Owner's Manual
Page 3
Copyright © 2005 Ford Motor Company 3 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Table of Contents Maintenance and Specifications Engine compartment Engine oil Battery Engine Coolant Fuel information Air filter(s) Part numbers Refill capacities Lubricant specifications 323 325 326 330 332 338 352 353 354 357 Accessories ... including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without incurring obligation. Ford may change the contents without notice and without written authorization from...
Copyright © 2005 Ford Motor Company 3 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Table of Contents Maintenance and Specifications Engine compartment Engine oil Battery Engine Coolant Fuel information Air filter(s) Part numbers Refill capacities Lubricant specifications 323 325 326 330 332 338 352 353 354 357 Accessories ... including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without incurring obligation. Ford may change the contents without notice and without written authorization from...
Owner's Manual
Page 9
Introduction Vehicle Symbol Glossary Power Windows Front/Rear Child Safety Door Lock/Unlock Panic Alarm Engine Coolant Power Window Lockout Interior Luggage Compartment Release Symbol Engine Oil Engine Coolant Temperature Battery Do Not Open When Hot Avoid Smoking, Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check fuel cap Low tire warning 9 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Introduction Vehicle Symbol Glossary Power Windows Front/Rear Child Safety Door Lock/Unlock Panic Alarm Engine Coolant Power Window Lockout Interior Luggage Compartment Release Symbol Engine Oil Engine Coolant Temperature Battery Do Not Open When Hot Avoid Smoking, Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check fuel cap Low tire warning 9 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 12
... to remind you to fasten your safety belt. If the light remains on at or near empty (refer to Fuel gauge in this chapter). 12 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Refer to Understanding Your Tire Pressure Monitoring System in the fuel tank is at start up or...): Illuminates when your servicing dealership. Normal braking is still functional unless the brake warning light also is not charging properly. Charging system: Illuminates when the battery is illuminated.
... to remind you to fasten your safety belt. If the light remains on at or near empty (refer to Fuel gauge in this chapter). 12 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Refer to Understanding Your Tire Pressure Monitoring System in the fuel tank is at start up or...): Illuminates when your servicing dealership. Normal braking is still functional unless the brake warning light also is not charging properly. Charging system: Illuminates when the battery is illuminated.
Owner's Manual
Page 16
... (kilometers) of the scale may damage the engine. Press the control again to select Trip 1 and Trip 2 features. H L 16 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Battery voltage gauge: Indicates the battery voltage when the ignition is 0.0 miles. • With Full Message Center Press and release the message center INFO button...
... (kilometers) of the scale may damage the engine. Press the control again to select Trip 1 and Trip 2 features. H L 16 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Battery voltage gauge: Indicates the battery voltage when the ignition is 0.0 miles. • With Full Message Center Press and release the message center INFO button...
Owner's Manual
Page 49
... Seat Entertainment DVD System, simultaneously press the memory preset controls 3 and 5 on the remote control to operate the headphones.) Batteries are supplied with the remote control unit. Wireless headphones Your system is pressed. There is a LED indicator light on the ...illuminate when any control is equipped with 2 sets of wireless headphones. (Two AAA batteries are needed to access the batteries. The remote control unit uses two AAA batteries. Battery replacement Batteries are included. 49 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) VOLUME control Press ...
... Seat Entertainment DVD System, simultaneously press the memory preset controls 3 and 5 on the remote control to operate the headphones.) Batteries are supplied with the remote control unit. Wireless headphones Your system is pressed. There is a LED indicator light on the ...illuminate when any control is equipped with 2 sets of wireless headphones. (Two AAA batteries are needed to access the batteries. The remote control unit uses two AAA batteries. Battery replacement Batteries are included. 49 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) VOLUME control Press ...
Owner's Manual
Page 50
... headphones. Ensure that the line of sight between the headphone and infrared transmitter (mounted on the right-hand earpiece will illuminate. VOL 50 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) P OW ER ON OF F Wireless headphone operation To operate the headphones: ...orientation. Note: Additional 1.9-2.3mhz infrared wireless headphones may be controlled by contacting your head. • Adjust the volume control to preserve battery power. ON OFF Note: The volume level of the wireless headphones can only be purchased by the thumbwheel. The LED light on ...
