Specifications
Page 4
... Mode Feature Set...71 12.9 Protected Area Function...77 12.10 Address Offset Feature (Vendor Specific 79 12.11 Seek Overlap ...80 12.12 Write Cache Function ...80 12.13 Reassign Function ...81 12.14 48-bit Address Feature Set...82 13 COMMAND PROTOCOL ...83 13.1 Data In Commands...83......127 14.20 Read Native Max ADDRESS EXT (27h 128 14.21 Read Sector(s) (20h/21h) ...129 14.22 Read Sector(s) EXT (24h) ...130 14.23 Read Verify Sector(s) (40h/41h) ...131 14.24 Read Verify Sector(s) EXT (42h)...132 14.25 Recalibrate (1xh)...133 4/188 Travelstar 5K160 (PATA) Hard Disk Drive Specification 9...
... Mode Feature Set...71 12.9 Protected Area Function...77 12.10 Address Offset Feature (Vendor Specific 79 12.11 Seek Overlap ...80 12.12 Write Cache Function ...80 12.13 Reassign Function ...81 12.14 48-bit Address Feature Set...82 13 COMMAND PROTOCOL ...83 13.1 Data In Commands...83......127 14.20 Read Native Max ADDRESS EXT (27h 128 14.21 Read Sector(s) (20h/21h) ...129 14.22 Read Sector(s) EXT (24h) ...130 14.23 Read Verify Sector(s) (40h/41h) ...131 14.24 Read Verify Sector(s) EXT (42h)...132 14.25 Recalibrate (1xh)...133 4/188 Travelstar 5K160 (PATA) Hard Disk Drive Specification 9...
Specifications
Page 6
...Status Register ...58 Figure 18 Device Control Register ...59 Figure 19 Drive Address Register...59 Figure 20 Device Register...59 Figure 21 Error Register...60 Figure 22 Status Register ...ECh) ...103 Figure 52 Identify device information ...104 Figure 53 Identify device information --- Travelstar 5K160 (PATA) Hard Disk Drive Specification List of temperature and humidity...24 Figure 2. Limits of Figures Figure 1. Mounting ...Figure 36 Device address map before and after Set Feature 79 Figure 37 Seek overlap...80 Figure 38 Command set ...90 Figure 39 Command Set - Continued 105 Figure 54 ...
...Status Register ...58 Figure 18 Device Control Register ...59 Figure 19 Drive Address Register...59 Figure 20 Device Register...59 Figure 21 Error Register...60 Figure 22 Status Register ...ECh) ...103 Figure 52 Identify device information ...104 Figure 53 Identify device information --- Travelstar 5K160 (PATA) Hard Disk Drive Specification List of temperature and humidity...24 Figure 2. Limits of Figures Figure 1. Mounting ...Figure 36 Device address map before and after Set Feature 79 Figure 37 Seek overlap...80 Figure 38 Command set ...90 Figure 39 Command Set - Continued 105 Figure 54 ...
Specifications
Page 8
.... Random Vibration PSD Profile Breakpoints (nonoperating 32 Table 19. Drive ready time...19 Table 10. Physical dimensions and weight...30 Table 16. Signal definition...38 Table 23. Travelstar 5K160 (PATA) Hard Disk Drive Specification Figure 122 Write DMA Command (CAh/CBh 168 Figure 123...Figure 131 Write Sector(s) EXT Command (34h 177 Figure 132 Timeout Values...179 Figure 133 Command coverage --- Drive ready time...20 Table 11. Operating shock ...33 Table 20. Mechanical positioning performance ...18 Table 6. Magnetic flux density limits ...25 Table 13. Weighted sound power ...
.... Random Vibration PSD Profile Breakpoints (nonoperating 32 Table 19. Drive ready time...19 Table 10. Physical dimensions and weight...30 Table 16. Signal definition...38 Table 23. Travelstar 5K160 (PATA) Hard Disk Drive Specification Figure 122 Write DMA Command (CAh/CBh 168 Figure 123...Figure 131 Write Sector(s) EXT Command (34h 177 Figure 132 Timeout Values...179 Figure 133 Command coverage --- Drive ready time...20 Table 11. Operating shock ...33 Table 20. Mechanical positioning performance ...18 Table 6. Magnetic flux density limits ...25 Table 13. Weighted sound power ...
Specifications
Page 16
Typical format is allocated by each head characteristics. Travelstar 5K160 (PATA) Hard Disk Drive Specification 4.3 Cylinder allocation Data format is described below. 80GB/p format Zone Cylinder 0 0 1 6068 2 9102 3 13246 4 17390 5 21164 6 26714 7 ...29748 8 33892 9 38036 10 42180 11 45584 12 49728 13 54538 14 57202 15 60606 16 64676 17 68080 18 72594 19 74888 20...
