Home » Ford » Troubleshooting » 2004 Ford F250

2004 Ford F250 Support Question

Find answers below for this question about 2004 Ford F250.
Need a 2004 Ford F250 manual? We have 10 online manuals for this item!

Ford Overview Questions Manuals Reviews Videos Research

Question posted by esilRAHOT on February 9th, 2014

Where To Drain Water Separator 04 F250

The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.

I Know the Answer!

I have the same question
Request More Information

Current Answers

There are currently no answers that have been posted for this question.
Be the first to post an answer!

Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.

Related Manual Pages

Diesel Maintenance Tips Customer Letter 1st Printing - Page 1

...optimum cold weather starting ability, and reduce engine wear. ¾ ¾ The water separator should be drained monthly (at the mileage or equivalent hour intervals specified by the maintenance schedule. ...coolant system nitrite strength should be checked and serviced at least) or when the "Water in the coolant reservoir. Ford Power Stroke® Diesel Operating, Maintenance & Care ...

Scheduled Maintenance Guide 5th Printing - Page 21

... Inspect engine cooling system and hoses. Inspect and lubricate 4X4 front axle shaft u-joints (F250/350/450/550 and Excursion). Rotation recommended for wear. Multi-point inspection (recommended) DEALER...: P&A CODE: MILEAGE: 75,000 miles Change engine oil and replace oil filter. Drain coalescent fuel filter bowl and replace filter (natural gas only). Inspect tires for wear....

Scheduled Maintenance Guide 5th Printing - Page 24

... Gross Vehicle Weight (except 5.4L 3V engines). Replace cabin air filter, if equipped. Inspect and lubricate 4X4 front axle shaft u-joints (F250/350/450/550 and Excursion). Rotation recommended for wear. Drain coalescent fuel filter bowl and replace filter (natural gas only). Multi-point inspection (recommended) DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE...

Scheduled Maintenance Guide 5th Printing - Page 27

.... Inspect steering linkage, ball joints, suspension and, if equipped, half shafts, driveshaft and u-joints. Inspect and lubricate 4X4 front axle shaft u-joints (F250/350/450/550 and Excursion). Drain coalescent fuel filter bowl and replace filter (natural gas only). Inspect engine cooling system and hoses. Lubricate 4X2 ball joints and steering linkage...

Scheduled Maintenance Guide 5th Printing - Page 29

... (see pages 44 and 46). Replace cabin air filter, if equipped. Inspect and lubricate 4X4 front axle shaft u-joints (F250/350/450/550 and Excursion). Inspect fuel tanks (natural gas and propane only). Drain coalescent fuel filter bowl (natural gas only). Change transfer case fluid (4X4 only). lines & hoses, and parking brake...

Diesel Supplement 2nd Printing - Page 3

... transmission case • an engine-mounted secondary fuel filter • a unit injector for each cylinder The FCM/HFCM acts as a primary fuel filter/water separator which removes both water and impurities from the fuel. To determine whether the vehicle is equipped with the Ford ambulance preparation package, inspect the information plate on the...

Diesel Supplement 2nd Printing - Page 4

...by the PCM. Extended oil change the engine oil at regular intervals or when the WATER IN FUEL light illuminates in maintaining the oil pressure required to be on according to ...protection in the Maintenance and Specifcations section of restricted flow. Introduction The FCM/HFCM should be drained at the recommended service intervals, because oil viscosity is placed in the ON position, then...

Diesel Supplement 2nd Printing - Page 7

... is running or the vehicle is turned to ON. Fuel may be pumped into your tank. Do not drain the water separator while the engine is necessary as safely possible, shut off the engine, then drain the FCM/HFCM. Instrumentation Glow plug pre-heat indicator With the key in the ON position, light will...

Diesel Supplement 2nd Printing - Page 13

... after the glow plug pre-heat indicator has turned off , turn the key to 5 (START), then release the key as soon as a fuel filter/heater/water separator to cool down. This will decrease due to clog the fuel filter. As the engine warms-up, the engine sound level will help prevent fuel...

