Specifications
Page 5
Travelstar 5K160 (PATA) Hard Disk Drive Specification 14.26 Security Disable Password (F6h)...134 14.27 Security Erase Prepare (F3h) ...135 14.28 Security Erase Unit (F4h) ...136 14.29 Security ... Set Max ADDRESS EXT (37h) ...148 14.37 Set Multiple (C6h) ...150 14.38 Sleep (E6h/99h)...151 14.39 S.M.A.R.T Function Set (B0h) ...152 14.40 Standby (E2h/96h) ...165 14.41 Standby Immediate (E0h/94h) ...166 14.42 Write Buffer (E8h) ...167 14.43 Write DMA (Cah/CBh)...168 14...
Travelstar 5K160 (PATA) Hard Disk Drive Specification 14.26 Security Disable Password (F6h)...134 14.27 Security Erase Prepare (F3h) ...135 14.28 Security Erase Unit (F4h) ...136 14.29 Security ... Set Max ADDRESS EXT (37h) ...148 14.37 Set Multiple (C6h) ...150 14.38 Sleep (E6h/99h)...151 14.39 S.M.A.R.T Function Set (B0h) ...152 14.40 Standby (E2h/96h) ...165 14.41 Standby Immediate (E0h/94h) ...166 14.42 Write Buffer (E8h) ...167 14.43 Write DMA (Cah/CBh)...168 14...
Specifications
Page 6
... Figure 3. System reset timings...42 Figure 5. Ultra DMA cycle timings (Host Terminating Write 52 Figure 15. continued ...91 Figure 40 Command Set (Subcommand)...92 Figure 41 Check Power Mode Command (E5h/98h 94 Figure 42 Device Configuration Overlay Command (B1h 95 ... 79 Figure 37 Seek overlap...80 Figure 38 Command set ...90 Figure 39 Command Set - Interface connector pin assignments ...37 Figure 4. Limits of Figures Figure 1. PIO cycle timings ...43 Figure 6. Continued 111 6/188 Travelstar 5K160 (PATA) Hard Disk Drive Specification List of temperature and humidity...
... Figure 3. System reset timings...42 Figure 5. Ultra DMA cycle timings (Host Terminating Write 52 Figure 15. continued ...91 Figure 40 Command Set (Subcommand)...92 Figure 41 Check Power Mode Command (E5h/98h 94 Figure 42 Device Configuration Overlay Command (B1h 95 ... 79 Figure 37 Seek overlap...80 Figure 38 Command set ...90 Figure 39 Command Set - Interface connector pin assignments ...37 Figure 4. Limits of Figures Figure 1. PIO cycle timings ...43 Figure 6. Continued 111 6/188 Travelstar 5K160 (PATA) Hard Disk Drive Specification List of temperature and humidity...
Specifications
Page 9
... 7 defines the hardware functional specification. General Travelstar 5K160 (PATA) Hard Disk Drive Specification 1 Introduction This document describes the specifications of the Hitachi Travelstar 5K160, a 2.5-inch hard disk drive with ATA/IDE interface: Drive name Travelstar 5K160-160 Travelstar 5K160-120 Travelstar 5K160-80 Travelstar 5K160-60 Travelstar 5K160-40 Model Number HTS541616J9AT00 HTS541612J9AT00 HTS541680J9AT00 HTS541660J9AT00 HTS541640J9AT00 Capacity (GB) 160 120 80 60 40 Height (mm) 9.5 9.5 9.5 9.5 9.5 Rotation speed (rpm) 5400...
... 7 defines the hardware functional specification. General Travelstar 5K160 (PATA) Hard Disk Drive Specification 1 Introduction This document describes the specifications of the Hitachi Travelstar 5K160, a 2.5-inch hard disk drive with ATA/IDE interface: Drive name Travelstar 5K160-160 Travelstar 5K160-120 Travelstar 5K160-80 Travelstar 5K160-60 Travelstar 5K160-40 Model Number HTS541616J9AT00 HTS541612J9AT00 HTS541680J9AT00 HTS541660J9AT00 HTS541640J9AT00 Capacity (GB) 160 120 80 60 40 Height (mm) 9.5 9.5 9.5 9.5 9.5 Rotation speed (rpm) 5400...
