Hayward Perflex Support Question
Hayward Perflex Support Question
Find answers below for this question about Hayward Perflex.Need a Hayward Perflex manual? We have 5 online manuals for this item!
Question posted by tepen67 on July 24th, 2011
How Do You Prime The Hayward Pump Power Flo Lx?
The person who posted this question about this Hayward product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Hayward Perflex Manual Pages
Models: EC65A EC75A - Page 3
... - Do NOT ground to local codes and regulations.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville, TN www.haywardpool...Pool and spa water circulation systems operate under hazardous pressure during pump start
up . Before servicing pool and spa water circulation system, all instructions in open filter manual air relief valve. Before starting system pump...
Models: EC65A EC75A - Page 4
..., TN www.haywardpool.com If the pump is needed for dependable priming. All plumbing connections on the other side of the filter outlet.
The Hayward-Perflex is an alternate bump handle location on the system are covered later.
4. It may be located below the normal pool water line. The pump mounting bracket (EC65BLP) and hardware purchased...
Models: EC65A EC75A - Page 5
...pool grades of operating chemicals, D.E., and a pool
test kit.
Follow chemical manufacturer's recommendations for recharging.
STARTING THE FILTER
Close the filter drain and the vent valve. Prime and start the pump...PREVENTIVE MAINTENANCE
While Perflex filters are recommended for normal daily ... process. Repeat 8 times.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC...
Models: EC65A EC75A - Page 8
... detergent
bumping,
amount of pump. Check cover gasket, hand knobs, hose, clamps, etc.
Power cut-backs or a
combination of filter.
Bumping incorrectly. Pump output exceeds design flow rate...acid solution (or filter
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville, TN www.haywardpool.com Page 8 of algae. coated with pool dirt, algae, 1. Bump. dirt,...
Models: EC65A EC75A - Page 11
...spa. Watch it on these other uses. Hayward Pool Products has an easy, stress-free way for distributing granular chlorine to -remove final gallons of other products from your Perflex... hundreds of water from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater □ Heat Pump
□ Salt/Chlorine Generator...
Perflex EC40 - Page 1
...PUMP SELECTION
To power your Perflex filter, select a continuous duty pump designed for convenient operation. The pump mounting bracket and hardware furnished with the filter will not flood when it rains.
2. Unlike self-priming... the filter "BUMP" handle, drain outlet, and pressure gauge accessible for swimming pool service. Position the filter so the tank can drain by gravity. It is used...
Perflex EC40 - Page 3
... from the pool water, the accumulated dirt causes a resistance to the pool, the filter is suggested valving. 5. Failure to the package instructions.
Prime and start the pump following the ... handle to empty completely. Reinstall the bump cover and grip.
PREVENTIVE MAINTENANCE
While Perflex filters are recommended for recharging. If the concentration of minerals is completely normal....
Perflex EC40C90 Series - Page 2
...do not permit children to follow instructions may also be used as the filtration system, pumps, and heaters be readily disassembled for storage. Closely supervise children at all electrical equipment,...WARNING - The Perflex™ Filtration System is intended for outdoor use on permanently installed
above -ground and on the motor housing and to all metal parts of swimming pool, spa, or hot...
Perflex EC40C90 Series - Page 3
Perflex™ Extended Cycle Filtration System__________
NOTE: The National Electrical Code (NEC) permits use of the pool or spa. Connect only to a grounding
type receptacle protected by entrapped air in injury and/or property damage. WARNING - Failure to electric supply. DANGER - Pumps for above-ground/on the floor and one drain or suction outlet can...
Perflex EC40C90 Series - Page 4
... Power-Flo Matrix™ Pump Series has been engineered as one micron - 100 times smaller than a grain of the Hayward® Perflex™ Filtration System.
All Perflex™ Filtration models are tuned to a horizontal discharge and back again. The Hayward Perflex D.E.
is initially started; It is driven by a heavy duty motor, which is a high performance swimming pool filter...
Perflex EC40C90 Series - Page 5
Perflex™ Extended Cycle Filtration System
Installation Instructions
System Location
For best pump performance, the system MUST be new or thoroughly cleaned before operating system.
12. There is needed .
4. Do not install pump...right). Securely hand tighten the union nut between the skimmer, pool outlet, and the pump. Keep the filter bump handle, drain outlet, and pressure ...
