Hayward Power-Flo LX Support Question
Hayward Power-Flo LX Support Question
Find answers below for this question about Hayward Power-Flo LX.Need a Hayward Power-Flo LX manual? We have 3 online manuals for this item!
Question posted by luciamiesse on June 26th, 2022
Strainer Basket
Apparently I put the basket in the wrong way(large hole facing back.) How can I get this out?
Current Answers
Answer #1: Posted by SonuKumar on June 26th, 2022 8:40 AM
SonuKumar
Member since:
May 9th, 2021 Points: 16,620,300
Member since:
May 9th, 2021 Points: 16,620,300
https://www.youtube.com/watch?v=RFbIvJwNAsM
How do you rotate a Hayward power Flo LX pump?
To rotate the pump housing, press down firmly on the tab located on the shroud.
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Hayward Power-Flo LX Manual Pages
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 1
...the pool as large or larger than discharge pipe. NOTE: If your pump is equipped with hot tubs and spas if ...product unless they are tight.
STARTING AND PRIMING INSTRUCTIONS
Fill strainer housing with the motor's voltage, phase and cycle, and .... A permanently installed pool is adequate for safe and proper installation of air to minimize abuse from power source. Motors require free...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 2
... O-Ring Check Valve Assembly (Optional) Basket Strainer Cover O-Ring Strainer Cover, Clear Lexan© Drain Plug (Optional -
DWG. SPX1510-Z-1E
SPX1510-Z-1XE
SPX1515-Z-1E
SP-1500-CP
SP-1500-CP
SP-1500-CP
SPX1500-W
SPX1500-W
SPX1500-W
SPX1500-RA
SPX1500-RA
SPX1500-RA
SPX1500-LX
SPX1500-LX
SPX1500-LX
SPX1500-P
SPX1500-P
SPX1500-P
SPX1500-D-2
SPX1500-D-2
SPX1500-D-2
SPX1700...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 3
...ceramic seat, with ceramic seat inside, into clear plastic seat retainer-polished surface facing out. Smith Canopy Style Motors: Remove motor end cover and carefully apply ...and evenly.
9. Reconnect pump to pump housing with strainer attached) by turning clockwise.
11. AMPS RATINGS - SEAL CHANGE INSTRUCTIONS
Power Flo™ LX Series with a dilute solution of non-granulated liquid-...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 4
...
4. Check voltage to wear or damage. MAINTENANCE
1. Clean strainer basket regularly. Occasionally, shaft seals must be replaced, due to...will develop a vacuum. PUMP WON'T PRIME
1. Make sure all electric power. Generally, check for : 1. Check for : 1. Shut off ... Insure air vents are open and unobstructed, and that pool water level is equipped with water and that cover O-...
SP1575X15 - Page 1
... proper installation of suction piping. Clean strainer basket regularly. Do not strike
basket to the pool by applicable electrical codes.
STORAGE/WINTERIZING ...pool, please see TROUBLE SHOOTING GUIDE on power and allow a reasonable time for the mechanical shaft seal. Shut off all suction and discharge lines and valves, as well as large or larger than discharge pipe. Inspect strainer...
SP1575X15 - Page 2
... Impeller Seal Assembly Pump Housing Nut, No. 10-24 Hex. Motor Strainer Housing O-Ring Basket Strainer Cover O-Ring Strainer Cover Drain Plug w/Gasket Strainer Shim Ring (Horizontal Outlet Pumps Only)
NO. REQ'D.
7 1 1 1 1 1 7 1 1 1 1 1 1 2 1
PART NUMBER MODEL
SP1575X15 (With Strainer) SPX1500N2 SPX1500B SPX1500H SPX1500F SPX1500KA SPX1500AA SPX1500Y2 SPX1515Z1E SPX1500CA SPX1500W SPX1250R...
SP1575X15 - Page 3
...and secure motor to fill strainer with strainer attached) by dirt or scratching...power before restarting.
*For A.O. SEAL CHANGE INSTRUCTIONS
SP1500 SERIES
GENERAL
Exercise extreme care in handling and installing the new seal and ceramic seat assembly. Replace the assembly firmly and evenly.
9. Note carefully the position of pump housing-O-ring end first. Gently wipe the polished face...
SP1575X15 - Page 4
.... (Amperage reading)
NOTE: Your Hayward pump motor is locked firmly in suction piping. Check for blocked suction line or strainer, or air leak in position. 2.
Make sure strainer cover is equipped with water and that pool water level is reached. If pump develops a vacuum, check for : 1.
E. Plugged or restricted discharge line of Hayward...
Owners Manual - Page 1
... death or major property damage and if ignored presents a potential hazard. ISPFSERIES Rev G
PowerFlo LX™ / PowerFlo II™ / EP Pump Series
Owner's Manual
Contents
Product Warnings 2 Installation 4 Start-...in this manual, look for personal injury.
This is the safety-alert symbol. Hayward Pool Products 620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995 www.haywardnet...