Specifications
Page 12
... Coding : 100/106 Multi zone recording Enhanced ECC 10 bit 40 symbol non Interleaved Read Solomon code Non interleave On-The -Fly correction Included 2 symbol system ECC Segmented Buffer with write cache 8192 KB - Travelstar 5K160 (PATA) Hard Disk Drive Specification 2 Outline of the drive 2.5-inch, 9.5-mm Height Perpendicular Recording Formatted capacities of 160GB,120GB...
... Coding : 100/106 Multi zone recording Enhanced ECC 10 bit 40 symbol non Interleaved Read Solomon code Non interleave On-The -Fly correction Included 2 symbol system ECC Segmented Buffer with write cache 8192 KB - Travelstar 5K160 (PATA) Hard Disk Drive Specification 2 Outline of the drive 2.5-inch, 9.5-mm Height Perpendicular Recording Formatted capacities of 160GB,120GB...
Specifications
Page 15
...117,210,240 60,011,642,880 HTS541640J9AT00 512 480-1272 1 1 16 63 16,383 78,140,160 40,007,761,920 4.2 Data sheet Model Rotational Speed (RPM) Data transfer rates (Max) (buffer to/from media) ...HTS541612J9AT00 512 480-1272 4 2 16 63 16,383 234,441,648 120,034,123,776 Description HTS541680J9AT00 Physical Layout Bytes per Sector Sectors per Track 512 480-1272 Number of Heads 2 Number of ...63 16,383 156,301,488 Total Logical Data Bytes 80,026,361,856 Table 1. Travelstar 5K160 (PATA) Hard Disk Drive Specification 4 Drive characteristics 4.1 Formatted capacity by model number.
...117,210,240 60,011,642,880 HTS541640J9AT00 512 480-1272 1 1 16 63 16,383 78,140,160 40,007,761,920 4.2 Data sheet Model Rotational Speed (RPM) Data transfer rates (Max) (buffer to/from media) ...HTS541612J9AT00 512 480-1272 4 2 16 63 16,383 234,441,648 120,034,123,776 Description HTS541680J9AT00 Physical Layout Bytes per Sector Sectors per Track 512 480-1272 Number of Heads 2 Number of ...63 16,383 156,301,488 Total Logical Data Bytes 80,026,361,856 Table 1. Travelstar 5K160 (PATA) Hard Disk Drive Specification 4 Drive characteristics 4.1 Formatted capacity by model number.
Specifications
Page 23
The other 34 symbols are 4 check symbols for user data and the 2 symbol system ECC. Hardware logic corrects up to 16 symbols(20 bytes) errors on-the-fly. 2 symbol System ECC is generated when HDC receives user data from HOST, and can correct up to 1 symbol(10bit) errors on-the-fly when one transfers to HOST. 23/188 The first 6 symbol of ECC are Read Solomon ECC. 5.8 Travelstar 5K160 (PATA) Hard Disk Drive Specification ECC The 10 bit 40 symbol non interleaved ECC processor provides user data verification and correction capability.
The other 34 symbols are 4 check symbols for user data and the 2 symbol system ECC. Hardware logic corrects up to 16 symbols(20 bytes) errors on-the-fly. 2 symbol System ECC is generated when HDC receives user data from HOST, and can correct up to 1 symbol(10bit) errors on-the-fly when one transfers to HOST. 23/188 The first 6 symbol of ECC are Read Solomon ECC. 5.8 Travelstar 5K160 (PATA) Hard Disk Drive Specification ECC The 10 bit 40 symbol non interleaved ECC processor provides user data verification and correction capability.
Specifications
Page 24
... -300 to 3048 m (10,000 ft) -40 to 65°C 5 to 95% noncondensing 40°C noncondensing 20°C/hour -300 to 12,192 m (40,000 ft) The system is one year. Specification (Environment) Relative Humidity (%) 100 90 80 70 60 Non Operating 50 Operating 40 30 20 10 0 -45 -35 -25 ...-15 -5 5 15 25 35 45 55 65 Temperature (degC) Figure 1. Environmental condition 5 to 55°C (See note below 63°C at the center of the drive circuit board assembly. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6 ...
