Owners Manual
Page 112
Running the engine at high speed while the vehicle is stopped may cause the exhaust system to overheat, which could result in a fire if combustible material is nearby. 2-1. Driving procedures CAUTION ● Avoid revving or racing the engine.
Running the engine at high speed while the vehicle is stopped may cause the exhaust system to overheat, which could result in a fire if combustible material is nearby. 2-1. Driving procedures CAUTION ● Avoid revving or racing the engine.
Owners Manual
Page 113
2-1. Failure to do so may allow exhaust gases to have the vehicle inspected and repaired by your Toyota dealer. If there is a hole or crack caused by corrosion, damage to a joint or abnormal exhaust noise, be checked occasionally. Driving procedures CAUTION ● The exhaust should be sure to enter the vehicle, resulting in death or a serious health hazard.
2-1. Failure to do so may allow exhaust gases to have the vehicle inspected and repaired by your Toyota dealer. If there is a hole or crack caused by corrosion, damage to a joint or abnormal exhaust noise, be checked occasionally. Driving procedures CAUTION ● The exhaust should be sure to enter the vehicle, resulting in death or a serious health hazard.
Owners Manual
Page 325
Engine compartment Items Battery Brake fluid Engine coolant Engine oil Exhaust system Radiator/condenser/hoses Washer fluid Check points Check the connections. (→P. 367) At the correct level? It is recommended that should be performed at ... ne ra l m a int e na nc e Listed below are the general maintenance items that any problem you notice should be brought to the attention of your Toyota dealer or qualified service shop for advice. 4 -2 .
Engine compartment Items Battery Brake fluid Engine coolant Engine oil Exhaust system Radiator/condenser/hoses Washer fluid Check points Check the connections. (→P. 367) At the correct level? It is recommended that should be performed at ... ne ra l m a int e na nc e Listed below are the general maintenance items that any problem you notice should be brought to the attention of your Toyota dealer or qualified service shop for advice. 4 -2 .
Owners Manual
Page 453
6-1. Specifications Engine 1.8 L 4-cylinder (2ZR-FE) engine Model Type Bore and stroke Displacement Drive belt tension* Valve clearance (engine cold) Intake Exhaust 2ZR-FE engine 4 cylinder in line, 4 cycle, gasoline 3.17 × 3.48 in. (80.5 × 88.3 mm) 109.7 cu.in. (1798 cm3) 143 ± 22 lbf (650 ± 100 N, 65 ± 10 kgf) Automatic adjustment *: Drive belt tension measured with Borroughs drive belt tension gauge No. BT33-73F (used belt), lbf 6 Vehicle specifications 473
6-1. Specifications Engine 1.8 L 4-cylinder (2ZR-FE) engine Model Type Bore and stroke Displacement Drive belt tension* Valve clearance (engine cold) Intake Exhaust 2ZR-FE engine 4 cylinder in line, 4 cycle, gasoline 3.17 × 3.48 in. (80.5 × 88.3 mm) 109.7 cu.in. (1798 cm3) 143 ± 22 lbf (650 ± 100 N, 65 ± 10 kgf) Automatic adjustment *: Drive belt tension measured with Borroughs drive belt tension gauge No. BT33-73F (used belt), lbf 6 Vehicle specifications 473
Owners Manual
Page 454
Specifications 2.4 L 4-cylinder (2AZ-FE) engine Model Type Bore and stroke Displacement Drive belt tension Valve clearance (engine cold) Intake Exhaust 2AZ-FE engine 4 cylinder in line, 4 cycle, gasoline 3.48 × 3.78 in. (88.5 × 96.0 mm) 144.1 cu.in. (2362 cm3) Automatic adjustment 0.007 ⎯ 0....
Specifications 2.4 L 4-cylinder (2AZ-FE) engine Model Type Bore and stroke Displacement Drive belt tension Valve clearance (engine cold) Intake Exhaust 2AZ-FE engine 4 cylinder in line, 4 cycle, gasoline 3.48 × 3.78 in. (88.5 × 96.0 mm) 144.1 cu.in. (2362 cm3) Automatic adjustment 0.007 ⎯ 0....
Warranty, Maitenance, Services Guide
Page 19
... Induction System • Intake manifold and intake air surge tank Catalyst System • Catalytic converter and protector (8/80) • Constricted fuel filler neck • Exhaust manifold • Exhaust pipe (manifold to catalyst and/or catalyst to catalyst) Evaporative Control System Charcoal canister Diaphragm valve Fuel filler cap Fuel tank Vapor liquid separator...
... Induction System • Intake manifold and intake air surge tank Catalyst System • Catalytic converter and protector (8/80) • Constricted fuel filler neck • Exhaust manifold • Exhaust pipe (manifold to catalyst and/or catalyst to catalyst) Evaporative Control System Charcoal canister Diaphragm valve Fuel filler cap Fuel tank Vapor liquid separator...
Warranty, Maitenance, Services Guide
Page 20
... you used a service provider other than a Toyota dealership for maintenance and repairs. When maintenance and repairs are responsible for performance of the required maintenance indicated in the Owner's Manual and this warranty. Federal Emission Control Warranty MAINTENANCE Exhaust Gas Recirculation (EGR) System • EGR gas...solenoids, switches and valves * Warranted until first required maintenance under terms of maintenance is not covered by this warranty. Toyota will not deny a warranty claim solely because you do not have records to show that you maintained your vehicle...
