
Owners Manual - Page 37
...GENERATOR
Dimensions*
Length
27 inches (685.8 mm)
Width
21.5 inches (546.1 mm)
Height
21.5 inches (546.1 mm)
Dry Weight
155 pounds (70.3 kg)
AC Output
Continuous (Rated) Power)
4000 Watts
Maximum Power
5000 Watts
Surge Power
6000 Watts
Frequency
60 Hz
Voltage... HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
31 HW4000 Portable Generator Specifications * Measurements ...
Owners Manual - Page 39
...set below .
1. Vent lines C. The emissions control parts are responsible to maintain the engine as described in the Honeywell Generator Owner's Manual, use emissions test. Carburetor C. Ignition coil
4. Repair or Replacement Cost.
Exhaust manifold C. Maintenance. HW4000 Portable Generator...
NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY
Honeywell Portable Generator
WARRANTY ...
Owners Manual - Page 40
... responsibilities, you should contact the Warranty and Service department at NSP. By phone: (414) 332-2375 Via web: www.honeywellgenerators.com By US mail: Northshore Power Systems, LLC Attention: Product Warranty and Service Dept. 4425 N Port Washington Road Suite 105 Milwaukee WI 53212-1082
34
www.honeywellgenerators.com
HW4000 Portable Generator Owner's Manual
Owners Manual - Page 41
... This limited warranty has time period conditions, operating conditions and disclaimers, limitations of purchase to :
Northshore Power Systems, LLC Attention: Product Warranty and Service Dept. 4425 N Port Washington Road Suite 105 Milwaukee WI 53212-1082
HW4000 Portable Generator Owner's Manual
www.honeywellgenerators.com
35 Commercial Use: 1 Year Limited. DISCLAIMERS, LIMITATIONS OF REMEDIES...
Owners Manual - Page 43
... 3 specifications 31 starting 15 stopping 16 storing 26 transporting 26
HW4000 Portable Generator Owner's Manual
INDEX
unpacking guidelines 5 warranty 35 Ground 10 special requirements 10 terminal 13
H Handles installing 10 High Altitude operation 16
M Maintenance 19 air filter 23 changing engine oil 21 cleaning spark arrestor 25 fuel sediment cup 24 parts listing 39...
Similar Questions
Seeking A Part For A Honeywell 2000i Portable Generator.
I require a 'primer bulb for my Honeywell 2000i model portable generator. Can you supply or, in the ...
I require a 'primer bulb for my Honeywell 2000i model portable generator. Can you supply or, in the ...
(Posted by jawbonegb42 9 months ago)
Need Fuel Line Diagram For 1000i Generator
(Posted by luckyballs1970 2 years ago)
Honeywell Hw5500 And A Big Bandsaw
I am looking at a hw5500 generator. I'm wondering if it will run my vintage walker turner bandsaw? I...
I am looking at a hw5500 generator. I'm wondering if it will run my vintage walker turner bandsaw? I...
(Posted by hawgeyemike 2 years ago)
Honeywell Hw1000i Generator 144f 10070149 Engine Parts
I am trying to find the engine cylinder valve retainer that holds the spring in place for the valve....
I am trying to find the engine cylinder valve retainer that holds the spring in place for the valve....
(Posted by eric83489 2 years ago)
Voltage Too High On Hw4000 Generator
I measured voltage at 240 outlet on Honeywell HW4000 generator. It varies under no-load, but is at 2...
I measured voltage at 240 outlet on Honeywell HW4000 generator. It varies under no-load, but is at 2...
(Posted by byron66778 12 years ago)