Hayward SwimClear Support Question
Hayward SwimClear Support Question
Find answers below for this question about Hayward SwimClear.Need a Hayward SwimClear manual? We have 2 online manuals for this item!
Question posted by cruisinged on August 26th, 2012
Leaking Air And Water From The Manual Air Relief Valve.
When I turn on the Hayward SwimClear, the manual air relief valve blows air and water, no matter how tight I close the pressure gauge switch. This is the first time it happened in four years. Can I fix it myself or do I need a Pro?
Current Answers
Related Hayward SwimClear Manual Pages
Models: C2020 C3030 C3040 C3050 - Page 8
...Hayward Pool Products, Inc. 900 Fairmont Avenue Elizabeth, NJ 07207
Hayward Pool Products, Inc. 2875 Pomona Boulevard Pomona, CA 91768
Hayward Pool Products Canada 2880 Plymouth Drive Oakville, Ontario L6H 5R4
www.haywardnet.com
Hayward Pool...2000 Air Relief Valve W/0-Ring (ECX1322A)
sure Gauge (ECX27091)
0-Ring Kit La Set of 2)
(DEX2420Z8A)
Filter Sleeve (DEX2420AR12)
Automatic
A Air Relief ...
Models: C2025 C3025 C4025 C5025 C7000 - Page 1
...
568
C5025
525
48.8
150
568
C7000
680
63.2
150
568
MAXIMUM WORKING PRESSURE FOR ALL MODELS 50 PSI (3.45 BAR)
ATTENTION INSTALLER: THIS MANUAL CONTAINS IMPORTANT INFORMATION ON THE OPERATION, AND SAFE USE OF THIS EQUIPMENT.
THIS MANUAL IS INTENDED FOR THE END USER OF THIS PRODUCT
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Models: C2025 C3025 C4025 C5025 C7000 - Page 2
... HAZARD
Pool and spa water circulation systems operate under hazardous pressure during start up, normal operation, and possibly after pump shut off all system and pump controls are important but not related to close manual air relief valve only when a steady stream of the upper filter body if safety and operation instructions are unpredictable and unsafe. Page 2 of 12
SWIMCLEAR...
Models: C2025 C3025 C4025 C5025 C7000 - Page 3
... gravity drain system. • Failure to remove pressure test plugs and/or plugs used in winterization of the pool/spa from near point to near point.
• Dual...12
SWIMCLEAR CARTRIDGE FILTER
ISC2028 REV C
WARNING - SUCTION ENTRAPMENT HAZARD. Body Suction Entrapment- Evisceration/ Disembowelment Entrapment- USE ONLY HAYWARD GENUINE REPLACEMENT PARTS A negative pressure applied...
Models: C2025 C3025 C4025 C5025 C7000 - Page 4
... sun.
5.
Connect the pool suction plumbing between the skimmer, pool outlet (from electrical devices. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS If practical, place pump and filter in the shade to the pool).
7. The filter system should be installed on a level concrete slab or other rigid base. Verify water discharge from the manual air relief valve(MAR) is directed away...
Models: C2025 C3025 C4025 C5025 C7000 - Page 5
... is time to flow. Once your filter cartridge elements. Do not return to CLOSE manual air relief valve only when a steady stream of 12
SWIMCLEAR CARTRIDGE FILTER
ISC2028 REV C
STARTING THE PUMP and FILTER SYSTEM WARNING
Before Starting the Pump 1.Use ONLY Hayward clamp system components;
Page 5 of water (not air or, air and water mix) is in this owner's manual to the pool...
Models: C2025 C3025 C4025 C5025 C7000 - Page 6
FILTER DISASSEMBLY INSTRUCTIONS 1. The manual air relief valve must be damaged. Using 3/4" wrenches, loosen and remove the clamp nut and
the clamp bolt. (Fig 5) 6.
Do not use the pressure gauge to drop the clamp during removal, because the clamp could be placed in a position to prevent water flow to remove fine particles. Do not to lift the upper...
Models: C2025 C3025 C4025 C5025 C7000 - Page 7
...
1. Replace the filter clamp around
the manual air relief area. 3. Follow Operation Instructions for "... filter body and from the bottom of 12
SWIMCLEAR CARTRIDGE FILTER
FILTER RE-ASSEMBLY INSTRUCTIONS
WARNING
RE-...Clamp Nut
inch-lbs.
2. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Remove filter tank seal....VACUUMING POOL Vacuuming can be performed directly into the filter whenever needed.
...
Models: C2025 C3025 C4025 C5025 C7000 - Page 8
... THE MANUAL AIR RELIEF VALVE 1. Press the MAR straight down into the upper filter body. 5. Verify the MAR discharge points away from flowing to prevent water from all dirt and debris. 3. The filter should be serviced, follow REMOVING CARTRIDGES per FILTER RE-ASSEMBLY INSTRUCTIONS. 5. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
For Qualified pool professionals only: If MAR valve needs...
Models: C2025 C3025 C4025 C5025 C7000 - Page 9
...
super-chlorinate as required.
2. POOL WATER WON'T CLEAR UP 1. Check for air leak in proper range (adjust as required.
2. Be sure flow rate through filter is sufficient.
3. Operate filter for longer periods. No returns may be made directly to the factory without the expressed written authorization of 12
SWIMCLEAR CARTRIDGE FILTER
ISC2028 REV C
SERVICE AND...
Models: C2025 C3025 C4025 C5025 C7000 - Page 10
...Air Relief Valve Nut Manual Air Relief w/O-Ring Manual Air Relief...Tie and Owner's Manual Complete as listed above Complete as listed above
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS ...DEX2420AT SP1022C DEX2420DCKIT SX220Z2 DEX2420F DE2400PAK2CS
DEX2420LA6PAK
DEX2420LA6PAK DEX2420LA6PAK
Description
Pressure Gauge O-Ring Kit (Set of 12
SWIMCLEAR CARTRIDGE FILTER
ISC2028 REV C
Item
1 2 3 4...
Models: C2025 C3025 C4025 C5025 C7000 - Page 11
...as original purchaser of this equipment, Hayward Pool Products warrants its products free from defects in materials and workmanship for a period of ONE (1) year from the date of purchase. Some...This warranty gives you specific legal rights, and you . Page 11 of 12
SWIMCLEAR CARTRIDGE FILTER
ISC2028 REV C
HAYWARD® LIMITED WARRANTY
To Buyer, as a result of freezing, negligence, improper...
Models: C2025 C3025 C4025 C5025 C7000 - Page 12
.../installation.
Yes No
REGISTER YOUR WARRANTY ON-LINE AT WWW.HAYWARDNET.COM
© Hayward Pool Products. 2008 All rights reserved. Page 12 of 12
SWIMCLEAR CARTRIDGE FILTER
ISC2028 REV C
PRODUCT REGISTRATION
(Retain For Your Records)
DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER
▲Retain this...
Similar Questions
Video How To Replace A Manifold In A Hayward Pool Filter
(Posted by Pedifluk 10 years ago)
Pro-grid Filter Leaking At Base Of Manual Air Relief Valve
The filter is leaking at the top, at the base of the manual air relief valve. What would cause this,...
The filter is leaking at the top, at the base of the manual air relief valve. What would cause this,...
(Posted by lwallas 11 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)