Diesel Supplement 2nd Printing - Page 35

...may run through the engine where it runs. E-SERIES)/HORIZONTAL FUEL CONDITIONING MODULE (HFCM - FUEL FILTER/WATER SEPARATOR HFCM - This is able to accept fuel up to -repair damage. F-SUPER DUTY/EXCURSION) -... itself in a galvanized container. Diesel fuel must not be using substandard fuel (i.e., high water content, low cetane rating or gasoline in 30 seconds, turn the key to enter the...

Diesel Supplement 2nd Printing - Page 36

... FUEL light will come on when approximately 100 cc (0.2 pints) of the engine. Fuel may ignite if the separator is drained while the engine is running or vehicle is mounted on top of water accumulates in the module. On F-Super Duty and Excursion vehicles, the second filter, inside the frame rail under the...

Diesel Supplement 2nd Printing - Page 37

...WATER IN FUEL indicator light; it counterclockwise. Remove the fuel filter cap by turning it clockwise until it continues to drain for approximately 25 seconds or until clean fuel is observed. Remove the drain plug, using a 6mm hex drive, by turning it should not be illuminated. Install the drain...Excursion • E-Series 3. Verify that the drain plug is firmly seated. 4. Allow the ...

Diesel Supplement 2nd Printing - Page 42

...than most available "will-fit" filters. To replace the filter, 1. Note: The filter should be changed before reinstalling the oil pan drain plug. 2. Continuous contact with bare hands. For more information refer the General Owner's Information section of these conditions, observe the following ... or API categories CI-4, CI-4/SL or DHD-1. Protect your engine by washing with soap and water.

Diesel Supplement 2nd Printing - Page 45

... with alcohol or methanol antifreeze (coolant). In this instance, the cooling system must be drained and refilled with a pressurized cap, or if it is necessary to remove the coolant ... with your factory filled coolant can result in degraded corrosion protection. • A large amount of water without engine coolant) can cause engine damage from corrosion, overheating or freezing. • Do not...

Diesel Supplement 2nd Printing - Page 46

... visible and radiator is not yet available. It may take several drains and additions to Checking engine coolant. Recycled engine coolant Ford Motor ...liter (1.0 quart) of engine coolant and distilled water to bring the liquid level to Refill capacities in the coolant reservoir should be necessary to -34° F/-36° C), drain some coolant and adjust the concentration. Whenever coolant...

Diesel Supplement 2nd Printing - Page 48

...; wrong fuel or oil viscosity for climactic conditions. 48 The following checks: • a plugged air inlet system or engine air filter element. • water in the fuel filter/water separator. • a clogged fuel filter. • contaminated fuel. • air in the fuel system, due to the ultimate purchaser or while it so the...

Diesel Supplement 2nd Printing - Page 57

... • Check tires for wear and proper air pressure • Check engine oil fluid level • Check windshield washer solvent fluid level • Check and drain fuel filter/water separator Check every six months: • Check lap/shoulder belts and seat latches for labor, parts or lubricants used.

Owner Guide 3rd Printing - Page 4

...: www.ford.com.mx Additional owner information is an integral part of the vehicle. 4 2004 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus) Please take the... Ford. Furthermore, due to printing cycles it . In addition, certain fluids contained in separate publications. The more information on Ford Motor Company and its constituents, and certain vehicle components...

Owner Guide 3rd Printing - Page 246

...and distilled water as soon as Motorcraft Speciality Orange Engine Coolant, VC-2 (US) or CXC-209 (Canada), meeting Ford Specification WSS-M97B51-A1. In this instance, the cooling system must be drained and ...in case of the engine coolant. If sprayed on the radiator of coolant and water to add engine coolant. 246 2004 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus...

Owner Guide 3rd Printing - Page 247

... risk of engine coolant and distilled water to bring the liquid level to... does NOT recommend the use the cloth to -34° F/-36° C), drain some coolant and adjust the concentration. The cooling system is cool, wrap a thick ... Fill the coolant reservoir slowly with a low level of automotive fluids. 247 2004 F250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA English (fus)...