2012 Ford F450 Cab Support Question
2012 Ford F450 Cab Support Question
Find answers below for this question about 2012 Ford F450 Cab.Need a 2012 Ford F450 Cab manual? We have 2 online manuals for this item!
Question posted by epigogma on July 28th, 2014
How To Bleed Air Out Of Fuel System On A 2012 F450
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
... Introduction
The glow plug system is electronically controlled by the GPCM using accelerator pedal.
5
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The GPCM energizes the glow plugs ... change intervals. Failure to cool the transmission, exhaust gas recirculation (EGR), charge air and fuel. Engine and secondary cooling system The cooling system contains an engine cooling loop to...
Diesel Supplement 3rd Printing - Page 7
... the fuel system if the DFCM is drained while the system is running or the vehicle is moving. If the light illuminates when the engine is running . See Diesel exhaust fluid in the Maintenance and Specifications chapter for the drain procedure. Refer to , or failure of manifold air pressure in the engine.
7
2012...
Diesel Supplement 3rd Printing - Page 8
... Engine oil specifications in the Maintenance and Specifications chapter for a short time.
8
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The fan drive is recommended to allow the... changing vehicle cooling air flow requirements. Do not press the accelerator during starting the engine in engine lubrication warm-up. Fan speed, fan noise level and fuel consumption all starting ...
Diesel Supplement 3rd Printing - Page 9
... for more than 10 seconds as ether, in the air intake system (see air filter decal). When the glow plug pre-heat indicator turns...as the engine starts. Such fluid could cause immediate explosive damage to diesel fuel. Do not start the turns off , turn the key to 3 ...pressure gauge indicates normal pressure. 9
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) After the engine starts, ...
Diesel Supplement 3rd Printing - Page 11
... OPERATION Changing to the DEF tank. Refer to Engine oil specifications in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) For best results in .... Your vehicle is recommended that the fuel level in P (Park). This will not restart, the fuel filter(s) may need to use alcohol based additives to help prevent air from inside the air filter assembly. For proper cold weather ...
Diesel Supplement 3rd Printing - Page 20
... cooling system) 7. Windshield washer fluid reservoir
20
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Brake fluid reservoir 4. Air filter restriction gauge 13. Maintenance and Specifications
IDENTIFYING ... cooling system coolant reservoir 11. Engine oil fill 9. Engine-mounted fuel filter assembly 10. Air filter assembly 12. Automatic transmission dipstick 3.
Diesel Supplement 3rd Printing - Page 25
... once. 25
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Repeat this several times. This is normal and should correct itself in a galvanized container. Maintenance and Specifications
Fueling tips Truck stops have pumps and nozzles designed for 30 seconds then to remove the cap from the fuel filler pipe. 4. If air is able to...
Diesel Supplement 3rd Printing - Page 35
...overfill the tank which allows the DEF system to a normal fuel fill. If the message center indicates EXHAUST FLUID LEVEL OK...not continue to fill the tank as required by the California Air Resources Board (CARB) and /or U.S. To refill your vehicle... the SCR system repaired will appear in the message center. 35
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Environmental Protection ...
Diesel Supplement 3rd Printing - Page 39
... not be sure that the drain valve is fully tightened. 5. Note: A loose drain valve can allow air to illuminate, have the fuel system checked and repaired.
39
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Note: Air will not operate properly if air enters the system. 2. Restart the engine. If they continues to enter the...
Diesel Supplement 3rd Printing - Page 42
... soak into the fuel filter element. See Purging air from the fuel system after removal/changing of the housing by squeezing the connector tabs and pulling the lines straight off .
To remove it is not tightened to completely bleed off . Engine-mounted fuel filter The engine-mounted fuel filter is not installed in the fuel system since...
Diesel Supplement 3rd Printing - Page 43
...3. Install the new filter into the filter bracket. Using a fuel which has more than average impurities may indicate that air is tight and the filter bowl has been tightened to be ...Pull the filter straight out from the fuel system after DFCM and engine-mounted fuel filter replacement following. The system will need to the mechanical stop.
43
2012 Diesel (67l) Supplement, 3rd Printing USA...
Diesel Supplement 3rd Printing - Page 53
... element needs to be changed.
53
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Maintenance and Specifications
AIR FILTER RESTRICTION GAUGE AND AIR FILTER REPLACEMENT Air filter restriction gauge: The restriction gauge, located on the upper housing of filter clogging by visual appearance alone. Engine performance and fuel economy are adversely affected when the maximum...
Diesel Supplement 3rd Printing - Page 59
... for operator commanded regeneration (OCR) may observe a light amount of fuel. • Make sure all fluids are used to introduce fresh air into the tailpipe to cool the exhaust gas as they are at... least 80%. Note: OCR will function normally. 59
2012 Diesel (67l) Supplement, 3rd Printing ...
Diesel Supplement 3rd Printing - Page 64
... services described in the Warranty Guide, are experiencing, consult an authorized dealer. 64
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The complexity of noise control...8226; a plugged or disconnected air inlet system or engine air filter element. • water in the fuel filter/water separator. • a clogged fuel filter. • contaminated fuel. • air in use, or (2) ...
Diesel Supplement 3rd Printing - Page 65
... in the diesel air intake system. this may shut off . If the lights are dim, do not go out, the battery connections may be discharged. If there is due to operate. 65
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Such fluids can cause immediate explosive damage to fuel at the starter connection...
Diesel Supplement 3rd Printing - Page 66
...to off and then back to overheat: • Lack of fuel. If the gauge shows that the tank control switch is fuel in the tank, the trouble may make the switch temporarily ... heavy trailers during hot weather. • Grill or radiator air blockage. • Slipping or missing drive belt. • Plugged or very dirty air filter.
66
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) You...
Diesel Supplement 3rd Printing - Page 67
...limit and Idle-only modes If the vehicle's speed is limited or in severe engine damage.
67
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Refer to fire. MOTORCRAFTா PART NUMBERS...oil filter FL-2051 Foam pre-filter FA-1907 * Air filter FA-1902 Fuel filter kit (2 included - Failure to use the authorized Motorcraft air filter or an equivalent replacement part. Check the DEF....
Diesel Supplement 3rd Printing - Page 74
... later in the tail pipe to make sure they are functional and clear of debris
74
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Scheduled Maintenance Guide
Maximum Oil Change Interval...km]) Special operating Refer to Special operating conditions later in conditions this chapter Normal schedule Maximum Fuel Filter Change Interval Normal schedule 22,500 miles (36,000 km) or as indicated by...
Diesel Supplement 3rd Printing - Page 78
... and filter. and frame-mounted fuel filters. 3 (36000 km) Every 30000 miles Replace climate-controlled seat filter (if equipped). (48000 km) At 45000 miles Replace air inlet foam filter. 4 (72000... Replace again at 105000 miles (168000 km), then every 45000 miles (72000 km) thereafter. 78
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Change transfer case fluid (4WD vehicles). Refer...
Diesel Supplement 3rd Printing - Page 86
...fuel filters
Every 7,500 miles (12,000 km)
Every 7,500 miles (12,000 km) or 300 engine hours Every 15,000 miles (24,000 km), 6 months, 600 engine hours or as indicated by message center Every 30,000 miles (48,000 km)
Replace air...tip and the holes under the shield just inboard of the Owner's Guide.
86
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) As required Off-road Operation Inspect...
Similar Questions
