2002 Chevrolet Malibu Support Question
2002 Chevrolet Malibu Support Question
Find answers below for this question about 2002 Chevrolet Malibu.Need a 2002 Chevrolet Malibu manual? We have 1 online manual for this item!
Question posted by capogreenw on September 9th, 2013
What Would Cause A 2002 Malibu Radiator Overflow Cap To Break
The person who posted this question about this Chevrolet automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Owner's Manual - Page 2
2002 Chevrolet Malibu Owner's Manual
Litho in U.S.A. Part Number 22675723 A First Edition
ECopyright General Motors Corporation 06/25/01
All Rights Reserved
i
Owner's Manual - Page 193
... . In a trunk, put inside the vehicle so that some of your vehicle. Try to .
4-33 These could cause you need to spread the weight evenly. D Never stack heavier things, like suitcases, inside your vehicle can break, and it whenever you can . D Don't leave an unsecured child restraint in a crash. CAUTION:
Do not...
Owner's Manual - Page 206
People have been hurt doing this can cause sparks. But if a battery has filler caps, be damaged, too. Don't get it is low, add water to take care of fluid...parts once the engine is there. If they do, you should know. CAUTION:
Using a match near a battery can cause battery gas to a remote positive (+) terminal if the vehicle has one . Battery fluid contains acid that the jumper cables...
Owner's Manual - Page 214
...check to the system, premature engine, heater core or radiator corrosion may have a leak at the pressure cap or in the radiator hoses, heater hoses, radiator, water pump or somewhere else in the cooling system...coolant. NOTICE:
When adding coolant, it could cause an engine fire, and you use of coolant other engine parts, can be burned. Damage caused by your new vehicle warranty.
5-13 If...
Owner's Manual - Page 215
... tank. If no coolant is hot. Never turn the coolant surge tank pressure cap -- They are under pressure, and if you do it. Wait for more information. Failure to follow this procedure could cause your engine to turn the pressure cap. even a little -- NOTICE:
This vehicle has a specific coolant fill procedure. If you...
Owner's Manual - Page 217
Then keep turning the pressure cap slowly, and remove it. Turn the pressure cap slowly counterclockwise (left to stop. This will allow any pressure still left ) about two or ...5-16 1. Park the vehicle on a level surface.
2. You can remove the coolant surge tank pressure cap when the cooling system, including the coolant surge tank pressure cap and upper radiator hose, is no longer hot.
Owner's Manual - Page 218
...level up to the hash mark on the label. Be sure the pressure cap is below the hash mark. Then replace the pressure cap. With the coolant surge tank pressure cap off, start the engine and let it run until the level remains ... the coolant surge tank may be lower. By this procedure until you can feel the upper radiator hose getting hot. 3. See your dealer, if necessary.
4.
Owner's Manual - Page 227
... NOTICE:
Wheel covers won 't fit. 12.
CAUTION:
Incorrect wheel nuts or improperly tightened wheel nuts can cause the wheel to use the correct wheel nuts. Tighten the wheel nuts firmly in a crisscross sequence, as... new GM original equipment wheel nuts.
Store the wheel cover and wheel nut caps in the proper sequence and to brake pulsation and rotor damage. If you have to replace ...
Owner's Manual - Page 234
... tools before adding equipment to do service work on a vehicle without knowing enough about it can later break or fall off. You could be easily confused. If it is less than 87, you may cause wind noise and affect windshield washer performance. Adding Equipment to the Outside of Your Vehicle
Things you...
Owner's Manual - Page 237
The fuel cap is highly flammable. Don't smoke if you're near gasoline or refueling your finger into the finger depression next to the fuel door.
6-6 To open ... gasoline. Filling Your Tank CAUTION:
Gasoline vapor is located behind a hinged door on the passenger's side of your vehicle. It burns violently, and that can cause very bad injuries.
Owner's Manual - Page 239
.... Static electricity discharge from the container can get one for you. See "Malfunction Indicator Lamp" in the Index. You can determine if the fuel cap has been left off or improperly installed. This may cause your vehicle. This would allow fuel to evaporate into approved containers. NOTICE:
If you need a new fuel...
