2012 Ford F550 Cab Support Question
2012 Ford F550 Cab Support Question
Find answers below for this question about 2012 Ford F550 Cab.Need a 2012 Ford F550 Cab manual? We have 2 online manuals for this item!
Question posted by skagagk on December 24th, 2013
2012 Ford F550 Where Does The Fuel Filter Go
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 3
... for each cylinder (8 total), • a high-pressure fuel pump, • a high-pressure fuel rail for more information. 3
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Make sure you to other parts. The engine mounted filter filters finer impurities from the fuel. DIESEL ENGINE INFORMATION The diesel engine fuel system is a pressurized two-stage filtration system and...
Diesel Supplement 3rd Printing - Page 4
...2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The fuel injection system is important to modify engine performance characteristics. See Fuel filter/water separator in the Maintenance and Specifications chapter. The fuel... protection mode Ford diesel engines are intended to change interval beyond the recommended interval can negatively affect engine performance, fuel economy and ...
Diesel Supplement 3rd Printing - Page 7
...gauge: Indicates the amount of water in it is contaminated and/or low. Refer to Fuel filter/water separator in the Maintenance and Specifications chapter of this light will illuminate when the ...engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) WARNING: Do not drain the DFCM while the engine is equipped with a fuel filter/water separator to be pumped into the fuel system if ...
Diesel Supplement 3rd Printing - Page 11
...idling in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) In cold weather below , it is installed correctly in P (Park). Diesel fuel which can clog the fuel filters. This will... if the engine starts, stalls after a short time, and then will not restart, the fuel filter(s) may experience a significant reduction in cold weather, special care must be allowed to operate properly...
Diesel Supplement 3rd Printing - Page 20
...5. Engine oil fill 9. Windshield washer fluid reservoir
20
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Secondary cooling system coolant reservoir 11. Air filter restriction gauge 13. Batteries 6. Power steering fluid reservoir... COMPARTMENT F-Super Duty
13
5
1
2
3
4
12
11
10
9
8
7
6
5
1. Engine-mounted fuel filter assembly 10. Air filter assembly 12.
Diesel Supplement 3rd Printing - Page 23
...fuel or any diesel fuel not intended for highway use of biodiesel. Damage to the fuel injection system, engine and exhaust catalyst can also cause fuel filter restrictions that has been converted from renewable fuel... fuel. This practice creates a serious fire hazard and engine performance problems. 23
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) For example, B20 indicates a fuel ...
Diesel Supplement 3rd Printing - Page 25
...fuel dispensing nozzle fill rate This truck is able to accept fuel up to -repair damage. then use a slower rate of diesel fuel. Diesel fuel must not be deposited in the fuel). Carefully turn on/off . Pumping fuel at least once. 25
2012...start, prime the system by turning the key to enter the fuel system (during fuel filter change or if you run through the engine where it will...
Diesel Supplement 3rd Printing - Page 26
... (SCR) System Your vehicle is equipped with a fuel filler cap that is not used. Importance of your vehicle. Running a system check in this section. 26
2012 Diesel (67l) Supplement, 3rd Printing USA (fus...the DEF level In order for the SCR system to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is designed for your Owner's Guide for message ...
Diesel Supplement 3rd Printing - Page 38
... (12553 km) - 9300 miles (14967 km)
FUEL FILTER/WATER SEPARATOR Diesel Fuel Conditioner Module (DFCM) The vehicle is allowed to ...exceed this level, the water may be drained from the module assembly whenever the warning light comes on and the message center directs you to the engine and may cause fuel injection equipment damage. 38
2012...
Diesel Supplement 3rd Printing - Page 40
...or exceed Ford specifications. the tank level is equipped with a low fuel pressure detection...2012 Diesel (67l) Supplement, 3rd Printing USA (fus) If it disappears and does not re-appear after fueling, see below 32°F (0°C): If this chapter. This may be changed regardless of the maintenance schedule interval. • If replacement of the fuel filter does not remedy the low fuel...
Diesel Supplement 3rd Printing - Page 41
... later in this chapter. Replace the seal prior to reinstalling the filter/bowl to Motorcraft part numbers in this section. 2. Removal - To install the new DFCM filter, see Installation - This part number includes filters and seals for the fuel filter kit part number.
41
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Note: Depending on the...
Diesel Supplement 3rd Printing - Page 42
... purged of the housing by squeezing the connector tabs and pulling the lines straight off . Engine-mounted fuel filter The engine-mounted fuel filter is not tightened to completely bleed off . Note: The engine will drain.
42
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Reinstall the lower portion of air after DFCM and engine...
Diesel Supplement 3rd Printing - Page 43
... tightened to the mechanical stop.
43
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Do this a total of six times in place. 2. Reconnect both fuel lines. The system will need to be purged of the filter. After filter service, a no start or rough running engine may require the fuel filter to be replaced more than the...
Diesel Supplement 3rd Printing - Page 64
... checks: • a plugged or disconnected air inlet system or engine air filter element. • water in the fuel filter/water separator. • a clogged fuel filter. • contaminated fuel. • air in the Warranty Guide, are applicable to constitute tampering are experiencing, consult an authorized dealer. 64
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) If these checks...
Diesel Supplement 3rd Printing - Page 65
... during a fuel filter change), the engine will make restarting difficult. Repeat the procedure six times. If the engine won't crank WARNING: Battery posts, terminals and related accessories contain lead and lead compounds. If you fuel your diesel vehicle out of fuel as ether or gasoline in order for the starter to operate. 65
2012 Diesel...
Diesel Supplement 3rd Printing - Page 67
... circuit breaker with one of a circuit malfunction, resulting in severe engine damage.
67
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) MOTORCRAFTா PART NUMBERS Item Ford Part Number Engine oil filter FL-2051 Foam pre-filter FA-1907 * Air filter FA-1902 Fuel filter kit (2 included - Burned-out or blown fuses usually indicate an electrical short...
Diesel Supplement 3rd Printing - Page 74
... operating Refer to Special operating conditions later in conditions this chapter Normal schedule Maximum Fuel Filter Change Interval Normal schedule 22,500 miles (36,000 km) or as indicated by... conditions later in conditions this chapter Initial change Check Every Month Engine air filter restriction gauge Fuel filter/water separator; drain if necessary (or if indicated by the message center ...
Diesel Supplement 3rd Printing - Page 78
... coolant. and frame-mounted fuel filters. 3 (36000 km) Every 30000 miles Replace climate-controlled seat filter (if equipped). (48000 km) At 45000 miles Replace air inlet foam filter. 4 (72000 km) ...Replace again at 105000 miles (168000 km), then every 45000 miles (72000 km) thereafter. 78
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) At 90000 miles Inspect accessory drive belt(s)....
Owner Guide 4th Printing - Page 53
... more information. 53
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Displayed approximately two hours after fueling, see below. LOW FUEL PRESSURE (diesel engine only...your authorized dealer. FUEL FILTER CHANGE REQUIRED (diesel engine only) - The customer warranty may be void from using additives that do not meet or exceed Ford specifications. The engine...
Owner Guide 4th Printing - Page 440
... long periods of trailer towing with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Class... be waived if the axle is 3,000 mile (4,800 km). 440
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (... the axle has been submerged in water California fuel filter replacement: If the vehicle is registered in the Middle East...
Similar Questions
When Is The Fuel Filter Recommended On A 2012 F550
(Posted by Captacouc 10 years ago)
Where Is The Fuel Filter On A 2012 Ford F550 With A V-10
(Posted by pravda 10 years ago)
