2004 Chrysler PT Cruiser Support Question
2004 Chrysler PT Cruiser Support Question
Find answers below for this question about 2004 Chrysler PT Cruiser.Need a 2004 Chrysler PT Cruiser manual? We have 1 online manual for this item!
Question posted by boo1al on December 11th, 2013
What Is Involved In A 60,000 Mile Service Tune Up For A 2004 Chrysler Pt
cruiser
Current Answers
Related Manual Pages
Owner's Manual - Page 59
...not required for the engine in low gear can be detrimental and should be avoided. After the initial 60 miles (100 km), speeds up to a good break-in or out of operation. Oil changes should ... (CO) which vehicle operations will occur. A new engine may consume some oil during the first 300 miles (500 km). This should be considered as a normal part of the break-in and not interpreted as...
Owner's Manual - Page 135
... or severe catalytic converter damage. Odometer/Trip Odometer Reset Knob Press the knob to zero miles/kilometers.
4 While the trip odometer is a reminder that could lead to the AutoStick position... running, serious conditions may illuminate the light after engine start. The vehicle should be serviced if the light stays on through several of your typical driving cycles. Low Fuel Light...
Owner's Manual - Page 219
... you notice a pungent burning odor or some light smoke, your dealer for service assistance.
5 If you should not have to add anything to contain effective detergent additives.
See the paragraph on the Onboard Diagnostics System in section 7 of tune or malfunctioning and may be out of this manual. Materials Added to overheat...
Owner's Manual - Page 253
... 90°F (32°C). • Trailer towing. • Taxi, Police or delivery service (commercial service). • Off-Road or desert operation. Engine Oil Selection For best performance and maximum protection...to you , and your vehicle is equipped with a Turbo Charged Engine change intervals exceed 6000 miles (10 000 km) or 6 months whichever comes first. If none of these apply to you , ...
Owner's Manual - Page 257
...a severe malfunction could cause the converter to overheat, resulting in proper operating condition. Service, including a tune up to cool.
A hot exhaust system can start a fire if you park ... system. Such materials might be obtained immediately.
7 WARNING! In unusual situations involving grossly malfunctioning engine operation, a scorching odor may suggest severe and abnormal catalyst ...
Owner's Manual - Page 275
... the following conditions: • Police, taxi, limousine, commercial type operation, or trailer towing where the vehicle is seated properly. Maintenance schedule "B"-All Engines - Every 60,000 miles (96 000 km) change necessary. Maintenance schedule "A"-Non Turbo Charged Engines - No change necessary.
If the fluid level shows low, add sufficient transmission fluid to bring to...
Owner's Manual - Page 290
... Filter 2.4 Liter Engines (SAE 5W-30, API Certified Engine Oil) Cooling System * 2.4 Liter Turbocharged Engines (Mopar Antifreeze/Coolant 5 Year/100,000 Miles Formula) 2.4 Liter Non-Turbocharged Engines (Mopar Antifreeze/ Coolant 5 Year/100,000 Miles Formula) * Includes heater and coolant recovery bottle filled to MAX level. U.S. 15 Gallons 5.0 qts 8.1 qts 6.5 qts Metric 56.7 Liters 4.8 Liters...
Owner's Manual - Page 291
... GENUINE PARTS Engine Component Engine Coolant Engine Oil Engine Oil Filter Spark Plugs Fuel Selection Fluids, Lubricants and Genuine Parts Mopar Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Organic Additive Technology) Use API Certified SAE 5W-30 Engine Oil.
Owner's Manual - Page 295
... 295 M
• Off-road or desert operation. • If equipped for vehicles that are listed, follow the interval that best describes your engine oil every 3,000 miles (5 000 km) or 3 months, whichever comes first and follow schedule "B-All Engines" of the Maintenance Schedules section of the oil level reading. Third is for and...
Owner's Manual - Page 296
... clamps. • Rotate the tires at each oil change interval shown on Schedule "A"-NON TURBO CHARGED ENGINES 6,000 miles (10 000 km), Schedule "A"-TURBO CHARGED ENGINES 5,000 miles (8 000 km), or every other interval shown on Schedule "B"-ALL ENGINES 6,000 miles (10 000 km).
• Check the fluid levels of coolant reservoir, brake S master cylinder and transaxle and add...