... -300 to 3048 m (10,000 ft) -40 to 65°C 5 to 95% noncondensing 40°C noncondensing 20°C/hour -300 to 12,192 m (40,000 ft) The system is one year. Specification (Environment) Relative Humidity (%) 100 90 80 70 60 Non Operating 50 Operating 40 30 20 10 0 -45 -35 -25 ...-15 -5 5 15 25 35 45 55 65 Temperature (degC) Figure 1. Environmental condition 5 to 55°C (See note below 63°C at the center of the drive circuit board assembly. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6 ...
Specifications
Page 25
... (KHz) Limits (uT RMS) 0-60 500 61-100 250 101-200 100 201-400 50 Table 12. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.1.2 Corrosion test The hard disk drive must be functional and show no signs of corrosion after being exposed to a temperature humidity stress of 50°C/90... for one week followed by a temperature and humidity drop to 25'C/40%RH in the Noise Susceptibility Test Method specification, P/N 95F3944. 25/188 The test method is defined in 2 hours. 6.1.3 Radiation noise The disk drive shall work without degradation of up to 45 mA (p-p) is applied through...
... (KHz) Limits (uT RMS) 0-60 500 61-100 250 101-200 100 201-400 50 Table 12. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.1.2 Corrosion test The hard disk drive must be functional and show no signs of corrosion after being exposed to a temperature humidity stress of 50°C/90... for one week followed by a temperature and humidity drop to 25'C/40%RH in the Noise Susceptibility Test Method specification, P/N 95F3944. 25/188 The test method is defined in 2 hours. 6.1.3 Radiation noise The disk drive shall work without degradation of up to 45 mA (p-p) is applied through...
Specifications
Page 26
... 13. DC Power requirements 6.2.1 Power consumption efficiency Capacity 160GB 120GB 80GB 60GB 40 GB Power Consumption Efficiency 0.0038 (Watts/GB) Table 14. The seek average current is calculated as Power Consumption of the drive population tested at an inner track. 4. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.2 DC power requirements Connection to 6.0 Volt 100 mV p-p max. ±...
... 13. DC Power requirements 6.2.1 Power consumption efficiency Capacity 160GB 120GB 80GB 60GB 40 GB Power Consumption Efficiency 0.0038 (Watts/GB) Table 14. The seek average current is calculated as Power Consumption of the drive population tested at an inner track. 4. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.2 DC power requirements Connection to 6.0 Volt 100 mV p-p max. ±...
Specifications
Page 30
Model Height (mm) 160 GB, 120 GB models 9.5±0.2 80 GB, 60 GB, 40 GB models 9.5±0.2 Table 15. Connector specifications are shown below. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.4 Mechanical specifications 6.4.1 Physical dimensions and weight The following figure lists the dimensions for the drive. Mounting hole locations 6.4.3 Connector and jumper description A jumper is described in section 7.2, "Interface connector" on page...
Model Height (mm) 160 GB, 120 GB models 9.5±0.2 80 GB, 60 GB, 40 GB models 9.5±0.2 Table 15. Connector specifications are shown below. Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.4 Mechanical specifications 6.4.1 Physical dimensions and weight The following figure lists the dimensions for the drive. Mounting hole locations 6.4.3 Connector and jumper description A jumper is described in section 7.2, "Interface connector" on page...
Specifications
Page 32
... 0.096 5 2.88 40 1.73 500 1.73 Table 18. Random Vibration PSD Profile Breakpoints (nonoperating) Note: Overall RMS level of vibration is 29.50 m/sec2 (3.01 G). 32/188 Swept sine vibration Sweep rate (oct/min) 1.0 6.5.4 Nonoperating vibration The disk drive withstands the following vibration... vibration The test consists of 30 minutes of random vibration using the power spectral density (PSD) levels below . Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.5 Vibration and shock All vibration and shock measurements in each of three mutually perpendicular axes for a duration ...