Typical format is allocated by each head characteristics. Travelstar 5K160 (PATA) Hard Disk Drive Specification 4.3 Cylinder allocation Data format is described below. 80GB/p format Zone Cylinder 0 0 1 6068 2 9102 3 13246 4 17390 5 21164 6 26714 7 ...29748 8 33892 9 38036 10 42180 11 45584 12 49728 13 54538 14 57202 15 60606 16 64676 17 68080 18 72594 19 74888 20...
Specifications
Page 18
... requirements" on page 24) The seek time is measured from every track in milliseconds is not employed to the start of the drive population tested at nominal environmental and voltage conditions. Single track seek time Typical (ms) 1.0 1.1 Maximum (ms) 2.0 2.2 Single...seek time Typical (ms) 20.0 21.0 Max. (ms) 25.0 26.0 Full stroke seek time in both directions (inward and outward). 4.4.1.4 Average latency Rotational Speed (RPM) 5400 Table 8. Average of a reliable read or write operation. Travelstar 5K160 (PATA) Hard Disk Drive Specification Mechanical positioning 4.4.1.1 ...
... requirements" on page 24) The seek time is measured from every track in milliseconds is not employed to the start of the drive population tested at nominal environmental and voltage conditions. Single track seek time Typical (ms) 1.0 1.1 Maximum (ms) 2.0 2.2 Single...seek time Typical (ms) 20.0 21.0 Max. (ms) 25.0 26.0 Full stroke seek time in both directions (inward and outward). 4.4.1.4 Average latency Rotational Speed (RPM) 5400 Table 8. Average of a reliable read or write operation. Travelstar 5K160 (PATA) Hard Disk Drive Specification Mechanical positioning 4.4.1.1 ...
Specifications
Page 20
...The device goes into Idle mode after power on the interface connector. The execution of commands is capable of accepting commands. Drive ready time Transition Time (typ) 2.5 Transition Time (max.) 9.5 4.4.2.3 Operating mode at full speed. Standby The device ... allowed by Set Features Enable Advanced Power Management subcommand. 20/188 The head is capable of responding immediately to idle media access requests. A device in power saving mode. Travelstar 5K160 (PATA) Hard Disk Drive Specification 4.4.2 Operating modes 4.4.2.1 Description of operating modes Operating...
...The device goes into Idle mode after power on the interface connector. The execution of commands is capable of accepting commands. Drive ready time Transition Time (typ) 2.5 Transition Time (max.) 9.5 4.4.2.3 Operating mode at full speed. Standby The device ... allowed by Set Features Enable Advanced Power Management subcommand. 20/188 The head is capable of responding immediately to idle media access requests. A device in power saving mode. Travelstar 5K160 (PATA) Hard Disk Drive Specification 4.4.2 Operating modes 4.4.2.1 Description of operating modes Operating...
Specifications
Page 23
Hardware logic corrects up to 16 symbols(20 bytes) errors on-the-fly. 2 symbol System ECC is generated when HDC receives user data from HOST, and can correct up to 1 symbol(10bit) errors on-the-fly when one transfers to HOST. 23/188 5.8 Travelstar 5K160 (PATA) Hard Disk Drive Specification ECC The 10 bit 40 symbol non interleaved ECC processor provides user data verification and correction capability. The other 34 symbols are 4 check symbols for user data and the 2 symbol system ECC. The first 6 symbol of ECC are Read Solomon ECC.
Hardware logic corrects up to 16 symbols(20 bytes) errors on-the-fly. 2 symbol System ECC is generated when HDC receives user data from HOST, and can correct up to 1 symbol(10bit) errors on-the-fly when one transfers to HOST. 23/188 5.8 Travelstar 5K160 (PATA) Hard Disk Drive Specification ECC The 10 bit 40 symbol non interleaved ECC processor provides user data verification and correction capability. The other 34 symbols are 4 check symbols for user data and the 2 symbol system ECC. The first 6 symbol of ECC are Read Solomon ECC.
Specifications
Page 24
... board assembly. Specification (Environment) Relative Humidity (%) 100 90 80 70 60 Non Operating 50 Operating 40 30 20 10 0 -45 -35 -25 -15 -5 5 15 25 35 45 55 65 Temperature (degC) Figure 1. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6 Specification 6.1 Environment 6.1.1 Temperature and humidity Operating conditions Temperature Relative humidity Maximum wet bulb temperature Maximum temperature...
