2012 Ford F350 Super Duty Support Question
2012 Ford F350 Super Duty Support Question
Find answers below for this question about 2012 Ford F350 Super Duty.Need a 2012 Ford F350 Super Duty manual? We have 2 online manuals for this item!
Question posted by stanbbeols on February 6th, 2014
How To Reset Exhaust Fluid Warning
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
...control (if equipped) If vehicle speed goes outside a predetermined range from the exhaust of diesel exhaust fluid (DEF) which must be energized decreases as determined by the PCM and GPCM....insufficient coolant and/or coolant additive can cause severe engine damage. Vehicle speed will not reset vehicle speed. Introduction
The glow plug system is electronically controlled by the GPCM using ...
Diesel Supplement 3rd Printing - Page 7
... operate properly if air enters the system. The engine will illuminate if the exhaust fluid is running , stop the vehicle as soon as safely possible, shut off the engine, then drain...(fus) Note: Air will illuminate when the DFCM has a significant quantity of , the fuel injection system. WARNING: Do not drain the DFCM while the engine is running or the vehicle is running . If the light ...
Diesel Supplement 3rd Printing - Page 9
... may remain on without turning the key to low or contaminated diesel exhaust fluid (DEF). Do not crank the engine for about 15 seconds. This... If the engine is recommended that the engine block heater be reset by turning the key to Engine block heater (if equipped) ... to start, turn the key to idle for more information. WARNING: Do not add gasoline, gasohol or alcohol to the engine and...
Diesel Supplement 3rd Printing - Page 11
... the ambient conditions. As the engine warms-up, the engine sound level will not restart, the fuel filter(s) may form wax crystals which uses diesel exhaust fluid (DEF) to the fuel injectors/system. Remove the air cleaner cover and the pleated paper filter, leaving the foam filter in damage to operate properly...
Diesel Supplement 3rd Printing - Page 17
Roadside Emergencies
JUMP STARTING YOUR VEHICLE The 6.7 diesel engine can also enter into an idle-only mode. RUNNING OUT OF DEF (DIESEL EXHAUST FLUID) If your vehicle runs out of jump starting procedure and refer to your Owner's Guide for more information.
17
2012 Diesel (67l) Supplement, 3rd Printing ...
Diesel Supplement 3rd Printing - Page 26
... your Owner's Guide for any damage to be refilled. The system automatically injects diesel exhaust fluid (DEF) into the exhaust system to disengage in a collision, which may be displayed in possible personal injury. The... the Instrument Cluster chapter of the diesel engine. WARNING: The fuel system may damage the fuel system or cause the fuel cap to enable proper SCR...
Diesel Supplement 3rd Printing - Page 27
... the Message center section in the Instrument Cluster chapter of miles (kilometers) to empty, speed will be speed limited to 5 mph. Maintenance and Specifications
DEF warning messages and vehicle operations WARNING: Diesel Exhaust Fluid (DEF) must be refilled when low or replaced when contaminated or the vehicle speed will be limited upon vehicle restart.
Diesel Supplement 3rd Printing - Page 29
...This occurs 200 Miles Engine Idled Soon Exhaust (322 km) after the vehicle Refill exhaust fluid - Fluid Empty reaches the 0 mile (0 km) exhaust fluid range
Maintenance and Specifications
29 2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Low DEF Warnings and Actions - exhaust (80 km/h) Upon Restart Refill exhaust fluid None fluid tank is empty Exhaust Fluid Empty Speed Limited To 50 MPH...
Diesel Supplement 3rd Printing - Page 30
...shown, base message center messages similar) Customer Distance/Exhaust Fluid Cluster Message Requested Vehicle Actions Level or Action Actions This occurs when the exhaust fluid is empty and: • The vehicle's ...Engine Idled-See Owner's • the engine is shut off for Refill exhaust fluid to idle ONLY Manual Exhaust Fluid Empty 10 minutes or, • the engine is idling with the parking ...
Diesel Supplement 3rd Printing - Page 35
.../or U.S. If the SCR becomes contaminated or inoperative, the DEF light will illuminate and exhaust fluid system fault messages will appear in cold climates DEF will be damaged, therefore DO NOT ...as this occurring a message will result in the nozzle. If the message center indicates EXHAUST FLUID LEVEL OK, do not add DEF. Continued driving without replacing DEF or having the SCR...
Diesel Supplement 3rd Printing - Page 37
...