... 0.096 5 2.88 40 1.73 500 1.73 Table 18. Random Vibration PSD Profile Breakpoints (nonoperating) Note: Overall RMS level of vibration is 29.50 m/sec2 (3.01 G). 32/188 Swept sine vibration Sweep rate (oct/min) 1.0 6.5.4 Nonoperating vibration The disk drive withstands the following vibration... vibration The test consists of 30 minutes of random vibration using the power spectral density (PSD) levels below . Travelstar 5K160 (PATA) Hard Disk Drive Specification 6.5 Vibration and shock All vibration and shock measurements in each of three mutually perpendicular axes for a duration ...
Specifications
Page 34
... 2.7 160GB, 120GB models Operating 2.7 2.9 Idle 2.2 2.4 80GB, 60GB, 40GB models Operating 2.4 2.6 Table 21. The seek rate for the drive can be taken in accordance with the following , unit ready to receive and respond to the A-weighted sound power (Lw) with ISO 7779. ... Tone-to-noise ratio taken in both board down orientations. The mean of the sample of 40 drives is to be less than the typical value. 6.6 Travelstar 5K160 (PATA) Hard Disk Drive Specification Acoustics 6.6.1 Sound power level The criteria of A-weighted sound power level are described below ...
... 2.7 160GB, 120GB models Operating 2.7 2.9 Idle 2.2 2.4 80GB, 60GB, 40GB models Operating 2.4 2.6 Table 21. The seek rate for the drive can be taken in accordance with the following , unit ready to receive and respond to the A-weighted sound power (Lw) with ISO 7779. ... Tone-to-noise ratio taken in both board down orientations. The mean of the sample of 40 drives is to be less than the typical value. 6.6 Travelstar 5K160 (PATA) Hard Disk Drive Specification Acoustics 6.6.1 Sound power level The criteria of A-weighted sound power level are described below ...
Specifications
Page 38
...was previously chosen via SetFeatures. The drive becomes aware of this change from the drive I designates an input to the drive I TTL 26 27 IORDY(*) O OD 28 29 DMACK- Write Operation HSTROBE STOP HDMARDY- Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.3 Signal definitions The pin ...-(*) I /O designates an input/output common OD designates an Open-Drain output power designates a power supply to the drive reserved designates reserved pins which must be left unconnected The signal lines marked with (*) are listed as follows: PIN SIGNAL I /O OD...
...was previously chosen via SetFeatures. The drive becomes aware of this change from the drive I designates an input to the drive I TTL 26 27 IORDY(*) O OD 28 29 DMACK- Write Operation HSTROBE STOP HDMARDY- Travelstar 5K160 (PATA) Hard Disk Drive Specification 7.3 Signal definitions The pin ...-(*) I /O designates an input/output common OD designates an Open-Drain output power designates a power supply to the drive reserved designates reserved pins which must be left unconnected The signal lines marked with (*) are listed as follows: PIN SIGNAL I /O OD...
Specifications
Page 40
...wait up to 5 Volt through a 10 kΩ resistor. 40/188 Device 1 should be different from the host. is used to device 0 that it is busy). This line is ready to assert PDIAG-. when the drive needs some additional WAIT cycle(s) to insert a WAIT state(s) ...or DIOW- The direction of a valid Execute Drive Diagnostics command, device 1 shall negate PDIAG- When CSEL is at a low level, the drive works as PDIAG- Travelstar 5K160 (PATA) Hard Disk Drive Specification Following a Power On Reset, software reset, or RESET-, drive 1 shall negate PDIAG- KEY Pin position 20 ...
...wait up to 5 Volt through a 10 kΩ resistor. 40/188 Device 1 should be different from the host. is used to device 0 that it is busy). This line is ready to assert PDIAG-. when the drive needs some additional WAIT cycle(s) to insert a WAIT state(s) ...or DIOW- The direction of a valid Execute Drive Diagnostics command, device 1 shall negate PDIAG- When CSEL is at a low level, the drive works as PDIAG- Travelstar 5K160 (PATA) Hard Disk Drive Specification Following a Power On Reset, software reset, or RESET-, drive 1 shall negate PDIAG- KEY Pin position 20 ...