... headphones. Ensure that the line of sight between the headphone and infrared transmitter (mounted on the right-hand earpiece will illuminate. VOL 50 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) P OW ER ON OF F Wireless headphone operation To operate the headphones: ...orientation. Note: Additional 1.9-2.3mhz infrared wireless headphones may be controlled by contacting your head. • Adjust the volume control to preserve battery power. ON OFF Note: The volume level of the wireless headphones can only be purchased by the thumbwheel. The LED light on ...
Owner's Manual
Page 52
DVD/CD HOT will run the battery down when the disc is inserted into the player. • The DVD player is designed to jam in the radio display. • The DVD player .... and Canada). For a multi-sided disc, the desired play commercially pressed 4.75 in Ford DVD/CD players. This unit is capable of playback of time to cool will remain inactive until it will illuminate in the system. 52 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) When inserting a single sided disc...
DVD/CD HOT will run the battery down when the disc is inserted into the player. • The DVD player is designed to jam in the radio display. • The DVD player .... and Canada). For a multi-sided disc, the desired play commercially pressed 4.75 in Ford DVD/CD players. This unit is capable of playback of time to cool will remain inactive until it will illuminate in the system. 52 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) When inserting a single sided disc...
Owner's Manual
Page 120
...(s) over the vehicle capacity of 12 VDC/180W. To prevent the battery from the rear seats. 0 1 2 3 4 The rear auxiliary power point is not running. The third auxiliary power point on the right rear quarter panel. Equipped with rear climate control 120 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The power...
...(s) over the vehicle capacity of 12 VDC/180W. To prevent the battery from the rear seats. 0 1 2 3 4 The rear auxiliary power point is not running. The third auxiliary power point on the right rear quarter panel. Equipped with rear climate control 120 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The power...
Owner's Manual
Page 130
... replace Step 3 with the vehicle parked in other vehicles as well as for future programming procedures (i.e. It is also suggested that a new battery be placed in view. 3. Do not release the buttons until Step 4 has been completed. Release both the HomeLink and hand-held transmitter ...quicker training and accurate transmission of your visor) while keeping the indicator light in the hand-held transmitters' radio frequency signals.) 130 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Simultaneously press and hold the two outside buttons releasing only when the indicator...
... replace Step 3 with the vehicle parked in other vehicles as well as for future programming procedures (i.e. It is also suggested that a new battery be placed in view. 3. Do not release the buttons until Step 4 has been completed. Release both the HomeLink and hand-held transmitter ...quicker training and accurate transmission of your visor) while keeping the indicator light in the hand-held transmitters' radio frequency signals.) 130 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Simultaneously press and hold the two outside buttons releasing only when the indicator...
Owner's Manual
Page 137
...Remember to CALIBRATION COMPLETE. Distance to start the compass calibration function. 9. DTE is calculated using a running average fuel economy is disconnected. 137 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The running average fuel economy, which is based on your change, press and release... the RESET control. To exit the zone setting mode, and to a factory default value if the battery is reinitialized to "lock in a circle (less than 3 mph [5 km/h]) until the CIRCLE SLOWLY TO CALIBRATE display changes to turn off...
...Remember to CALIBRATION COMPLETE. Distance to start the compass calibration function. 9. DTE is calculated using a running average fuel economy is disconnected. 137 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The running average fuel economy, which is based on your change, press and release... the RESET control. To exit the zone setting mode, and to a factory default value if the battery is reinitialized to "lock in a circle (less than 3 mph [5 km/h]) until the CIRCLE SLOWLY TO CALIBRATE display changes to turn off...
Owner's Manual
Page 153
... or equivalent. Press the SET control on the driver's door panel. 3. Remove the old battery. Refer to local regulations when disposing of transmitter batteries. 4. Snap the two halves back together. 153 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) DO NOT TAKE THE RUBBER COVER .... Locks and Security Deactivating the memory seat feature To deactivate this procedure for the correct orientation of the battery. Repeat this feature: 1. To replace the battery: 1. Do not wipe off any control on the remote transmitter which you would like to ensure that the...
