Owner's Manual
Page 82
... ...118 ▫ Console Storage Compartment ...118 ▫ Rear Storage Compartment ...119 Dual Top - If Equipped ...120 ▫ Removing The Soft Top ...120 ▫ Installing The Soft Top ...122 Freedom Top Three-Piece Modular Hard Top ...125 ▫ Front Panel(s) Removal ...126 ▫ Front Panel(s) Installation ...128 ▫ Front Panel(s) Installation Only (With Rear...
... ...118 ▫ Console Storage Compartment ...118 ▫ Rear Storage Compartment ...119 Dual Top - If Equipped ...120 ▫ Removing The Soft Top ...120 ▫ Installing The Soft Top ...122 Freedom Top Three-Piece Modular Hard Top ...125 ▫ Front Panel(s) Removal ...126 ▫ Front Panel(s) Installation ...128 ▫ Front Panel(s) Installation Only (With Rear...
Owner's Manual
Page 83
82 UNDERSTANDING THE FEATURES OF YOUR VEHICLE Door Frame ...132 ▫ Door Frame Removal (Two-Door Models) ...132 ▫ Door Frame Installation (Two-Door Models) . . 134 ▫ Door Frame Removal (Four-Door Models) ...135 ▫ Door Frame Installation (Four-Door Models) . . 138 Soft Top (Two-...9643; Putting Up The Soft Top ...180 Folding Windshield ...191 ▫ Lowering The Windshield And Removing Side Bars ...193 ▫ Raising The Windshield And Replacing Side Bars ...196 Rear Window Features - Hard Top Only ...197 ▫ Rear Window Wiper/Washer - If Equipped ...197 ▫ Rear ...
82 UNDERSTANDING THE FEATURES OF YOUR VEHICLE Door Frame ...132 ▫ Door Frame Removal (Two-Door Models) ...132 ▫ Door Frame Installation (Two-Door Models) . . 134 ▫ Door Frame Removal (Four-Door Models) ...135 ▫ Door Frame Installation (Four-Door Models) . . 138 Soft Top (Two-...9643; Putting Up The Soft Top ...180 Folding Windshield ...191 ▫ Lowering The Windshield And Removing Side Bars ...193 ▫ Raising The Windshield And Replacing Side Bars ...196 Rear Window Features - Hard Top Only ...197 ▫ Rear Window Wiper/Washer - If Equipped ...197 ▫ Rear ...
Owner's Manual
Page 121
... the tops from both tops remaining on the soft top. Removal is removed, the pivot brackets must remove one of time. Remove the hard top. The soft top and the hard top are to "Freedom Top ThreePiece Modular Hard Top - Front/Rear Panel Removal" later in this section. Your vehicle warranty will not cover...; Two rear window roll up straps • Two Sunrider secure straps (If Equipped) • Two rear swing gate brackets 2. Removing The Soft Top 1. Refer to be removed from the sport bar. If the soft top is mandatory to prevent any possible wear and tear on the vehicle at the...
... the tops from both tops remaining on the soft top. Removal is removed, the pivot brackets must remove one of time. Remove the hard top. The soft top and the hard top are to "Freedom Top ThreePiece Modular Hard Top - Front/Rear Panel Removal" later in this section. Your vehicle warranty will not cover...; Two rear window roll up straps • Two Sunrider secure straps (If Equipped) • Two rear swing gate brackets 2. Removing The Soft Top 1. Refer to be removed from the sport bar. If the soft top is mandatory to prevent any possible wear and tear on the vehicle at the...
Owner's Manual
Page 123
... and left door frames • Door frame attachment knobs (four for two-door models, six for first time set up only. Reinstall the hard top. Remove the brackets using a #T30 Torx head driver. For future soft top procedures, refer to "Soft Top" in this section. Refer to "...Freedom Top ThreePiece Modular Hard Top - Front/Rear Panel Removal" later in a safe place. 122 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 5. Recover and re-zip the sports bar cover. Locate and remove the following procedures are for four-door models) • Right ...
... and left door frames • Door frame attachment knobs (four for two-door models, six for first time set up only. Reinstall the hard top. Remove the brackets using a #T30 Torx head driver. For future soft top procedures, refer to "Soft Top" in this section. Refer to "...Freedom Top ThreePiece Modular Hard Top - Front/Rear Panel Removal" later in a safe place. 122 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 5. Recover and re-zip the sports bar cover. Locate and remove the following procedures are for four-door models) • Right ...
Owner's Manual
Page 126
... top has been either fully attached to carry any additional loads other than environmental (rain, snow, etc.). 3 CAUTION! FREEDOM TOP THREE-PIECE MODULAR HARD TOP CAUTION! • The hard top is enclosed in the dual top wrap. 6. It was not designed as roof racks, spare tires, building, hunting, or camping supplies, and... lift the top. 7. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 125 5. NOTE: A visual instruction sheet is not designed to the windshield frame and bodyside, or fully removed. Remove the swing gate bar (black metal bar for shipping only. Unsnap and...
