Home » Ford » Technical Support » 2002 Ford F250

2002 Ford F250 Support Question

Find answers below for this question about 2002 Ford F250.
Need a 2002 Ford F250 manual? We have 5 online manuals for this item!

Ford Overview Questions Manuals Reviews Videos Research

Question posted by dapple9109 on January 28th, 2014

Will Not Start.

I think it is with the fuel system. Replaced fuel pump relay worked for 1 month. Was running yesterday but did not start. It started this morning but when I got home today it would not start again. New relay don't know what is going on. Turns over fine but will not start.

I Know the Answer!

I have the same question
Request More Information

Current Answers

Answer #1: Posted by TexasDeviL on January 28th, 2014 4:14 PM

This answer was accepted by the poster of the original question.

TexasDeviL

Member since:
December 27th, 2012

Points: 960,825

1,100
points

That relay is connected thru a fusable link. You may want to check that and see if its intact.

If you agree that the answer I provided is correct please remember to "accept" and/or mark it as "helpful" so I know I'm doing a good job. Thank you, I would really appreciate it.

[automotive mechanic and phone modding enthusiast]

Related Manual Pages

Warranty Guide 5th Printing - Page 11

..., oil pan and pump, water pump, fuel system (excluding fuel lines and fuel tank), high pressure ...months or 12,000 miles, whichever occurs first. 7.3L PowerStrokeா Diesel Engine Coverage The New... Vehicle Limited Warranty covers certain direct injection diesel engine components against defects in factory-supplied materials or workmanship for each repair visit. after the warranty start...

Warranty Guide 5th Printing - Page 12

.../Wear Your New Vehicle Limited Warranty does not cover: (1) parts and labor needed to maintain your vehicle. and (2) the replacement of time ...starting systems, and performance-enhancing powertrain chips • tampering with the vehicle, tampering with the emissions systems, or with the result that the actual mileage cannot be determined • using contaminated or improper fuel...

Warranty Guide 5th Printing - Page 17

...• Air/Fuel Feedback Control System and Sensors • Air Induction System • Altitude Compensation System • Catalytic Converter • Cold Start Enrichment System • Cold Start Fuel Injector (1) &#...all these conditions: • You have maintained and operated your vehicle will repair, replace, or adjust - with , misused, or abused. any emissions control device or ...

7.3L Diesel Supplement 2nd Printing - Page 4

... in engine performance while it's engaged. Pressurized oil from the fuel tank by the fuel pump PCM relay. The fuel pump contains a pressure relief valve for overpressure protection in the event of : • a frame-mounted electric fuel supply pump • an engine mounted fuel filter/water separator • a fuel restriction sensor • a unit injector for more information. Extended...

7.3L Diesel Supplement 2nd Printing - Page 5

..., refer to limit maximum engine speed. Do not exceed 3,600 rpm. The PCM controls fuel input to the "Transmission shift speed" chart in the ON position, then determines how long... and barometric pressure increase. Diesel information Fast start glow plug system The glow plug system consists of: • eight glow plugs • the glow plug relay • engine oil temperature (EOT) sensor...

7.3L Diesel Supplement 2nd Printing - Page 8

... drain the water separator while the engine is running or the vehicle is moving. 8 Allowing water to stay in the system could result in it is possible for drain procedure. Your vehicle fuel system is turned to be IN pumped into your tank. The WATER IN FUEL light will illuminate when the ignition is equipped...

7.3L Diesel Supplement 2nd Printing - Page 9

... vehicle is equipped with a manual transmission, make sure the parking brake is in order to diesel fuel. Make sure all starting instructions carefully before you start , turn the key to START. (For Canadian vehicles, the daytime START running lamps will continue to be activated for more information on if the parking brake is not applied and the...

7.3L Diesel Supplement 2nd Printing - Page 17

... damage. 17 The zinc will then remain in solution until it is run rough and produce white smoke while air is stored. The engine may run through the engine where it runs. Use only clean, approved containers which sells a large amount of fuel) the engine will be purchased from a reputable station which will dissolve...

7.3L Diesel Supplement 2nd Printing - Page 34

... may be in excess of fuel. If a discharged battery is securely fastened to ON again. 34 Also, make starting may also indicate a loose or corroded battery connection. If the starter relay clicks, but the starter does not crank, check the connections at the starter relay terminals. Reset the system by turning the ignition key to...