... board assembly. Specification (Environment) Relative Humidity (%) 100 90 80 70 60 Non Operating 50 Operating 40 30 20 10 0 -45 -35 -25 -15 -5 5 15 25 35 45 55 65 Temperature (degC) Figure 1. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6 Specification 6.1 Environment 6.1.1 Temperature and humidity Operating conditions Temperature Relative humidity Maximum wet bulb temperature Maximum temperature...
Specifications
Page 25
Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.1.2 Corrosion test The hard disk drive must be functional and show no signs of corrosion after being exposed to a temperature humidity stress of 50°C/90%RH (relative humidity) for one ...%RH in the Noise Susceptibility Test Method specification, P/N 95F3944. 25/188 Magnetic flux density limits 6.1.4 Conductive noise The disk drive shall work without soft error degradation in the frequency range from DC to 20 Mhz injected through a 50-ohm resistor connected to 45 mA (p-p) is defined in 2 hours. 6.1.3 Radiation noise The disk...
Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.1.2 Corrosion test The hard disk drive must be functional and show no signs of corrosion after being exposed to a temperature humidity stress of 50°C/90%RH (relative humidity) for one ...%RH in the Noise Susceptibility Test Method specification, P/N 95F3944. 25/188 Magnetic flux density limits 6.1.4 Conductive noise The disk drive shall work without soft error degradation in the frequency range from DC to 20 Mhz injected through a 50-ohm resistor connected to 45 mA (p-p) is defined in 2 hours. 6.1.3 Radiation noise The disk...
Specifications
Page 26
... Power Idle Watt/ Capacity (GB). 26/188 The seek average current is specified at the power connector of 20 ms) on three operations per 100 ms. 5. The idle current is specified based on the 5 volt nominal supply. 3. The worst case operating current includes motor surge. 7. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.2 DC power requirements...
... Power Idle Watt/ Capacity (GB). 26/188 The seek average current is specified at the power connector of 20 ms) on three operations per 100 ms. 5. The idle current is specified based on the 5 volt nominal supply. 3. The worst case operating current includes motor surge. 7. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.2 DC power requirements...
Specifications
Page 27
... not be applied to the cover of the drive. The drive should be protected from ESD. Seeking/Writing/Reading operation is approximately 5 years or 20,000 power on hours, whichever comes first, under the following assumptions: Less than 20% of power on hours. 6.3 Travelstar 5K160 (PATA) Hard Disk Drive Specification Reliability 6.3.1 Data reliability Probability of not recovering...
... not be applied to the cover of the drive. The drive should be protected from ESD. Seeking/Writing/Reading operation is approximately 5 years or 20,000 power on hours, whichever comes first, under the following assumptions: Less than 20% of power on hours. 6.3 Travelstar 5K160 (PATA) Hard Disk Drive Specification Reliability 6.3.1 Data reliability Probability of not recovering...
Specifications
Page 28
... suspend state, or system hibernation state. HITACHI recommends that load/unload is operated normally, not in emergency mode. 6.3.7 Emergency unload When hard disk drive power is interrupted while the heads are... 350 ms are unloaded by the drive micro code. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.3.6 Load/unload The product supports a minimum of the following commands: Hard reset Standby Standby immediate Sleep Load... unavailable to the voice coil. The drive supports a minimum of 20,000 emergency unloads. 6.3.8 Required Power-Off Sequence The required host system sequence ...
... suspend state, or system hibernation state. HITACHI recommends that load/unload is operated normally, not in emergency mode. 6.3.7 Emergency unload When hard disk drive power is interrupted while the heads are... 350 ms are unloaded by the drive micro code. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.3.6 Load/unload The product supports a minimum of the following commands: Hard reset Standby Standby immediate Sleep Load... unavailable to the voice coil. The drive supports a minimum of 20,000 emergency unloads. 6.3.8 Required Power-Off Sequence The required host system sequence ...
Specifications
Page 33
...axes, one axis at a time. Duration of 1 ms 9800 m/sec2 (1000 G) Table 20. Nonoperating shock Duration of 11 ms 1470 m/sec2 (150 G) The shocks are measured on a base plate where the drive is attached with four screws. 33/188 Operating shock Duration of 2 ms 3185 m/sec2 ...ms 1568 m/sec2 (160 G) Table 19. There must be applied to the normal disk drive subsystem mounting points used to secure the drive in each direction of the drive for a total of 60. 6.5.6 6.5.7 Travelstar 5K160 (PATA) Hard Disk Drive Specification Swept sine vibration 49 m/ sec2 (5 G) (zero-to-peak), 5 to 500 ...
