2012 Ford F350 Super Duty Support Question
2012 Ford F350 Super Duty Support Question
Find answers below for this question about 2012 Ford F350 Super Duty.Need a 2012 Ford F350 Super Duty manual? We have 2 online manuals for this item!
Question posted by jimOverH on January 20th, 2014
How Often Do You Check The Secondary Cooling System Reservoir On A 2012 Ford F
450
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
... an engine cooling loop to cool the engine and a secondary cooling loop to "wear out" in the vehicle entering an idle-only mode. These two factors may cause the additives in the Maintenance and Specifications chapter for more information. Refer to provide heat transfer, freeze point protection, and corrosion protection using accelerator pedal.
5
2012 Diesel...
Diesel Supplement 3rd Printing - Page 16
... system for leaks.
16
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Turn the ignition on the reset button. 4. Make another check for leaks. 3. After an accident, if the engine cranks but does not start, this switch may have been activated. To reset the switch: 1. Wait a few ...
Diesel Supplement 3rd Printing - Page 20
... 4. Power distribution box 5. Engine cooling system coolant reservoir (primary hightemperature cooling system) 7. Windshield washer fluid reservoir
20
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)...Automatic transmission dipstick 3. Air filter assembly 12. Batteries 6. Air filter restriction gauge 13. Power steering fluid reservoir
8. Secondary cooling system coolant reservoir 11.
Diesel Supplement 3rd Printing - Page 39
... MANUAL message and light should not be sure that the drain valve is visible. Rotate the drain clockwise to illuminate, have the fuel system checked and repaired.
39
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Fuel may be stopped with the engine off the engine. Note: Air will not operate properly...
Diesel Supplement 3rd Printing - Page 47
...: Do not add coolant when the engine is hot. Maintenance and Specifications
ENGINE AND SECONDARY COOLING SYSTEM COOLANT Checking engine coolant Note: For best results, coolant concentration should be tested with a refractometer such as listed on the engine coolant reservoirs. Ford does not recommend the use engine coolant/antifreeze or windshield washer fluid outside of...
Diesel Supplement 3rd Printing - Page 48
... system. The secondary cooling system operates close to ambient temperature, and is loosened slightly. These can be drained, chemically cleaned, and refilled with alcohol or methanol antifreeze (coolant). The cooling system(s) are under your vehicle's warranty.
DO NOT use prediluted engine coolant that meets Ford specifications. Only use this instance, the cooling system must be...
Diesel Supplement 3rd Printing - Page 49
...on the engine coolant reservoir. Cap must be checked the next few times you removed the radiator cap in engine overheating and possible engine damage.
49
2012 Diesel (67l) ...coolant reservoir should be tightly installed to the FULL COLD level. For all makes and models may not meet the Ford specification and may have your authorized dealer check the engine cooling system....
Diesel Supplement 3rd Printing - Page 50
... coolant is within the COLD FILL RANGE as listed on the reservoir. 6. Shut engine off, and remove the pressure relief cap as listed on the reservoir. 10. Secondary cooling system: Repeat Step 5 until the coolant level is flowing through the entire system). 11. Check the coolant level in the chapter for 2 minutes. 8. When the engine...
Diesel Supplement 3rd Printing - Page 51
...point protection. Recycled engine coolant Ford Motor Company does not recommend the...freeze point protection) and corrosion inhibitor 51
2012 Diesel (67l) Supplement, 3rd Printing USA...cooling system can hold, refer to Maintenance product specifications and capacities in this time. Maintenance and Specifications
Whenever coolant has been added, the coolant level in the reservoir should be checked...
Diesel Supplement 3rd Printing - Page 52
...COOLING SYSTEM corrosion inhibitor additive strength is low, add 16 fluid oz. The coolant can be recharged with this additive up to Maintenance product specifications and capacities in this chapter for maximum engine performance and protection. If additional dosages are available for the proper coolant. 52
2012...too low. If the SECONDARY COOLING SYSTEM corrosion inhibitor additive ...