Owner's Manual - Page 297
... trips of less than 50% of the conditions marked with an . N A • Trailer towing.† N C • Taxi, police, or delivery service (commercial ser-
Change the automatic transmission fluid and filter every 60,000 miles (96 000 km) if the vehicle is at sustained high T E speeds during hot weather, above 90° F (32° C ). U NOTE: If...
Owner's Manual - Page 301
... PCV make-up air filter. Change the automatic transaxle fluid and filter.
57,000 (91 000) X
60,000 (96 000) X X X X X X X X X
63,000 66,000 69,000 (101 000) (106 000) (111 000) X X X
72,000 (115 000) X X
A I N T E N A N C E S C H E D U L E S
8 Inspect the brake linings. MAINTENANCE SCHEDULES 301 M
Miles ( Kilometers) Change engine oil and engine oil filter. Inspect the PCV valve and...
Owner's Manual - Page 303
... Change the manual transaxle fluid.† Flush and replace the engine coolant at 60 months or 102,000 miles. Inspect the engine air cleaner filter and replace as necessary.
93,000 (150 000) X
96,000 (154 000) X X X
99,000 (159 000) X
102,000 (164 000) X
105,000 (168 000) X
A I N T E N A N C E S C H E D U L E S
X X X X
8 Inspect the PCV make-up air filter. If vehicle is used for trailer...
Owner's Manual - Page 304
..., or trailer towing. Adjust the generator drive belt tension. Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all receipts.
8 Replace as E necessary.* S C H E D U L E S
108,000 (173 000) X X
111,000 (178 000) X
114,000 (183 000) X X
117,000 (188 000) X
120,000 (193 000) X
Inspect the tie rod ends and boot seals. Inspect the PCV...
Owner's Manual - Page 306
...L E S
42,000 (67 000) [42] X
48,000 (77 000) [48] X
54,000 (86 000) [54] X X
60,000 (96 000) [60] X X X X X X X X
66,000 (106 000) [66] X
8
Replace the spark plugs and ignition cables. Inspect the tie rod ends and boot seals. E Replace the engine air cleaner filter. Replace the PCV make-up air filter. N C Inspect the brake linings. M 306 MAINTENANCE SCHEDULES A I N Miles T (Kilometers...
Owner's Manual - Page 307
...PCV valve and replace if necessary. Flush and replace the engine coolant at 60 months or 102,000 miles.
72,000 (115 000 [72] X X
78,000 (125 000) [78] X
84,000 (134 000) [84] X
90,000 (144 000) [90] X X X X X X X X
96,000 (154 000) [96] X
102,000 (163 000) [102] X
A I N T E N A N C E S C H E D U L E S
X
8 Inspect the brake linings. Replace the spark plugs. Not required if previously...
Owner's Manual - Page 308
... 000) [114] X
120,000 (192 000) [120] X X
* This maintenance is recommended by the manufacturer to the owner but is not required to maintain the emissions warranty. ‡ This maintenance is observed or suspected. Inspection and service should also be performed anytime a malfunction is not required if previously replaced. Retain all receipts.
8 M 308 MAINTENANCE SCHEDULES A I N Miles...
Owner's Manual - Page 311
...Miles (Kilometers) [Months] Change engine oil and engine oil filter. Inspect the PCV valve and replace if necessary. Inspect the brake linings. Not required if previously changed. * ‡ Flush and replace the engine coolant at 60... tension.
60,000 (96 000) [48] X X X X X X
65,000 (104 000) [54] X
70,000 (112 000) X
75,000 (120 000) [60] X
80,000 (128 000) [66] X X
85,000 (136 000)
X
...
Owner's Manual - Page 312
...,000 (168 000) [84] X
8
Replace the spark plugs. Replace the PCV make-up air filter. N C Inspect the brake linings.
X X X Inspect the tie rod ends and boot seals. Not required if previously changed. * ‡ Flush and replace the engine coolant if not done at 60 months. Replace the engine timing belt. M 312 MAINTENANCE SCHEDULES A I N Miles...
Owner's Manual - Page 313
... replaced. Retain all receipts.
110,000 (177 000) [90] X
115,000 (185 000) [96] X
120,000 (193 000) [102] X X
A I N T E N A N C E S C H E D U L E S
WARNING!
Inspection and service should also be badly injured working on... mechanic.
8 Do only that service work for which you have the knowledge and the right equipment. MAINTENANCE SCHEDULES 313 M
Miles (Kilometers) [Month] Change engine...