Owner Guide 5th Printing - Page 2

...Cleaning Maintenance and Specifications Engine compartment Engine oil Battery Fuel information Air filter(s) Part numbers Refill capacities Lubricant ...Motor Company. Table of Contents Driving Starting Brakes Transmission operation Trailer towing 101 101 105 109 130 Roadside Emergencies Getting roadside assistance Fuses and relays Changing tires Jump starting Wrecker towing 158 158 160 165...

Owner Guide 5th Printing - Page 3

...acquainted with your vehicle the greater the safety and pleasure you know and understand about your vehicle by reading this handbook. Fuel pump shut-off switch In the event of an accident the safety... switch will derive from driving it may not apply to your new Ford. To reset the switch...

Owner Guide 5th Printing - Page 8

... Child Seat Lower Anchor Brake System Brake Fluid Non-Petroleum Based AdvanceTrac Traction Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 8 Introduction These are some of the symbols you may see on your vehicle...

Owner Guide 5th Printing - Page 54

...(this control to the nearest liter (gallon) To reset the average fuel economy: 1. If you calculate your average fuel economy by dividing liters of fuel used by 100 kilometers traveled (miles traveled by gallons used), your figure...during fill-up • differences in the automatic shut-off points on the fuel pumps at service stations • variations in the ON position. Mode control Each press...

Owner Guide 5th Printing - Page 159

...-3673; If you may purchase extended coverage prior to turn them off . Canadian customers who require roadside assistance,...run down your Basic Warranty's Roadside Assistance expiring. After an accident, if the engine cranks but does not start...been activated. 159 FUEL PUMP SHUT-OFF SWITCH FUEL RESET This device stops the electric fuel pump from sending fuel to obtain reimbursement ...

Owner Guide 5th Printing - Page 160

... no leaks are not working, a fuse may have blown. Make another check of leaks. Turn the ignition OFF. 2. Turn the ignition ON. 5. Check the appropriate fuses before replacing any electrical components. 15 Note: Always replace a fuse with a higher amperage rating can cause severe wire damage and could start a fire. 160 FUSES AND RELAYS Fuses If electrical components...

Owner Guide 5th Printing - Page 164

Roadside Emergencies Fuse/Relay Location 39 40 41 42 43 44 45 46 47 48 101 102 103 ... 30A** 30A** 20A** 30A** 30A CB*** 60A** - - Passenger Compartment Fuse Panel Description Not used Fuel pump Instrument cluster Delayed accessory Fog lamps Not used Ignition switch Run/Start feed Left-hand lowbeam Right-hand lowbeam Not used Trailer tow electric brake Door locks/Body security module Ignition ...

Owner Guide 5th Printing - Page 196

...Working with the engine running in an enclosed space, unless you are sure you service your vehicle: • We highlight do-it-yourself items in moving parts. • Do not work...Do not work on a vehicle with the engine off the engine and remove the key. 3. Block the wheels. • Manual transmission: 1. Turn off • Automatic transmission: 1. Use only recommended fuels, lubricants...

Owner Guide 5th Printing - Page 212

... inhaling excess fumes. Turn off . 2. If you start the engine, the fuel filler cap may 212 Fuel vapor is in the vehicle (including the cargo area). • Keep the fuel pump nozzle in the fill position. Care should be properly installed. Carefully turn the filler cap counterclockwise 1/8 of a turn on after you must replace the fuel filler cap, replace it stops...

Owner Guide 5th Printing - Page 218

... other emission control components continue to work properly: • Use only the specified fuel listed. • Avoid running out of fuel. • Do not turn off the ignition while your dealer if...and a catalytic converter which can start a fire. Do not park, idle, or drive your vehicle in the scheduled maintenance guide are used for maintenance replacements or for high speed driving....

Owner Guide 5th Printing - Page 257

...fuel ...213 comparisons with EPA fuel economy estimates ...218 detergent in fuel ...214 filling your vehicle with fuel ...210, 212, 215 filter, specifications ...214, 234 fuel pump shut-off switch ...159 improving fuel economy ...215 octane rating ...213, 240-241 quality ...213 running out of fuel... daytime running lights ...37 flash to pass ...38 high beam ...37 replacing bulbs ...40 turning on and...