Diesel Supplement 3rd Printing - Page 68
... Specialty Orange Engine Coolant Capacity Ford part name Ford part number / Ford specification or specification VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS-M97B44-D2
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Engine coolant (primary high- Pick-up Diesel Exhaust Fluid (DEF) - Engine coolant 11.7 quarts (11.1L) (secondary cooling system*) Motorcraft Specialty Orange...
Diesel Supplement 3rd Printing - Page 75
... any problems. Ford Motor Company suggests...check air pressure, warning system operation including spare Fluid levels*; fill if necessary Windshield for cracks, chips and pitting For oil and fluid leaks Windshield washer spray and wiper operation *Brake, engine coolant reservoir, secondary low-temperature cooling system reservoir, automatic transmission, power steering and window washer 75
2012...
Diesel Supplement 3rd Printing - Page 78
...again at 105000 miles (168000 km), then every 45000 miles (72000 km) thereafter. 78
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Replace accessory drive belt(s) if not...Scheduled Maintenance Guide
Additional Maintenance Items 1 Every 15000 miles Inspect engine and secondary cooling system (24000 km) concentration (freeze-point protection), additive strength (corrosion inhibitor), coolant ...
Owner Guide 4th Printing - Page 18
...reservoir cap while the engine is not completely closed. When the ignition is working.
Refer to the Driving chapter for three seconds to the transmission could occur.
18
2012 F-250/350/450...vehicle as soon as possible, switch off the engine and let cool. If the light remains on , the light will illuminate ...checked. Transmission Tow/Haul Feature (if equipped): Displays when the ...
Owner Guide 4th Printing - Page 21
... and C). 21
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Stop the vehicle as soon as safely possible, switch off the engine and check the engine oil ...turn off the engine and let the engine cool. At normal operating temperature, the needle will be in the: Normal area The transmission fluid is correct, have your vehicle checked at your authorized dealer. 2. Metric similar...
Owner Guide 4th Printing - Page 380
...vehicle's warranty. 380
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) steam and hot liquid can burn you spill coolant on the engine coolant reservoir (depending upon the ... you badly. do not use stop leak pellets, cooling system sealants, or unapproved additives as Rotunda tool ROB75240 available from a hot cooling system can come out forcefully when the cap is ...
Owner Guide 4th Printing - Page 381
...a pressure relief cap on the coolant recovery reservoir when the engine is cool, wrap a thick cloth around the coolant... Slowly turn it counterclockwise and remove the cap. 381
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus...meets the Ford specification. Mixing of an improper coolant may harm engine and cooling system components and may not meet the Ford specification. Generic...
Owner Guide 4th Printing - Page 382
... reservoir. When you add coolant, check the coolant concentration. If you drive the vehicle, check the coolant level in engine overheating and possible engine damage. 382
2012 F-250/350/450/...proper level. Slowly turn it cool. 2. When the engine is cool, wrap a thick cloth around the coolant pressure relief cap on the engine coolant reservoir (depending upon application). 8. ...
Owner Guide 4th Printing - Page 383
... your engine coolant reservoir as outlined previously in the Adding engine coolant section. Fill your vehicle's cooling system can hold,...Ford-approved recycling process is equipped with a diesel engine, refer to the Maintenance product specifications and capacities section of your community's regulations and standards for optimum cooling system and engine protection.
383
2012 F-250/350/450...
Owner Guide 4th Printing - Page 413
... MERCON LV ATF XT-10-QLV / MERCON LV Automatic transmission fluid (6-speed)3 2.0 quarts (1.9L) Keep fluid level between MIN and MAX on reservoir
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus)
Capacity Ford part name Ford part number / Ford specification
Maintenance and Specifications
413
Similar Questions
Where Are The Cooling Reservoir On A 6.7 Diesel
(Posted by waltebi 9 years ago)
What Is The Secondary Cooling System On Ford Diesel For
(Posted by AdalrTJ 10 years ago)
2012 F-450 Lights
parking,mirror and cab lights won't turn off on a 2012 F-450?
parking,mirror and cab lights won't turn off on a 2012 F-450?
(Posted by plumbundy 10 years ago)
Why Is 2012 Ford F350 Diesel Coolant Reservoir Empty Cold
(Posted by dieggoog 10 years ago)