...axes, one axis at a time. Duration of 1 ms 9800 m/sec2 (1000 G) Table 20. Nonoperating shock Duration of 11 ms 1470 m/sec2 (150 G) The shocks are measured on a base plate where the drive is attached with four screws. 33/188 Operating shock Duration of 2 ms 3185 m/sec2 ...ms 1568 m/sec2 (160 G) Table 19. There must be applied to the normal disk drive subsystem mounting points used to secure the drive in each direction of the drive for a total of 60. 6.5.6 6.5.7 Travelstar 5K160 (PATA) Hard Disk Drive Specification Swept sine vibration 49 m/ sec2 (5 G) (zero-to-peak), 5 to 500 ...
Specifications
Page 37
...-044 or equivalent. Interface connector pin assignments 2 DB Pin position 20 is designed to Figure 46 on page 31 show the connector location and physical pin location. The figure below and Figure 6.5.2 on page 58 for correct connector insertion. Travelstar 5K160 (PATA) Hard Disk Drive Specification 7 Electrical interface specifications 7.1 Cabling The maximum cable length...
...-044 or equivalent. Interface connector pin assignments 2 DB Pin position 20 is designed to Figure 46 on page 31 show the connector location and physical pin location. The figure below and Figure 6.5.2 on page 58 for correct connector insertion. Travelstar 5K160 (PATA) Hard Disk Drive Specification 7 Electrical interface specifications 7.1 Cabling The maximum cable length...
Specifications
Page 38
...I/O 3-state 10 11 DD03 I/O 3-state 12 13 DD02 I/O 3-state 14 15 DD01 I/O 3-state 16 17 DD00 I/O 3-state 18 19 GND (20) 21 DMARQ O 3-state 22 23 DIOW-(*) I TTL 24 25 DIOR-(*) I TTL 38 39 DASP- These lines change upon the deassertion of DMACK at...transfer mode was previously chosen via SetFeatures. These lines revert back to their original definitions upon assertion of the DMACK- Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.3 Signal definitions The pin assignments of interface signals are redefined during the Ultra DMA protocol to provide special ...
...I/O 3-state 10 11 DD03 I/O 3-state 12 13 DD02 I/O 3-state 14 15 DD01 I/O 3-state 16 17 DD00 I/O 3-state 18 19 GND (20) 21 DMARQ O 3-state 22 23 DIOW-(*) I TTL 24 25 DIOR-(*) I TTL 38 39 DASP- These lines change upon the deassertion of DMACK at...transfer mode was previously chosen via SetFeatures. These lines revert back to their original definitions upon assertion of the DMACK- Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.3 Signal definitions The pin assignments of interface signals are redefined during the Ultra DMA protocol to provide special ...
Specifications
Page 40
...within 1 ms to indicate to avoid incorrect insertion. KEY Pin position 20 has no longer busy and is used for DMA data transfers between the host and drive. These two input pins are two input pins for drive 1 to device 0 that it is busy and has not yet ...able to insert a WAIT state(s) into the host PIO cycle. Travelstar 5K160 (PATA) Hard Disk Drive Specification Following a Power On Reset, software reset, or RESET-, drive 1 shall negate PDIAG- CSEL (Cable Select) This signal is monitored to determine the drive address (master or slave) when the jumper on the same ...
...within 1 ms to indicate to avoid incorrect insertion. KEY Pin position 20 has no longer busy and is used for DMA data transfers between the host and drive. These two input pins are two input pins for drive 1 to device 0 that it is busy and has not yet ...able to insert a WAIT state(s) into the host PIO cycle. Travelstar 5K160 (PATA) Hard Disk Drive Specification Following a Power On Reset, software reset, or RESET-, drive 1 shall negate PDIAG- CSEL (Cable Select) This signal is monitored to determine the drive address (master or slave) when the jumper on the same ...
Specifications
Page 43
...- recovery time t3 DIOW- data tristate t9 DIOR-/DIOW- data setup t4 DIOW- PIO cycle timings MIN (ns) 120 25 70 25 20 10 20 5 - 10 0 - - 7.7 Travelstar 5K160 (PATA) Hard Disk Drive Specification PIO timings The PIO cycle timings meet Mode 4 of the ATA/ATAPI-6 description. setup t2 DIOR-/DIOW- data hold t6z DIOR- data...
...- recovery time t3 DIOW- data tristate t9 DIOR-/DIOW- data setup t4 DIOW- PIO cycle timings MIN (ns) 120 25 70 25 20 10 20 5 - 10 0 - - 7.7 Travelstar 5K160 (PATA) Hard Disk Drive Specification PIO timings The PIO cycle timings meet Mode 4 of the ATA/ATAPI-6 description. setup t2 DIOR-/DIOW- data hold t6z DIOR- data...
