E-Z-GO RXV - Electric Support Question
E-Z-GO RXV - Electric Support Question
Find answers below for this question about E-Z-GO RXV - Electric.Need a E-Z-GO RXV - Electric manual? We have 1 online manual for this item!
Question posted by bdponzio on April 26th, 2015
What Do I Do When Charger Not Working And Gives 2 Red Blinks Pause Then Repeat
The person who posted this question about this E-Z-GO product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by BusterDoogen on April 26th, 2015 7:14 AM
BusterDoogen
Member since:
October 30th, 2011 Points: 28,565,397
Member since:
October 30th, 2011 Points: 28,565,397
TWO RED FLASHES: Two flashes, a pause and
then again two flashes and a pause - Battery Voltage
Fault: Battery pack is less than 36.0 Volts or
more than 67.2 Volts. Battery pack is too discharged
or over charged for the charger to work. Use a voltmeter to check the voltage output. If it well below 36v the battery needs replacing.
I hope this is helpful to you!
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful. Please feel free to submit further info for your question, if a solution was not provided. I appreciate the opportunity to serve you!
Related E-Z-GO RXV - Electric Manual Pages
Owner Manual - Page 3
OWNER'S GUIDE
ELECTRIC POWERED FLEET & PERSONAL GOLF CARS
RXV GOLF CAR RXV FREEDOM™ RXV SHUTTLE 2 + 2
STARTING MID-MODEL YEAR 2009 (MANUFACTURED BEGINNING FEBRUARY 23, 2009)
E-Z-GO Division of the information and materials in this Manual.
The E-Z-GO Division DISCLAIMS ...
Owner Manual - Page 4
...of non Original Equipment Manufacturer (OEM) approved parts may void the warranty. As with all electric vehicles, set to 'OFF'. Overfilling batteries may void the warranty. For winter storage, the ...batteries must be clean, fully charged and disconnected from any source of electrical drain.
Page ii
Owner's Guide
GENERAL INFORMATION
This vehicle has been designed and ...
Owner Manual - Page 5
... ...Inside Covers
GENERAL INFORMATION ii
SAFETY INFORMATION v
LABELS AND PICTOGRAMS ix
SERIAL NUMBER LOCATION 1
BEFORE INITIAL USE...1
PORTABLE CHARGER 2 PORTABLE CHARGER INSTALLATION 2 USING THE CHARGER 3 UNDERSTANDING THE CHARGER 3 LED OPERATION CODES 4 LED FAULT CODES 4 MAINTENANCE INSTRUCTIONS 4
CONTROLS AND INDICATORS 5 KEY SWITCH/DIRECTION SELECTOR 5 SPEEDOMETER/STATE OF...
Owner Manual - Page 9
... dedicated circuit for injury, refer the repair or maintenance to a qualified mechanic.
Chargers must
B have the skill and experience to recognize and protect themselves from potential situations...each battery charger. SAFETY INFORMATION
B
Read all of manual to become familiar with charger manufacturers recommendations or applicable electrical code (whichever is considered the ...
Owner Manual - Page 22
...15 AMP Circuit
Locations outside the US and Canada: Reference appropriate local electrical code and charger manufacturer recommendations for future brake performance tests. Determine and record the braking... by children. Prior to qualified personnel.
Study all repair work to vehicle or charger operation, the charger must be placed such that has been properly installed and grounded...
Owner Manual - Page 23
... remain plugged into the AC outlet when not in an electrical shock or electrocution, be removed to the instruction labels on the driver side of the way when finished with a grounded plug. UNDERSTANDING THE CHARGER
Plugging the charger into the vehicle's charger receptacle, the charger will automatically turn on the vehicle when driving away. Do...
Owner Manual - Page 24
... will repeat again. THREE RED FLASHES: Three flashes, a pause and then again three flashes and a pause -
...charger connections to work. If the AC voltage is less than 36.0 Volts or more than 80% charged
SOLID GREEN = 100% charged
RED FLASH = fault code
LED FAULT CODES:
RED FLASH: Light turns on automatically. Charge Enable Fault: poor contact in , the charger must be a pause...
Owner Manual - Page 27
... splash shield by aligning the mounting holes with the rivet head. then perform the following:
1. when the vehicle is stopped the parking brake is depressed. Repeat the process for releasing the parking brake. Owner's Guide
Page 7
To access the instructions remove three re-usable plastic rivets securing the controller splash shield...
Owner Manual - Page 29
... windshield does not provide protection from being operated or towed while the charger is released, the motor controls the deceleration. STARTING VEHICLE ON A HILL...objects nor does the windshield protect against flying objects and tree limbs. Owner's Guide
Page 9 Remove the charger plug from the elements; NOTICE
When the direction selector is in the reverse position, a warning signal will...
Owner Manual - Page 35
... a battery is in a battery explosion, turn off all electrical loads from improper servicing techniques:
DO NOT attempt any type ...for more frequently on the vehicle. Wear eye protection when working around batteries, or using solvents or compressed air.