... top has been either fully attached to carry any additional loads other than environmental (rain, snow, etc.). 3 CAUTION! FREEDOM TOP THREE-PIECE MODULAR HARD TOP CAUTION! • The hard top is enclosed in the dual top wrap. 6. It was not designed as roof racks, spare tires, building, hunting, or camping supplies, and... lift the top. 7. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 125 5. NOTE: A visual instruction sheet is not designed to the windshield frame and bodyside, or fully removed. Remove the swing gate bar (black metal bar for shipping only. Unsnap and...
Owner's Manual
Page 129
Also, make sure that the panels are sitting flush with the body. 2. Front Panel(s) Installation Only (With Rear Hard Top Removed) 1. Install right panel first, then the left panel. Set the panels on the windshield frame so that there is no overhang. Install right ...panel first, then the left panel. 2. Reinstall panel(s) using the same steps for removal in reverse order. NOTE: The front panel(s) must be positioned properly to ensure sealing. Turn left and right panels over and move spacer block ...
Also, make sure that the panels are sitting flush with the body. 2. Front Panel(s) Installation Only (With Rear Hard Top Removed) 1. Install right panel first, then the left panel. Set the panels on the windshield frame so that there is no overhang. Install right ...panel first, then the left panel. 2. Reinstall panel(s) using the same steps for removal in reverse order. NOTE: The front panel(s) must be positioned properly to ensure sealing. Turn left and right panels over and move spacer block ...
Owner's Manual
Page 130
... (along the interior bodyside) using a #40 Torx head driver. 5. Remove both doors. 3. Lift rear window glass. 3 Reinstall panel(s) using a #40 Torx head driver (4-Door Only). 4. Remove the six Torx head screws that secure the hard top at the B-pillar (near top of the rear window glass. Open... swing gate all the way to ensure clearance of door) using the same steps for removal in this section. 2. UNDERSTANDING THE FEATURES...
... (along the interior bodyside) using a #40 Torx head driver. 5. Remove both doors. 3. Lift rear window glass. 3 Reinstall panel(s) using a #40 Torx head driver (4-Door Only). 4. Remove the six Torx head screws that secure the hard top at the B-pillar (near top of the rear window glass. Open... swing gate all the way to ensure clearance of door) using the same steps for removal in this section. 2. UNDERSTANDING THE FEATURES...
Owner's Manual
Page 132
... damage and replace if necessary. 2. Remove the hard top from soft top usage, they must be removed prior to ensure sealing. NOTE: The hard top must be positioned properly to installation of the hard top. 1. Place on a soft surface to ensure that the hard top is sitting flush with the body... and check to prevent damage. Also, make sure that there is a uniform gap between the lift glass and hard top. 3 9. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 131 Rear Hard Top Installation NOTE: If the door frames are installed from the vehicle. Close the swing gate. 10. Inspect...
... damage and replace if necessary. 2. Remove the hard top from soft top usage, they must be removed prior to ensure sealing. NOTE: The hard top must be positioned properly to installation of the hard top. 1. Place on a soft surface to ensure that the hard top is sitting flush with the body... and check to prevent damage. Also, make sure that there is a uniform gap between the lift glass and hard top. 3 9. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 131 Rear Hard Top Installation NOTE: If the door frames are installed from the vehicle. Close the swing gate. 10. Inspect...
Owner's Manual
Page 150
The swing gate brackets do not need to Step 16. 3 If your vehicle is not equipped with the Sunrider package, proceed to be removed unless the hard top is being installed. Completely release the latches from the loops on the windshield frame. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 149 12. To remove the swing gate brackets, pull the front of the bracket forward while rolling the entire bracket back in towards the vehicle to disengage. 13.
The swing gate brackets do not need to Step 16. 3 If your vehicle is not equipped with the Sunrider package, proceed to be removed unless the hard top is being installed. Completely release the latches from the loops on the windshield frame. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 149 12. To remove the swing gate brackets, pull the front of the bracket forward while rolling the entire bracket back in towards the vehicle to disengage. 13.
Owner's Manual
Page 177
Grasp the front side bow behind the header, and lift the top. To remove the swing gate brackets, pull the front of the bracket forward while rolling the entire bracket back in towards the vehicle to be removed unless the hard top is being installed. 176 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 12. The swing gate brackets do not need to disengage. 13.
Grasp the front side bow behind the header, and lift the top. To remove the swing gate brackets, pull the front of the bracket forward while rolling the entire bracket back in towards the vehicle to be removed unless the hard top is being installed. 176 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 12. The swing gate brackets do not need to disengage. 13.
Owner's Manual
Page 194
...), and the one hex bolt (13 mm) on the side of the side bar. 3 Open sport bar Velcro covering. 4. NOTE: To assist in this manual. Remove the one hex bolt (13 mm) visible through the plastic trim on bottom side of side bar, one hex bolt (13 mm) on top of... the side bar, and one side hex bolt (13 mm) visible through the trim (Do not remove plastic corner trim, sun visor bolts, or sport bar covering). 3. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 193 Lowering The Windshield And...