... or equivalent. Press the SET control on the driver's door panel. 3. Remove the old battery. Refer to local regulations when disposing of transmitter batteries. 4. Snap the two halves back together. 153 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) DO NOT TAKE THE RUBBER COVER .... Locks and Security Deactivating the memory seat feature To deactivate this procedure for the correct orientation of the battery. Repeat this feature: 1. To replace the battery: 1. Do not wipe off any control on the remote transmitter which you would like to ensure that the...
Owner's Manual
Page 154
...transmitter has been programmed. • When you would like to remove it from your vehicle's transmitters to confirm programming has been completed. 154 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Again the doors will lock/unlock to your remote transmitters available prior to program... remote transmitters and have them programmed to your vehicle: • Take all (maximum of six - original and/or new) of the battery will not cause the remote transmitter to confirm that the remote transmitter has been programmed. (If more than 20 seconds pass before pressing a...
...transmitter has been programmed. • When you would like to remove it from your vehicle's transmitters to confirm programming has been completed. 154 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Again the doors will lock/unlock to your remote transmitters available prior to program... remote transmitters and have them programmed to your vehicle: • Take all (maximum of six - original and/or new) of the battery will not cause the remote transmitter to confirm that the remote transmitter has been programmed. (If more than 20 seconds pass before pressing a...
Owner's Manual
Page 177
... glass must be open. The system is designed to the Battery Saver feature, the power 3rd row seat will operate for the airbags, crash sensor(s), safety belt pretensioners, front safety belt usage sensors, driver seat position sensor, and indicator lights. 177 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Similar to...
... glass must be open. The system is designed to the Battery Saver feature, the power 3rd row seat will operate for the airbags, crash sensor(s), safety belt pretensioners, front safety belt usage sensors, driver seat position sensor, and indicator lights. 177 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Similar to...
Owner's Manual
Page 241
... monitors tire pressure in each tire to verify that no tire is subject to the following two conditions: (1) This device may not cause harmful 241 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Contained air temperature is stationary over 15 minutes, the sensors go into a low power ...mode to conserve battery life and therefore only transmit about once an hour. For example, if the vehicle is dependent upon several factors such as being the contained air...
... monitors tire pressure in each tire to verify that no tire is subject to the following two conditions: (1) This device may not cause harmful 241 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) Contained air temperature is stationary over 15 minutes, the sensors go into a low power ...mode to conserve battery life and therefore only transmit about once an hour. For example, if the vehicle is dependent upon several factors such as being the contained air...
Owner's Manual
Page 287
... tows, like accidents, are covered (some exclusions apply, such as impound towing or repossession). Ford or Mercury vehicle customers who require roadside assistance, call 1-800-521-4140. 287 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The service is found in the... tow per disablement). U.S. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is separate from the New Vehicle Limited Warranty. Roadside Emergencies...
... tows, like accidents, are covered (some exclusions apply, such as impound towing or repossession). Ford or Mercury vehicle customers who require roadside assistance, call 1-800-521-4140. 287 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus) The service is found in the... tow per disablement). U.S. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is separate from the New Vehicle Limited Warranty. Roadside Emergencies...