... you used a service provider other than a Toyota dealership for maintenance and repairs. When maintenance and repairs are responsible for performance of the required maintenance indicated in the Owner's Manual and this warranty. Federal Emission Control Warranty MAINTENANCE Exhaust Gas Recirculation (EGR) System • EGR gas...solenoids, switches and valves * Warranted until first required maintenance under terms of maintenance is not covered by this warranty. Toyota will not deny a warranty claim solely because you do not have records to show that you maintained your vehicle...
Warranty, Maitenance, Services Guide
Page 26
... System • Engine control computer (engine control module) • Throttle body Air Induction System • Intake manifold and intake air surge tank Catalyst System • Exhaust front pipe (including catalytic converter) Evaporative Control System • Fuel tank Your Warranties in -service date, whichever occurs first. California Emission Control Warranty PARTS LIST...
... System • Engine control computer (engine control module) • Throttle body Air Induction System • Intake manifold and intake air surge tank Catalyst System • Exhaust front pipe (including catalytic converter) Evaporative Control System • Fuel tank Your Warranties in -service date, whichever occurs first. California Emission Control Warranty PARTS LIST...
Warranty, Maitenance, Services Guide
Page 40
....1 Inspect the following: __ __ __ __ Ball joints and dust covers Brake lines and hoses Drive shaft boots Engine coolant 3 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on chassis and body Repeated trips of...
....1 Inspect the following: __ __ __ __ Ball joints and dust covers Brake lines and hoses Drive shaft boots Engine coolant 3 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on chassis and body Repeated trips of...
Warranty, Maitenance, Services Guide
Page 42
... joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 3 __ Drive shaft boots __ Engine coolant 4 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
... joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 3 __ Drive shaft boots __ Engine coolant 4 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
Warranty, Maitenance, Services Guide
Page 44
....1 Inspect the following: __ __ __ __ Ball joints and dust covers Brake lines and hoses Drive shaft boots Engine coolant 3 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on chassis and body Repeated trips of...
....1 Inspect the following: __ __ __ __ Ball joints and dust covers Brake lines and hoses Drive shaft boots Engine coolant 3 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on chassis and body Repeated trips of...
Warranty, Maitenance, Services Guide
Page 46
... covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 3 __ Drive belts 4 __ Drive shaft boots __ Engine coolant 5 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
... covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 3 __ Drive belts 4 __ Drive shaft boots __ Engine coolant 5 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
Warranty, Maitenance, Services Guide
Page 48
... oil filter.1 Inspect the following: Ball joints and dust covers Brake lines and hoses Drive belts Drive shaft boots Engine coolant 3 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on chassis and body Repeated trips of...
... oil filter.1 Inspect the following: Ball joints and dust covers Brake lines and hoses Drive belts Drive shaft boots Engine coolant 3 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on chassis and body Repeated trips of...
Warranty, Maitenance, Services Guide
Page 50
... covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 3 __ Drive belts __ Drive shaft boots __ Engine coolant 4 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
... covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 3 __ Drive belts __ Drive shaft boots __ Engine coolant 4 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
Warranty, Maitenance, Services Guide
Page 52
... oil filter.1 Inspect the following: Ball joints and dust covers Brake lines and hoses Drive belts Drive shaft boots Engine coolant 4 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on dirt roads or in urban, dusty...
... oil filter.1 Inspect the following: Ball joints and dust covers Brake lines and hoses Drive belts Drive shaft boots Engine coolant 4 __ __ __ __ Exhaust pipes and mountings Radiator and condenser Steering gear box Steering linkage and boots Note: Driving in heavy traffic, on dirt roads or in urban, dusty...
Warranty, Maitenance, Services Guide
Page 54
... covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 4 __ Drive belts __ Drive shaft boots __ Engine coolant 5 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
... covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs 4 __ Drive belts __ Drive shaft boots __ Engine coolant 5 __ Exhaust pipes and mountings __ Front differential oil __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank...
Warranty, Maitenance, Services Guide
Page 57
... must be replaced at specified intervals. Fuel Tank Cap Gasket Visually inspect for any problem repaired immediately by a qualified technician. 56 Maintenance Log Have any exhaust gas leakage. Start the engine and listen carefully for cracks, deterioration and damage and replace if necessary. Spark Plugs Replace at 5,000 miles or 6 months... Items Engine Oil and Oil Filter Replace the oil filter and drain and refill the engine oil at A 5,000 miles or 6 month INTERVAL with Genuine Toyota 0W20 motor oil. Tighten connections or replace parts as necessary.
... must be replaced at specified intervals. Fuel Tank Cap Gasket Visually inspect for any problem repaired immediately by a qualified technician. 56 Maintenance Log Have any exhaust gas leakage. Start the engine and listen carefully for cracks, deterioration and damage and replace if necessary. Spark Plugs Replace at 5,000 miles or 6 months... Items Engine Oil and Oil Filter Replace the oil filter and drain and refill the engine oil at A 5,000 miles or 6 month INTERVAL with Genuine Toyota 0W20 motor oil. Tighten connections or replace parts as necessary.