Owner's Manual - Page 246
... by your oil and filter every 3,000 miles (5 000 km) or 3 months -- If any one of these conditions causes engine oil to use the recommended oil can use other commercial application. Both will need to your vehicle. D The vehicle ... either an SAE 5W-30 synthetic oil or an SAE 0W-30 oil. Failure to break down sooner. D Most trips include extensive idling (such as SAE 20W-50.
Owner's Manual - Page 247
... oil. Clean your skin for very long. Used oil can be unhealthy for your skin and could even cause cancer. If you have a problem properly disposing of your used oil stay on the ground, into sewers,... recycle it by putting it in the trash, pouring it to a place that may be a threat to break down slower. If none of them is located in the Index for more information on the driver's side of...
Owner's Manual - Page 250
... clean, drinkable water and one-half DEX-COOLR coolant which won't damage aluminum parts. Damage caused by your engine could be dangerous. Your vehicle's coolant warning system is set for the proper...use this coolant mixture, you don't need to the system, premature engine, heater core or radiator corrosion may result. If coolant other than DEX-COOLR is not covered by the use only DEX...
Owner's Manual - Page 252
...on and stays on, it means you're low on hot engine parts.
when the engine and radiator are hot enough.
See "Engine Overheating" in the Index for instructions on "How to Add ...engine. Don't spill coolant on a level surface. CAUTION:
Turning the surge tank pressure cap when the engine and radiator are hot can be burned if you spill coolant on engine coolant. When your engine...
Owner's Manual - Page 253
...Check Power Steering Fluid
Turn the key off, let the engine compartment cool down, wipe the cap and the top of fluid to regularly check power steering fluid unless you hear an unusual noise. Failure...repaired. If necessary, add only enough fluid to bring the level up to use the proper fluid can cause leaks and damage hoses and seals.
6-22
When to Check Power Steering Fluid
It is not necessary to...
Owner's Manual - Page 254
...which could damage the tank if it is completely full.
This allows for adding water.
It can cause the solution to freeze and damage your washer system and paint. Also, water doesn't clean as ...
6-23 Fill your washer fluid tank only three-quarters full when it .
D
D
Open the cap with ready-to-use washer fluid. Windshield Washer Fluid
What to Use
When you will be sure to ...
Owner's Manual - Page 256
This could cause a crash. Use new brake fluid from entering the reservoir. This will come on.
If you do need brake fluid, use the ...parts.
D
6-25 If you do , wash it . See "Recommended Fluids and Lubricants" in the Index. Always clean the brake fluid reservoir cap and the area around the cap before removing it off immediately. See "Appearance Care" in the Index.
Owner's Manual - Page 296
.... D You frequently tow a trailer or use a carrier on the following pages. Be sure to break down sooner.
7-5
Every 30,000 Miles (50 000 km): Engine Air Cleaner Filter Replacement. Every 100...,000 Miles (166 000 km): Spark Plug Wire Inspection. This is that these conditions cause engine oil to follow this schedule if you should follow the complete scheduled maintenance on top ...
Owner's Manual - Page 297
Driving a vehicle with a fully warmed engine under highway conditions will cause engine oil to follow the complete scheduled maintenance on the following pages.
7-6...used off paved roads.
Every 30,000 Miles (50 000 km): Engine Air Cleaner Filter Replacement. Be sure to break down slower. Every 60,000 Miles (100 000 km): Engine Accessory Drive Belt Inspection. Every 100,000 Miles (166...
Similar Questions
How Do You Fold Down The Seats In A 2002 Malibu Ls
(Posted by rgeGeez 10 years ago)
Air Compressor 2002 Malibu
Do you have instructions on how to replace an air compressor on a 2002 malibu that we can print out?
Do you have instructions on how to replace an air compressor on a 2002 malibu that we can print out?
(Posted by leegrantham 11 years ago)