Fasteners...to be replaced after checking or inflating. This vehicle will give years of severe injury or death from the battery before...
Owner Manual - Page 37
Pay attention to all of pedal, stopping distance
Brakes - PERIODIC SERVICE SCHEDULE
B
- CHECK C&A - loose connections, broken or missing insultation
Charger Receptacle - clean connections
CL
CL
CL
CL
Steering Assembly - drain & replace fluid
R
Front Suspension - Add Anti - pressure, condition of contaminants to become familiar with this ...
Owner Manual - Page 38
...tests on the vehicle. BBATTERIES AND CHARGING SAFETY
NOTICE
Always observe the following warnings when working on or near batteries:
To prevent battery explosion that its design amperes from 'shorting ... device.
Hydrogen gas is absent or if the metals are turned off and all electrical accessories are not dissimilar, a battery has not been created. Contact a physician immediately...
Owner Manual - Page 39
...gas' with commercially avail-
The charging cycle will force it out of fire, never attach a battery charger to a vehicle that is to become familiar with this loss is complete. Water that results from the ...the concentration of acid within the electrolyte and reduce the life of the battery. The charger should be pure and free of contaminants that it can damage vehicle components and the...
Owner Manual - Page 43
... be stored fully charged, and disconnected from the battery case to keep them maintained and prevent discharge. BL+ Red Wire from Solenoid
Black Wire from Harness
Fig. 29 Battery Connections
PROLONGED STORAGE
Battery charger, controller and other electronic devices need attention to prevent self discharge. A vehicle that could discharge the battery. For...
Owner Manual - Page 44
...
In general, troubleshooting will shut off during the connect/disconnect cycle and therefore no electrical arc is generated at the recommended level and cover the plates.
• The charging ... is unable to 100 charge/discharge cycles. Maturing may result from being driven when the charger plug is designed to determine why a particular vehicle does not perform adequately. After the maturing...
Owner Manual - Page 45
... the electrolyte meets the scale on a battery that is significantly different from the 1.250 to give a corrected reading of the electrolyte will read in a vertical position at full charge. The battery must be recharged and the test repeated.
Test each other. As a battery ages the specific gravity of 1.246.
5. If the results...
Owner Manual - Page 48
Page 28
Owner's Guide GENERAL SPECIFICATIONS
RXV ELECTRIC - DO NOT use any tire which has a recommended inflation pressure less than 2.5 m/s2 The ...to 68 db(A) The highest RMS value of weighted acceleration is: 1.15 m/s2 The highest RMS value of charge meter
BATTERY CHARGER
Powerwise QE™ 48V, 110 - 120 VAC, fully automatic, line compensating, 13 Amp DC output at 48 Volts, 9.5...
Owner Manual - Page 49
... less than the inflation pressure recommended in the Owner's Guide. GENERAL SPECIFICATIONS
RXV ELECTRIC - FREEDOM VEHICLE SPECIFICATIONS
BATTERIES SPEED CONTROLLER MOTOR TRANSAXLE BRAKES PARKING BRAKE FRONT ...DASH PANEL TIRES TIRE PRESSURE GROUND CLEARANCE WEIGHT OPERATING CONTROLS &
INSTRUMENTATION LIGHTS
BATTERY CHARGER
NOISE VIBRATION, WBV VIBRATION, HAV
Four 12 Volt deep cycle (70 minute ...
Owner Manual - Page 50
... 14 - 17.5 mph (23 - 28.2 kph) in the Owner's Guide.
GENERAL SPECIFICATIONS
RXV ELECTRIC - SHUTTLE 2 + 2 VEHICLE SPECIFICATIONS
BATTERIES SPEED CONTROLLER MOTOR TRANSAXLE BRAKES PARKING BRAKE FRONT SUSPENSION ... PANEL TIRES TIRE PRESSURE GROUND CLEARANCE WEIGHT OPERATING CONTROLS &
INSTRUMENTATION LIGHTS
BATTERY CHARGER
NOISE VIBRATION, WBV VIBRATION, HAV
Four 12 Volt deep cycle (70 minute...
Owner Manual - Page 59
... and during turns.
Slow down hill. Always bring vehicle to control the vehicle.
Before working around the vehicle.
To prevent personal injury or death, observe the following:
When vehicle...are not operating correctly, take time to run or adjust powertrain.
Use extreme care when working on jack stands before attempting to consider the safety of control. A concentration of vehicle...
Similar Questions
What Causes Limp Mode Ezgo Rxv Golf Cart
(Posted by Anonymous-169198 2 years ago)
2015 Ezgo Terrain 250 Gas Car Low Oil Pressure Light?
Just Bought A Brand New 2015 Terrain 250, Gas Powered. My Owners Manual Claims There Is A Low Oil Pr...
Just Bought A Brand New 2015 Terrain 250, Gas Powered. My Owners Manual Claims There Is A Low Oil Pr...
(Posted by joeldenison 8 years ago)