Specifications
Page 44
data setup tH DIOW- Multiword DMA cycle timings MIN (ns) 120 70 - 5 20 10 0 5 25 - - data hold tKR/tKW DIOR negated pulse width / DIOW- to DMARQ delay tZ DMACK- DMARQ tLR/tLW DMACKDIOR-/DIOWREAD DD(15:0) WRITE DD(... DMARQ delay / DIOW- MAX (ns) - - 50 - - - - - - 35 25 44/188 hold tG DIOR-/DIOW- negated pulse width tLR/tLW DIOR- to DIOR-/DIOW- Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.8 Multiword DMA timings The Multiword DMA timings meet Mode 2 of the ATA/ATAPI-6 description. data hold tI DMACK- to DMACK- setup tJ DIOR...
data setup tH DIOW- Multiword DMA cycle timings MIN (ns) 120 70 - 5 20 10 0 5 25 - - data hold tKR/tKW DIOR negated pulse width / DIOW- to DMARQ delay tZ DMACK- DMARQ tLR/tLW DMACKDIOR-/DIOWREAD DD(15:0) WRITE DD(... DMARQ delay / DIOW- MAX (ns) - - 50 - - - - - - 35 25 44/188 hold tG DIOR-/DIOW- negated pulse width tLR/tLW DIOR- to DIOR-/DIOW- Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.8 Multiword DMA timings The Multiword DMA timings meet Mode 2 of the ATA/ATAPI-6 description. data hold tI DMACK- to DMACK- setup tJ DIOR...
Specifications
Page 45
Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.9 Ultra DMA timings The Ultra DMA timings meet Mode 0, 1, 2, 3, 4, and 5 of the Ultra DMA Protocol. 7.9.1 Initiating Read DMA DMARQ DMACKSTOP HDMARDY- DMACK- before driving IORDY tFS First DSTROBE 0 230 0 200 ...20 70 20 70 tZIORD Minimum time 0 - 0 - MODE3 MIN MAX (ns) (ns) 0 - 20 - 20 55 0 - 0 130 39 - 86 - - 10 0 - 7 - 5 - interlock time tACK Setup time for output drivers to release tAZD Drivers to assert 0 - 0 - tAZ Maximum time - 10 - 10 allowed for 20 - 20 - MODE5 MIN MAX (ns) (ns) 0 - 20 - 20...
Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.9 Ultra DMA timings The Ultra DMA timings meet Mode 0, 1, 2, 3, 4, and 5 of the Ultra DMA Protocol. 7.9.1 Initiating Read DMA DMARQ DMACKSTOP HDMARDY- DMACK- before driving IORDY tFS First DSTROBE 0 230 0 200 ...20 70 20 70 tZIORD Minimum time 0 - 0 - MODE3 MIN MAX (ns) (ns) 0 - 20 - 20 55 0 - 0 130 39 - 86 - - 10 0 - 7 - 5 - interlock time tACK Setup time for output drivers to release tAZD Drivers to assert 0 - 0 - tAZ Maximum time - 10 - 10 allowed for 20 - 20 - MODE5 MIN MAX (ns) (ns) 0 - 20 - 20...
Specifications
Page 46
... MIN MAX MIN MAX MIN MAX (ns) (ns) (ns) (ns) (ns) (ns) tSR DSTROBE to - 75 - 70 - 60 final DSTROBE time Figure 8. to - 50 - 30 - 20 HDMARDY- Ultra DMA cycle timings (Host Pausing Read) MODE3 MIN MAX (ns) (ns) - - - 60 MODE4 MIN MAX (ns) (ns) - - - 60 MODE5 MIN MAX (ns) (ns... Note: When a host does not satisfy the tSR timing, the host should be ready to receive two more data words after HDMARDY- time tRFS HDMARDY- 7.9.2 Travelstar 5K160 (PATA) Hard Disk Drive Specification Host Pausing Read DMA DMARQ DMACK-
... MIN MAX MIN MAX MIN MAX (ns) (ns) (ns) (ns) (ns) (ns) tSR DSTROBE to - 75 - 70 - 60 final DSTROBE time Figure 8. to - 50 - 30 - 20 HDMARDY- Ultra DMA cycle timings (Host Pausing Read) MODE3 MIN MAX (ns) (ns) - - - 60 MODE4 MIN MAX (ns) (ns) - - - 60 MODE5 MIN MAX (ns) (ns... Note: When a host does not satisfy the tSR timing, the host should be ready to receive two more data words after HDMARDY- time tRFS HDMARDY- 7.9.2 Travelstar 5K160 (PATA) Hard Disk Drive Specification Host Pausing Read DMA DMARQ DMACK-