Owners Manual - Page 2
... meter] apart, as measured from near point to
prevent their being used in winterization of the pool/spa
from using them as a means of debris, such as leaves, dirt, hair, paper
and... for suction entrapment as described above . WARNING - WARNING - A negative pressure applied to a large portion of a suction outlet sump or suction outlet cover that is running . o Dual suction fittings...
Owners Manual - Page 3
... servicing pool and spa circulation system, filters manual air relief valve must be used with strainer cover lock ring. To reduce the risk of an electrical shock. Before working on a routine basis. WARNING -
Contact a qualified electrician if you cannot verify that is defective. Such a GFCI should be tested on
electrical connections. Power should be...
Owners Manual - Page 4
...use , it is needed. do NOT over-tighten fitting or you face the open end of air for outdoor use Plumber's Pipe Dope as... tape to reduce friction losses). Allow for ball valves in strainer port. The pump suction and outlet ports have molded-in a damp ...Instructions
Pump Location
The PowerFlo LX™ and EP series pumps MUST be installed below the pool water line (see Figure to force ...
Owners Manual - Page 5
... sure to seal wire opening on end of rated voltage when motor is adequate for the H.P. (KW) rating and distance from the power source. In case of swimming pool, spa, or hot tub.
Failure to do not use conduit when wiring motor, be sure to add their amp loads before it will prevent...
Owners Manual - Page 6
... from bottom of pump suction. WARNING - NEVER run pump dry. CLOSE VALVES in your pool/spa system. WARNING -
CAUTION - Propylene glycol is removed of water, re-install the strainer lid and strainer plug. 5.
NEVER operate the pump without water. Fill strainer housing with "Jack's 327" each time it is removed. Clean and inspect O-ring...
Owners Manual - Page 7
... water level. 6. Install all electrical wiring for swimming pool pump installation. Shaft Seal Change Instructions
IMPORTANT SAFETY INSTRUCTIONS ...facing out. 12. Make certain motor shaft turns freely before beginning shaft seal replacement. Tighten screws alternately and evenly. 15. Insert basket and fasten strainer cover. 16. Reconnect pump to instructions. Open all electrical power...
Owners Manual - Page 8
... the motor to automatically restart once the motor has cooled, provided the power source is rotating at motor or power drop (frequently caused by removing the skimmer basket and holding your pool dealer can build up or binded on skimmer wall.
3. Make sure strainer cover is felt, check for clogging or obstruction in OPEN position...
Owners Manual - Page 9
...wiping out the grease causing bearing to wear or damage. Maintenance
Clean strainer basket regularly. Foreign matter in pump. 2.
DATE OF INSTALLATION
INITIAL PRESSURE GAUGE READING...Do NOT strike basket to improper mounting, etc. See "Shaft Seal Change Instructions" in
this point or putting in pool, and
unrestricted discharge return lines. Inspect strainer cover gasket ...
Owners Manual - Page 10
...end of model number to Part No. SPX1524Z1ESC
10 Strainer Housing with Basket
SPX1500CAP
SPX1500CAP
11 Check Valve Assembly (Optional)
SPX1500RA
SPX1500RA
12 Strainer Basket
SPX1250RA
SPX1500LX
13 Strainer Cover O-Ring
SPX1500P
SPX1500P
14 Strainer Cover with O-Ring
SPX1500D2A
SPX1500D2A
15 Complete Strainer Assembly
SP1516
SP1516
16 Drain Plug with Gasket
SPX1700FG
SPX1700FG...
Owners Manual - Page 11
...of incidental or consequential damages, so the above constitutes the entire warranty of Hayward Pool Products with respect to you may not apply to its products to components manufactured... your records. Proof of purchase is in lieu of all previous publications.
HAYWARD® Pool Products Limited Warranty
To original purchasers of this Warranty Certificate (upper portion) in a safe...
Owners Manual - Page 12
... mail within 10 days of Pool: Concrete/Gunite Vinyl Fiberglass Other
New Installation
Replacement
Installation for:
In Ground
Above Ground
Spa
Hayward is not necessary to complete warranty registration for the overall product, using the serial number that have individual serial numbers, it is a registered trademark, and PowerFlo LX, and PowerFlo II are trademarks of...
Similar Questions
Power Flo Lx Model Sp1510z1xbc Hums Will Not Start
I have a power flo lx model sp1510z1xbc when i 1st turned on it started for a minute I shut it off a...
I have a power flo lx model sp1510z1xbc when i 1st turned on it started for a minute I shut it off a...
(Posted by christinedomon77 5 years ago)
I Am Looking For A Hayward Power Flo Lx Pump Model Sp1510-2-xes. Can You Help?
(Posted by gregjaws 8 years ago)
How To Remove A Strainer From A Hayward Power Flo Lx
(Posted by hekijsr 9 years ago)
How To Replace The Strainer Housing On Hayward Power Flo Pool Pump
(Posted by gowthttja 10 years ago)
Hayward Pool Pumps Power Flo Lx Power Switch Won't Shut Off
(Posted by JLCASdm86 10 years ago)