Owner's Manual
Page 291
... tab as shown in the illustration, then pull the cover off. If the battery has been disconnected and reconnected, refer to the Battery section of the cover until you and swing it out away from the side and... access to the fuse box, pull the panel toward you hear it click shut. Always disconnect the battery before reconnecting the battery. To reinstall it is seated properly. To reduce the risk of electrical shock, always replace the cover... then push the bottom part of the Maintenance and Specifications chapter. 291 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
... tab as shown in the illustration, then pull the cover off. If the battery has been disconnected and reconnected, refer to the Battery section of the cover until you and swing it out away from the side and... access to the fuse box, pull the panel toward you hear it click shut. Always disconnect the battery before reconnecting the battery. To reinstall it is seated properly. To reduce the risk of electrical shock, always replace the cover... then push the bottom part of the Maintenance and Specifications chapter. 291 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 294
... switch, Rear window defroster relay coil, A/C refrigerant containment switch, A/C de-icing switch, A/C low pressure switch, DEATC control head, DEATC solenoids, DEATC blower control, Trailer tow battery charge relay coil Daytime Running Lamps (DRL) ignition relay coil, Digital Transmission Range Sensor (DTRS) back-up lamps, Trailer tow back-up lamps relay coil... flasher, Electrochromatic mirror, Auxiliary mode motor Restraints Control Module (RCM) 13 10A* 14 10A* 15 5A* 16 17 18 10A* 15A* 10A* 19 10A* 294 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
... switch, Rear window defroster relay coil, A/C refrigerant containment switch, A/C de-icing switch, A/C low pressure switch, DEATC control head, DEATC solenoids, DEATC blower control, Trailer tow battery charge relay coil Daytime Running Lamps (DRL) ignition relay coil, Digital Transmission Range Sensor (DTRS) back-up lamps, Trailer tow back-up lamps relay coil... flasher, Electrochromatic mirror, Auxiliary mode motor Restraints Control Module (RCM) 13 10A* 14 10A* 15 5A* 16 17 18 10A* 15A* 10A* 19 10A* 294 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 295
... Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps), Battery saver relay coil, Battery saver relay power, Heated Positive Crankcase Ventilation (PCV) valve LH low beam Horn relay, Horns Compass module, Reverse sensing system module, Brake shift interlock... coil, SecuriLock transceiver, Heated PCV valve relay coil 21 15A* 22 10A* 23 24 10A* 15A* 25 26 27 10A* 20A* 5A* 28 5A* 295 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
... Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps), Battery saver relay coil, Battery saver relay power, Heated Positive Crankcase Ventilation (PCV) valve LH low beam Horn relay, Horns Compass module, Reverse sensing system module, Brake shift interlock... coil, SecuriLock transceiver, Heated PCV valve relay coil 21 15A* 22 10A* 23 24 10A* 15A* 25 26 27 10A* 20A* 5A* 28 5A* 295 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 297
... RSC module (pump motor) LH 3rd row seat relay, LH 3rd row seat switch, LH 3rd row seat motor Spare Trailer tow battery charge relay, Trailer tow 7-way connector (battery charge) Auxiliary A/C blower relay, Auxiliary A/C blower motor Passenger seat motor switch Driver seat motor switch (non-memory), Memory module, Power memory mirrors... grid, Heated mirrors (Fuse 8) 297 105 106 30A** 30A** 107 108 109 30A** 30A** 30A** 110 111 112 113 114 30A** 50A** 30A** 30A** 40A** 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
... RSC module (pump motor) LH 3rd row seat relay, LH 3rd row seat switch, LH 3rd row seat motor Spare Trailer tow battery charge relay, Trailer tow 7-way connector (battery charge) Auxiliary A/C blower relay, Auxiliary A/C blower motor Passenger seat motor switch Driver seat motor switch (non-memory), Memory module, Power memory mirrors... grid, Heated mirrors (Fuse 8) 297 105 106 30A** 30A** 107 108 109 30A** 30A** 30A** 110 111 112 113 114 30A** 50A** 30A** 30A** 40A** 2005 Expedition (exd) Owners Guide (post-2002-fmt) USA (fus)
Owner's Manual
Page 298
... Fuse 8 (heated mirrors), Rear defrost relay window defroster, Heated outside mirrors, Rear window defroster indicator (climate control head) Trailer tow Trailer tow 7-wire connector battery charge (battery charge) relay Front blower Front blower motor relay Trailer tow park Trailer tow 7-wire and 4-wire lamp relay connectors (park lamps) Foglamp relay Front foglamps...
... Fuse 8 (heated mirrors), Rear defrost relay window defroster, Heated outside mirrors, Rear window defroster indicator (climate control head) Trailer tow Trailer tow 7-wire connector battery charge (battery charge) relay Front blower Front blower motor relay Trailer tow park Trailer tow 7-wire and 4-wire lamp relay connectors (park lamps) Foglamp relay Front foglamps...