Perflex EC40C90 Series - Page 11
... Nipple
1
Pressure Gauge
1
Flow Diffuser with Check Valve
1
Check Valve
1
Flow Controller
1
Flex-Tube Nest (Includes 6, 9, 10, 11, 12, 13) 1
1 ½" Male Union
1
O-Ring
1
Power-Flo Matrix Pump
1
6 ft.
Perflex™ Extended Cycle Filtration System
Replacement Parts
Parts Diagram
Parts Listing
Ref.
SP0723
15
ECX27081
16
ECX1256
17
ECX4077B1
18
SPX1055
-
Perflex EC40C90 Series - Page 12
... less than 1 □ 1-3 □ 3-5 □ 5-10
Purchased from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater Some states... components manufactured by the respective manufacturer will apply. Perflex™ Extended Cycle Filtration System
HAYWARD® LIMITED WARRANTY
This filter system was inspected ...
Perflex EC50 - Page 1
...priming. is initially started; When the filter powder is totally used diatomite without changing the powder.
Self-priming pumps...Hayward bases and plumbing connections, or with a variety of Teflon tape or plastic pipe sealant to prevent their being used with other side of pump... swimming pool service. PUMP SELECTION
To power your Perflex filter, select a continuous duty pump designed ...
Perflex EC50 - Page 2
... pump; Carefully pry the bump cover from the filter so the tank can be a slight increase in the bottom of diatomite, roughly 7 leveled coffee cans full, or 5 leveled scoops using a wrench, tighten one more than one minute without the precoat charge. then, using Hayward's EC-10SC. 2. Additional tightening is installed below the pool...
Perflex EC50C90 Series - Page 2
... Perflex™ Filtration System is capable of being used with storable pools.
Use a solid copper conductor, size or larger.
KEEP SAFETY LABELS IN GOOD CONDITION AND REPLACE IF MISSING OR DAMAGED.
Do not install in a building such that will not flood when it is intended for use with hot tubs and spas if...
Perflex EC50C90 Series - Page 4
...be used on a strong, molded mounting base. All Perflex™ Filtration models are high performance, above -ground pools ƒ Combines large cleaning capacity with the Hayward Perflex D.E. It's large profile and integrated styling makes the Power-Flo Matrix a swimming pool pump like no longer efficiently remove dirt from the pool water.
D.E. within the filter and extending the filter...
Perflex EC50C90 Series - Page 5
... tape. Securely hand tighten the union nut between the skimmer, pool outlet, and the pump.
Connect the pool suction plumbing between the filter and pump.
7. Perflex™ Extended Cycle Filtration System
Installation Instructions
System Location
For best pump performance, the system MUST be located below the pool water line (See Figure to the gauge threads, and carefully...
Perflex EC50C90 Series - Page 11
No. Part No.
Power-Flo Matrix Pump
1
34a SPX1250WA 6 ft.
Description
No. Operation
1
26
ECX1055
Flow Controller
1
27
ECX4077B1
Check Valve
1
28
ECX1256
Flow Diffuser with Check Valve 1
29
SP1022C
Drain Plug with Large Hole
2
37d DEX360JN
Nickel Plated Sleeve Nut
2
Parts Diagram Twist Lock Cord Set
1
35
ECX1108
Pump Mounting Screw
4
36
ECX1109
Washer...
Perflex EC50C90 Series - Page 12
Perflex™ Extended Cycle Filtration System
HAYWARD® LIMITED WARRANTY
This filter system was inspected before shipment from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater To original purchasers of this Warranty Certificate (upper portion) in materials and workmanship for a period of ...
Similar Questions
How To Connect A Hayward Power-flo Lx Pump To A Hayward Perflex Extended Life
de filter
de filter
(Posted by babbuch 10 years ago)
Hayward Pool Pumps Power Flo Lx Power Switch Won't Shut Off
(Posted by JLCASdm86 10 years ago)
Hayward Ec75a Perflex Pool Filter Loses Prime When Pool Return Is On
(Posted by stvnjujubar6 10 years ago)
How To Prime Hayward Power Flo Lx Above Ground Pool Pump
(Posted by meriosdeluc 10 years ago)