...), and the one hex bolt (13 mm) on the side of the side bar. 3 Open sport bar Velcro covering. 4. NOTE: To assist in this manual. Remove the one hex bolt (13 mm) visible through the plastic trim on bottom side of side bar, one hex bolt (13 mm) on top of... the side bar, and one side hex bolt (13 mm) visible through the trim (Do not remove plastic corner trim, sun visor bolts, or sport bar covering). 3. UNDERSTANDING THE FEATURES OF YOUR VEHICLE 193 Lowering The Windshield And...
Owner's Manual
Page 371
... lowered. 8. A loose tire or jack, thrown forward in the places provided. 11. Always stow the jack parts and the spare tire in a collision or hard stop, could slip off the jack, do not tighten the nuts fully until each nut has been tightened twice. Raising the vehicle higher than necessary...your authorized dealer or at a service station. 10. Push down on vehicle and install lug nuts with a torque wrench by turning the jack screw to remove the tire. 6. Secure the tire, jack, and tools in doubt about the correct tightness, have them checked with cone-shaped end toward wheel. Raise ...
... lowered. 8. A loose tire or jack, thrown forward in the places provided. 11. Always stow the jack parts and the spare tire in a collision or hard stop, could slip off the jack, do not tighten the nuts fully until each nut has been tightened twice. Raising the vehicle higher than necessary...your authorized dealer or at a service station. 10. Push down on vehicle and install lug nuts with a torque wrench by turning the jack screw to remove the tire. 6. Secure the tire, jack, and tools in doubt about the correct tightness, have them checked with cone-shaped end toward wheel. Raise ...
Owner's Manual
Page 389
... civil penalties being assessed against you. NOTE: Intentional tampering with emissions control systems can cause hard starting or limit the speed at which is not working properly, replace it with any spark plug wires disconnected or removed, such as when diagnostic testing. • Do not idle the engine for indication of damage...
... civil penalties being assessed against you. NOTE: Intentional tampering with emissions control systems can cause hard starting or limit the speed at which is not working properly, replace it with any spark plug wires disconnected or removed, such as when diagnostic testing. • Do not idle the engine for indication of damage...
Owner's Manual
Page 414
... Top Zipper Cleaner and Lubricant into the zipper slide. MAINTAINING YOUR VEHICLE 413 zipper halves with fresh water and allow to the windows. Adhesives are hard to remove and may be required before the zipper comes free. 6. Several applications may damage the windows.
... Top Zipper Cleaner and Lubricant into the zipper slide. MAINTAINING YOUR VEHICLE 413 zipper halves with fresh water and allow to the windows. Adhesives are hard to remove and may be required before the zipper comes free. 6. Several applications may damage the windows.
Owner's Manual
Page 453
... Glass Cleaning ...410 Gross Axle Weight Rating ...342,345 Gross Vehicle Weight Rating ...342,345 GVWR ...342 Hands-Free Phone (UConnect™) Hard Drive (HDD) ...Hard Top ...Hard Top, Modular ...Hard Top Removal ...85,250,251 ...250 ...125 ...125 ...129 Hazard Warning Flasher ...364 Head Restraints ...89 Head Rests ...89 Headlights Bulb Replacement ...420 Dimmer...
... Glass Cleaning ...410 Gross Axle Weight Rating ...342,345 Gross Vehicle Weight Rating ...342,345 GVWR ...342 Hands-Free Phone (UConnect™) Hard Drive (HDD) ...Hard Top ...Hard Top, Modular ...Hard Top Removal ...85,250,251 ...250 ...125 ...125 ...129 Hazard Warning Flasher ...364 Head Restraints ...89 Head Rests ...89 Headlights Bulb Replacement ...420 Dimmer...
Owner's Manual
Page 465
... Lock Programming Additional TransmittersGeneral InformationBattery ReplacementREMOTE STARTING SYSTEM - IF EQUIPPED Removing The Soft TopInstalling the Soft TopFREEDOM TOP THREE-PIECE MODULAR HARD TOP Front Panel(s) RemovalFront Panel(s) InstallationFront Panel(s) Installation Only (With Rear Hard Top Removed)Rear Hard Top RemovalRear Hard Top InstallationDOOR FRAME Door Frame Removal (Two-Door Models)Door Frame Installation (Two-Door Models)Door...
... Lock Programming Additional TransmittersGeneral InformationBattery ReplacementREMOTE STARTING SYSTEM - IF EQUIPPED Removing The Soft TopInstalling the Soft TopFREEDOM TOP THREE-PIECE MODULAR HARD TOP Front Panel(s) RemovalFront Panel(s) InstallationFront Panel(s) Installation Only (With Rear Hard Top Removed)Rear Hard Top RemovalRear Hard Top InstallationDOOR FRAME Door Frame Removal (Two-Door Models)Door Frame Installation (Two-Door Models)Door...