Specifications
Page 60
HS3,HS2,HS1,HS0 Travelstar 5K160 (PATA) Hard Disk Drive Specification selected. UNC=1 indicates an uncorrectable data error has been encountered. IDN=1 indicates the requested sector's ID field could not be found after finding the ... is obsolete. 11.8 Features Register This register is used , the "most recently written" content contains LBA Bits 16-23, and the "previous content" contains Bits 40-47. At the end of the command, this register are valid always even if ERR=0 in the Status Register. At the end of this register...
HS3,HS2,HS1,HS0 Travelstar 5K160 (PATA) Hard Disk Drive Specification selected. UNC=1 indicates an uncorrectable data error has been encountered. IDN=1 indicates the requested sector's ID field could not be found after finding the ... is obsolete. 11.8 Features Register This register is used , the "most recently written" content contains LBA Bits 16-23, and the "previous content" contains Bits 40-47. At the end of the command, this register are valid always even if ERR=0 in the Status Register. At the end of this register...
Specifications
Page 90
Travelstar 5K160 (PATA) Hard Disk Drive Specification 14 Command Descriptions Protocol Command 3 Check Power Mode 3 Check Power Mode* 3 Device Configuration RESTORE 3 Device Configuration FREEZE LOCK 1 Device Configuration IDENTIFY 2 Device Configuration SET 3 ... E7 EA 50 F7 EC E3 97 E1 95 E1 91 E4 C8 C9 25 2F 22 23 C4 29 F8 27 20 21 24 40 41 42 1x F6 F3 F4 F5 F1 F2 7x F0 EF 76543210 11100101 10011000 10100001 10100001 10100001 10100001 10010000 11100111 11101010 01010000 11110111 11101100...
Travelstar 5K160 (PATA) Hard Disk Drive Specification 14 Command Descriptions Protocol Command 3 Check Power Mode 3 Check Power Mode* 3 Device Configuration RESTORE 3 Device Configuration FREEZE LOCK 1 Device Configuration IDENTIFY 2 Device Configuration SET 3 ... E7 EA 50 F7 EC E3 97 E1 95 E1 91 E4 C8 C9 25 2F 22 23 C4 29 F8 27 20 21 24 40 41 42 1x F6 F3 F4 F5 F1 F2 7x F0 EF 76543210 11100101 10011000 10100001 10100001 10100001 10100001 10010000 11100111 11101010 01010000 11110111 11101100...
Specifications
Page 92
...S.M.A.R.T. " Figure 40 Command Set (Subcommand)" on page 90 shows the commands that are supported by each command or feature. 92/188 Disable Operations S.M.A.R.T. Return Status S.M.A.R.T. Read Log Sector S.M.A.R.T. Execute Off-line Immediate S.M.A.R.T. Enable Operations S.M.A.R.T. Travelstar 5K160 (PATA) Hard Disk Drive Specification Command (...Device Configuration Overlay) Device Configuration RESTORE Device Configuration FREEZE LOCK Device Configuration IDENTIFY Device Configuration SET Figure 40 Command Set (Subcommand) Command code (Hex) B0 B0 B0 B0 B0 B0 B0 B0 B0 B0...
...S.M.A.R.T. " Figure 40 Command Set (Subcommand)" on page 90 shows the commands that are supported by each command or feature. 92/188 Disable Operations S.M.A.R.T. Return Status S.M.A.R.T. Read Log Sector S.M.A.R.T. Execute Off-line Immediate S.M.A.R.T. Enable Operations S.M.A.R.T. Travelstar 5K160 (PATA) Hard Disk Drive Specification Command (...Device Configuration Overlay) Device Configuration RESTORE Device Configuration FREEZE LOCK Device Configuration IDENTIFY Device Configuration SET Figure 40 Command Set (Subcommand) Command code (Hex) B0 B0 B0 B0 B0 B0 B0 B0 B0 B0...