Steady highway driving 7300 miles (11748 km) - 8900 miles (14323 km)
37
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Maintenance and Specifications
Typical Diesel Exhaust Fluid (DEF) Usage The charts below illustrate approximate DEF usage for the given distances traveled under various driving conditions and when using the PTO. Your usage...
Diesel Supplement 3rd Printing - Page 59
...) away from any obstructions as it is a minimum of 1/8 tank of fuel. • Make sure all fluids are used to introduce fresh air into the tailpipe to 2,000 or 2,400 rpm (depending on stable, level ...8226; and must not be burned. Maintenance and Specifications
OCR precautions and safe exhaust position WARNING: Failure to operate if the service engine soon is illuminated light Note: ...
Diesel Supplement 3rd Printing - Page 63
... emissions control systems (including related sensors and the diesel exhaust fluid (DEF) injection system) can stay hot even after only a short period of debris or foreign material may result in reduced . Maintenance and Specifications
WARNING: Failure to repair any vehicle modification without determining applicable law. WARNING: Do not remove or alter the original equipment...
Diesel Supplement 3rd Printing - Page 67
...to the Owner's Guide for a circuit check. Maintenance and Specifications
If fuses burn out WARNING: Replacement fuses and circuit breakers must always be limiting the vehicle's functions due to use ...Air filter FA-1902 Fuel filter kit (2 included - Failure to low or contaminated diesel exhaust fluid (DEF). Selective catalytic reduction (SCR) system speed limit and Idle-only modes If the...
Diesel Supplement 3rd Printing - Page 68
...)* Engine coolant additive 48.0 oz. (1.4L) per addition if (secondary cooling system) required Motorcraft Specialty Orange Engine Coolant Revitalizer VC-12 / - Pick-up Diesel Exhaust Fluid (DEF) - 68 MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES Item Motorcraft Specialty Orange Engine Coolant Capacity Ford part name Ford part number / Ford specification or specification...
Diesel Supplement 3rd Printing - Page 77
... each engine oil and filter change Change engine oil and filter. 2 interval as indicated Refill diesel exhaust fluid tank. Inspect brake pads, shoes, rotors, drums, brake linings, hoses and parking brake. Inspect automatic transmission fluid level. Inspect exhaust system and heat shields. Inspect steering linkage, ball joints, suspension, tie-rod ends, driveshaft and U-joints...
Diesel Supplement 3rd Printing - Page 93
... capacities ...68 Coolant additive ...68 Coolant change ...47, 52, 68 Cooler ...5 D Diesel exhaust fluid (DEF) ...17, 26 Diesel Particulate Filter (DPF) ...57-58, 62 Drivebelt ...70 ... ...44 filter, specifications ...67 refill capacities ...68 specifications ...44, 68 Exhaust brake ...14 Exhaust filter ...57-58 Exhaust Fluid ...26 Exhaust system ...26, 57, 62 F Fan, Engine Cooling ...8 Filter fuel ...
Owner Guide 4th Printing - Page 20
...8226; Water in fuel
• Diesel exhaust fluid
Key-in-ignition warning chime: Sounds when the key is left or right turn signal or the hazard lights are on . Headlamps on warning chime: Sounds when the headlamps or ... equipped with a diesel engine, it has some unique warning lights; Turns off . • Engaged (green light): Illuminates when the speed control system is disengaged. Diesel...
Owner Guide 4th Printing - Page 25
... and will begin to the recommended maintenance schedule. EXHAUST FLUID LEVEL (Diesel only) 3. OIL LIFE This displays the remaining oil life. OIL LIFE 2. FUEL LEVEL 10. Press and release the SETUP button to English. RESET FOR SYSTEM CHECK When this message appears, press the RESET button and the message center will not appear. An...
Owner Guide 4th Printing - Page 47
...Hours Engine Idle Hours Doors Exhaust Fluid Level (diesel only) Brakes Trailer Brake Gain and Output (when trailer is displayed, pressing OK will display the number of warnings that need immediate attention in... empty) * If equipped-your vehicle may be equipped with some or all of informational warnings will only display during a system check if a problem has been detected. Information is ...
Similar Questions
How To Reset Exhaust Fluid Warning On F350
(Posted by grecrichar 10 years ago)
How To Reset Exhaust Fluid Warning On F-350
(Posted by 2ndbobcjoh 10 years ago)
How To Reset Exhaust Fluid Warning On 2012 F250
(Posted by tamow 10 years ago)