Specifications
Page 118
...(15:8) LBA Mid Previous LBA (39:32) LBA High Current LBA (23:16) LBA High Previous LBA (47:40) Input Parameters From The Device LBA Low (HOB=0) LBA (7:0) of the address of the first unrecoverable error. Feature ... HOB=1 V V V V V V V V HOB=0 V V V V V V V V HOB=1 V V V V V V V V V See Below... LBA Mid (HOB=1) LBA (39:32)of the address of the first unrecoverable error. Travelstar 5K160 (PATA) Hard Disk Drive Specification 14.14 Read DMA EXT (25h) Command Block Output Registers Register 76543210 Data Low -------- If 0000h in the Sector Count register is available.
...(15:8) LBA Mid Previous LBA (39:32) LBA High Current LBA (23:16) LBA High Previous LBA (47:40) Input Parameters From The Device LBA Low (HOB=0) LBA (7:0) of the address of the first unrecoverable error. Feature ... HOB=1 V V V V V V V V HOB=0 V V V V V V V V HOB=1 V V V V V V V V V See Below... LBA Mid (HOB=1) LBA (39:32)of the address of the first unrecoverable error. Travelstar 5K160 (PATA) Hard Disk Drive Specification 14.14 Read DMA EXT (25h) Command Block Output Registers Register 76543210 Data Low -------- If 0000h in the Sector Count register is available.
Specifications
Page 123
... Self-test failure check point Failing LBA (7:0) Failing LBA (15:8) Failing LBA (23:16) Failing LBA (31:24) Failing LBA (39:32) Failing LBA (47:40) Vendor specific Figure 75 Extended Self-test log descriptor entry Bytes 1 1 2 1 1 1 1 1 1 1 15 26 Offset 00h 01h 02h 04h 05h 06h 07h 08h 09h 0Ah 0Bh... have been no self-tests, this revision number shall be 01h. 14.15.3.2 Self-test descriptor index This indicates the most recent self-test descriptor. Travelstar 5K160 (PATA) Hard Disk Drive Specification Figure 74 Extended Self-test log data structure These descriptor entries are 0 to zero.
... Self-test failure check point Failing LBA (7:0) Failing LBA (15:8) Failing LBA (23:16) Failing LBA (31:24) Failing LBA (39:32) Failing LBA (47:40) Vendor specific Figure 75 Extended Self-test log descriptor entry Bytes 1 1 2 1 1 1 1 1 1 1 15 26 Offset 00h 01h 02h 04h 05h 06h 07h 08h 09h 0Ah 0Bh... have been no self-tests, this revision number shall be 01h. 14.15.3.2 Self-test descriptor index This indicates the most recent self-test descriptor. Travelstar 5K160 (PATA) Hard Disk Drive Specification Figure 74 Extended Self-test log data structure These descriptor entries are 0 to zero.
Specifications
Page 126
Travelstar 5K160 (PATA) Hard Disk Drive Specification 14.18 Read Multiple EXT (29h) Command Block Output Registers Register 76543210 Data Low -------- Command 00101001 Command Block Input Registers Register 76543210 Data Low ...... If 0000h in the Sector Count register is specified, then 65,536 sectors will be transferred high order, bits (15:8). LBA High (HOB=1) LBA (47:40)of the address of the first unrecoverable error. Sector Count LBA Low LBA Mid LBA High Device Status HOB=0 HOB=1 HOB=0 V V V V V V V V HOB=1 V V V V V V V V HOB=0 V V V V V V V V HOB=1 V V V V V V V V...
Travelstar 5K160 (PATA) Hard Disk Drive Specification 14.18 Read Multiple EXT (29h) Command Block Output Registers Register 76543210 Data Low -------- Command 00101001 Command Block Input Registers Register 76543210 Data Low ...... If 0000h in the Sector Count register is specified, then 65,536 sectors will be transferred high order, bits (15:8). LBA High (HOB=1) LBA (47:40)of the address of the first unrecoverable error. Sector Count LBA Low LBA Mid LBA High Device Status HOB=0 HOB=1 HOB=0 V V V V V V V V HOB=1 V V V V V V V V HOB=0 V V V V V V V V HOB=1 V V V V V V V V...